-
Alto-Shaam ASC-2E - page 1
W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 USA / CANADA FAX: 262.251.7067 • 800.329.8744 U . S . A . ONLY www.alto-shaam.com M odel: ASC-2E ASC-4E Electronic Control Convection Oven Electric • INSTALLATION • OPERATION • MAINTENANCE MN-28665 ...
-
Alto-Shaam ASC-2E - page 2
i Delivery .................................................................... 1 Unpacking ................................................................ 1 Safety Procedures and Precautions .......................... 2 Installation Site Installation ................................................... 3 Clearance Requirements .................... ...
-
Alto-Shaam ASC-2E - page 3
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 1 DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section l ...
-
Alto-Shaam ASC-2E - page 4
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 2 CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause minor o ...
-
Alto-Shaam ASC-2E - page 5
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 3 INSTALLATION SITE INSTALLATION The Alto-Shaam convection oven must be installed in a location that will permit the oven to function for its intended purpose and to allow adequate clearance for ventilation, proper cleaning, and maintenance. 1. Hood installation is recommended. ...
-
Alto-Shaam ASC-2E - page 6
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 4 INSTALLATION 30-5/8" (778mm) 8" (203mm) CA VITY VENT ELECTRICAL INLET 3-5/32" (80,1mm) 9-15/16" (252mm) ELECTRICAL ENTRANCE 123° 129° 29" (737mm) CA VITY WIDTH 38" (965mm) 31-1/16" (789mm) 4" (102mm) ELECTRICAL INLET 54-5/8" (1387 ...
-
Alto-Shaam ASC-2E - page 7
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 5 INSTALLATION The oven must be mounted on the factory equipped oven legs or on an optional oven stand. Installation on a solid or concrete base that in any way restricts air flow may void the warranty. All clearances for a proper ventilation air supply must be maintained to min ...
-
Alto-Shaam ASC-2E - page 8
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 6 INSTALLATION The oven must be installed by a qualified electrician. This appliance must be branch circuit protected with proper ampacities, in accordance with the wiring diagram located in this manual or in the electrical compartment of the oven. The oven must be properly grou ...
-
Alto-Shaam ASC-2E - page 9
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 7 INSTALLATION STACKING & VENTING ASSEMBLY (2-ASC-2E/STK SHOWN ) CAUTION TO PREVENT PERSONAL INJURY, USE CAUTION WHEN MOVING OR LEVELING THIS APPLIANCE. Note: Actual unit may be different than shown. Part numbers and drawings are subject to change without notice. ...
-
Alto-Shaam ASC-2E - page 10
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 8 INSTALLATION STACKING & VENTING ASSEMBLY (2-ASC-4E/STK 208/240V SHOWN ) After legs or casters have been installed on the bottom oven, place the upper oven on top of lower unit. Align. ITEM DESCRIPTION PART NO. QTY 2 RISER, FLUE ELECTRIC 1004984 1 3 SCREW, #10 SMS .5LG SC-2 ...
-
Alto-Shaam ASC-2E - page 11
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 9 INSTALLATION 8 1 1 7 3 4 2 9 1 2 34-5/16" (876mm) 5 6 2 38" (956mm) OVEN STAND ASSEMBLY ITEM DESCRIPTION PART NO. QTY 1 LEG SUPPORT ASSEMBLY 5003488 2 2 CHANNEL, SUPPORT 1004459 2 3 LEG LG-22185 4 *CASTERS, RIGID CS-25674 2 *CASTERS, SWIVEL W/BRAKE CS-25675 2 4 BRACK ...
-
Alto-Shaam ASC-2E - page 12
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 10 USER SAFETY INFORMATION CAUTION METAL PARTS OF THIS EQUIPMENT BECOME EXTREMELY HOT WHEN IN OPERATION. TO AVOID BURNS, ALWAYS USE HAND PROTECTION WHEN OPERATING THIS APPLIANCE. IN THE EVENT OF A POWER FAILURE: •TURN ALLSWITCHES OFF. •? ...
-
Alto-Shaam ASC-2E - page 13
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 11 PAN/SHELF POSITIONS FOR ASC-4E: The oven includes 6 chrome plated wire shelves with two removable side racks and 12 shelf positions spaced at 1- 3/ 4" (43mm). 1. The best arrangement for broiling, baking cookies and for other baked goods under 2- 1 ...
-
Alto-Shaam ASC-2E - page 14
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 12 1 PREHEAT INDICATOR B LED DISPLAY C UP/DOWN ARROWS D COOK INDICATOR E TEMPERATURE INDICATOR F PROBE INDICATOR G PRESET INDICATOR H COOK KEY I PROBE KEY J TIME KEY K PRESET LOCK KEY L START/STOP KEY M PRESET KEYS 1-7 N CANCEL KEY O FAN SPEED KEY P COOL D ...
-
Alto-Shaam ASC-2E - page 15
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 13 A. PRESS MAIN POWER Q “ON.” • Thedisplay 2 will alternate between last Cook Set Temperature and actual Cavity Temperature. • Theoven willpreheat toprevious Cook temperature, and the PREHEAT Indicat ...
-
Alto-Shaam ASC-2E - page 16
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 14 PROGRAMMING This Alto-Shaam electronic convection oven allows the operator to program up to seven cooking procedures. Each cooking program entered can be preset in any program function to cook by time (or probe, if a probe is included on the oven). Cook ...
-
Alto-Shaam ASC-2E - page 17
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 15 Stop an Operation: Press Start/stop L Key. The oven will remain in a power-on state, and the operation will be cancelled. Press Cook 8 to set procedure again. Adding product after Start: If the door is opened during cook cycle, the heater, fan, and time ...
-
Alto-Shaam ASC-2E - page 18
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 16 CHEF OPERATING TIPS The Alto-Shaam convection oven will provide the best results and longest possible service with the utilization of the following suggestions and guidelines. NOTE : Moisture will escape around the doors when baking products with a heavy moisture content such ...
-
Alto-Shaam ASC-2E - page 19
CARE AND CLEANING ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 17 PROTECTING STAINLESS STEEL SURFACES It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely destroy the protective surface layer of stainless steel. Abrasive pads, steel ...
-
Alto-Shaam ASC-2E - page 20
CARE AND CLEANING ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 18 CLEAN THE OVEN ON A DAILY BASIS 1. After the oven has cooled, remove all detachable items such as wire shelves, side racks, and drip pan. Clean these items separately. 2. Remove any food scraps from shelves, shelf supports, and blower fan wheel. Convection b ...
-
Alto-Shaam ASC-2E - page 21
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 19 TROUBLESHOOTING GUIDE Error Code Description Possible Cause E-10 Cavity air sensor shorted Cavity air sensor reading < 5°F. Verify sensor integrity. See sensor test instructions below. E-11 Cavity air sensor open Cavity air sensor reading > 517°F. Verify senso ...
-
Alto-Shaam ASC-2E - page 22
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 20 Part numbers and drawings are subject to change without notice. FULL ASSEMBLY - ASC-2E 2 3 6 7 9 8 10 1 5 4 11 12 ITEM DESCRIPTION PART NO. QTY 1 PANEL, TOP AND SIDE 1005455 1 2 MOTOR MO-34208 1 3 PANEL OVERLAY PE-26977 1 4 SWITCH, ON/OFF/COOL DOWN SW-34112 1 5 FEET s ...
-
Alto-Shaam ASC-2E - page 23
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 21 Part numbers and drawings are subject to change without notice. CONTROL ASSEMBLY - ASC-2E 5 2 17 4 1 6 7 8 14 13 12 16 10 9 18 3 11 15 ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 HIGH LIMIT BRACKET 1012678 1 10 BLOCK, TERMINAL BK-3597 1 2 HEAT ELEMEN ...
-
Alto-Shaam ASC-2E - page 24
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 22 Part numbers and drawings are subject to change without notice. INTERIOR ASSEMBLY - ASC-2E 1 3 2 5 4 15 16 14 6 55 40 26 21 20 19 18 49 48 51 52 53 54 28 27 12 29 23 46 45 44 43 37 36 35 38 17 34 39 9 25 22 24 12 10 4 42 41 47 33 56 32 31 30 13 11 50 7 8 ...
-
Alto-Shaam ASC-2E - page 25
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 23 Part numbers and drawings are subject to change without notice. ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 BODY SIDE, TOP 1005455 1 29 DOOR LATCH ASC-2 L T -26976 2 2 SCREW, #10 X 1/2 SMS HEX HEAD SLOTTED SC-26520 25 30 WASHER, 1/4", FLAT, 5/8 ...
-
Alto-Shaam ASC-2E - page 26
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 24 Part numbers and drawings are subject to change without notice. 2 3 6 7 9 8 11 13 10 1 5 4 12 FULL ASSEMBLY - ASC-4E *Not Shown ITEM DESCRIPTION PART NO. QTY 1 PANEL OUTER, TOP AND LH 1006623 1 2 PANEL OUTER, RH 1006671 1 3 PANEL OVERLAY PE-26977 1 4 SWITCH, FAN, HI/L ...
-
Alto-Shaam ASC-2E - page 27
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 25 Part numbers and drawings are subject to change without notice. CONTROL ASSEMBLY - ASC-4E 5 2 4 1 6 7 8 14 13 12 16 10 9 3 11 15 ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 HEAT ELEMENTS, REAR 208V eL-34128 1 7 MOTOR RELAY RL-33558 2 240V eL-34125 1 ...
-
Alto-Shaam ASC-2E - page 28
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 26 Part numbers and drawings are subject to change without notice. INTERIOR ASSEMBLY - ASC-4E 42 2 1 40 2 6 5 7 13 13 35 36 26 8 18 21 22 20 19 18 38 36 39 16 29 30 27 28 12 8 17 41 4 3 9 8 10 11 8 23 24 25 15 14 DETAIL A 31 32 34 33 43 ...
-
Alto-Shaam ASC-2E - page 29
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 27 Part numbers and drawings are subject to change without notice. INTERIOR ASSEMBLY - ASC-4E ITEM DESCRIPTION PART NO. QTY 1 COVER, TOP HINGE 1006679 1 2 SCREW ,10-32 X1/2,NF PHIL TRUSS M/S,18-8 SC-2661 4 3 SCREW , 1/4-20 X 1/2" HEX HEAD SC-22729 4 4 BAFFLE ASSEMBL ...
-
Alto-Shaam ASC-2E - page 30
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 28 ...
-
Alto-Shaam ASC-2E - page 31
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 29 ...
-
Alto-Shaam ASC-2E - page 32
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 30 ...
-
Alto-Shaam ASC-2E - page 33
ASC-2E & ASC-4E Electric Convection Ovens - Electronic Control • 31 ...
-
Alto-Shaam ASC-2E - page 34
TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...
¿Tienes una pregunta acerca de Alto-Shaam ASC-2E?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Alto-Shaam ASC-2E, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Alto-Shaam ASC-2E probablemente compartirá una forma de solucionarlo.