-
Carrier 42GW - page 1
42GW • L L O Y D ' S R E G I S T E R Q U A L I T Y A S S U R A N C E I S O 9 0 0 1 INST ALLA TION MANU AL ...
-
Carrier 42GW - page 2
ENGLISH GB - 1 42 GW “Hydronic Global Cassette” Fan Coil Units Contents P a ge Dimensions and weights ........................................................................ 2 T echnical data ........................................................................................ 3 General information .......................................... ...
-
Carrier 42GW - page 3
42 GW GB - 2 Dimensions and weights 42GW 004 008 010 012 016 020 Unit 17.5 19 19 36 38 38 Frame/Grille assembly 333555 813 595 960 298 120 225 280 Ø 150 440 88 160 825 11 2 70 125 825 120 ø150 298 237 52 100 50 160 11 0 90 155 575 158 Ø 70 720 550 515 Ø 25 Ø 25 62 0 Ø 100 150 575 42GW 012 - 016 - 020 kg 42GW 004 - 008 - 010 ...
-
Carrier 42GW - page 4
42 GW GB - 3 ENGLISH T able III: T echnical data of electric heaters (if installed) IMPORT ANT : The electric heater must always be factory installed (mod. 42GWE/H...). The use of other eletric heaters is absolutely prohibited. Failure to follow this safety requirement causes unit damage and voids the warranty . T able I: Nominal data • The power ...
-
Carrier 42GW - page 5
42 GW GB - 4 General Information Unit installation Read this instruction manual thoroughly before starting installation. • This unit complies with the low-voltage (EEC/73/23) and electromagnetic compatibility (EEC/ 89/336) directives. • The installation should be carried out by a qualified installer . • Follow all current national safety code ...
-
Carrier 42GW - page 6
GB - 5 42 GW ENGLISH A void... MAX 3 m MAX 3 m MAX. 200 mm ... any obstruction of the unit air intake or supply grilles. ... exposure to direct sunshine, when the unit is operating in the cooling mode; always use shutters or shades. ... positions too close to heating sources which may damage the unit. ... ascending sections of condensate drain pipi ...
-
Carrier 42GW - page 7
42 GW GB - 6 Installation Prior to installation It is advisable to place the unit as close as possible to the installation site before removing it from the packaging. The grille panel and the control are separately packed for maximum protection. IMPORT ANT : Do not lift the unit by the condensate drain discharge pipe; hold it by its four co ...
-
Carrier 42GW - page 8
GB - 7 42 GW ENGLISH Installation Threaded hangers "T" bar (to be removed) False ceiling Spirit level Suspension brackets mm • T o ensure correct condensate water flow , the drain pipe should have a gradient of 2% without obstructions. Furthermore an odour tr ...
-
Carrier 42GW - page 9
42 GW GB - 8 A B Installation Installation of grille/frame assembly Carefully unpack the assembly and check for damage sustained in transit. Attach the assembly to the unit by using the two hooks. Use the screws supplied to fix the frame in position. Frame pre-hooking support Safety belt Frame fixing screw A. Gasket "A" B. Gas ...
-
Carrier 42GW - page 10
GB - 9 42 GW ENGLISH • The unit control circuit only allows opening of the motorized valve when the fan motor is working. (See wiring diagrams) • When the thermostat asks for cooling, terminal 1 of TB3 (cold water) is supplied with 230V . When it asks for heating, terminal 2 of TB3 (hot water or electric heater) is supplied with 230V . • The ...
-
Carrier 42GW - page 11
42 GW GB - 10 Fan speed H = high speed M = medium speed L = low speed Heat Cool Motorized valve and control 230V valve connection or 230V valve relay connection Instructions for field supplied valves W ater connection • Install valves following manufacturer's instructions; refer to the relevant figures for connection to the unit. ...
-
Carrier 42GW - page 12
GB - 11 42 GW ENGLISH Motorized valve and control • If these connections are not made as described the drain pan condensate may overflow . • V alves should only open when the fan motor is working, i.e. when one of TB1 terminals 1 or 2 or 3 is supplied from TB1 terminal 4. • The optional electric heater (mod. 42GWE) which can only be factory i ...
-
Carrier 42GW - page 13
42 GW GB - 12 IMPORT ANT for units with electric heaters; The unit is equipped with two thermostats: one with automatic reset and one with manual (electric) reset that can be reactivated by switching the power supply off and then on. Connect the power cables to terminal box connectors in accordance with the wiring diagram and tighten firmly . IMPOR ...
-
Carrier 42GW - page 14
42 GW GB - 13 ENGLISH Electric heater supply Valves connection: select the diagram according to the system type 햻 햺 햹 햸 햲 햳 햴 햵 햶 햷 햿 헀 W W R A C C C C Y- G Y- G G G C C B B Y- G Y- G R R R R 12 3 4 5 67 9 1 23 67 81 0 11 5 4 3 2 1 TB3 TB1 HR F1 CR PR PCB IFM PS 1 2 FS 2 1 C2_F C2_M 2 1 3 2 C1_F 1 C1_M 1 2 3 6 5 4 3 2 1 C3_M ...
-
Carrier 42GW - page 15
42 GW GB - 14 Air intake grille Fresh air renewal and conditioned air supply to an adjacent room • Side knockouts allow connection of fresh air inlet ducts and ducts to deliver conditioned air to an adjacent room. • Remove the external prepunched anti-condensate insulation and take away the knockout panels using a ...
-
Carrier 42GW - page 16
GB - 15 42 GW ENGLISH Air flow m 3 /h Available static pressure - Pa Fresh air renewal • The optional supplementary fan for fresh air intake (field supplied) has to be connected to terminal block as per diagrams enclosed. Fan motor operation is parallel to the thermo-electric control valve, and the motor stops when the valve shuts off. • For wi ...
-
Carrier 42GW - page 17
42 GW GB - 16 Maintenance and owner's guide Maintenance Cleaning and maintenance operations must be carried out by specially trained personnel. Before performing any service or maintenance operations, turn OFF the main power switch. T o open the unit grille: T urn the two screws through 90 ° (1/4 turn). Filter cleaning Clean filters in accord ...
-
Carrier 42GW - page 18
L010122H22 - 0405 Via R. Sanzio, 9 - 20058 Villasanta (MI) Italy - T el. 039/3636.1 The manuf acturer reser ves the right to change any product specifications without notice . Order No. 14207-74M10, April 2005. Supersedes Order No. 14207-74M10, December 2004. Printed in Italy ...
¿Tienes una pregunta acerca de Carrier 42GW?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Carrier 42GW, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Carrier 42GW probablemente compartirá una forma de solucionarlo.