-
Wells 1222 1222CA - page 1
PRINTED IN UNITED ST A TES OF AMERICA WELLS BLOOMFIELD , LLC 2 ERIK CIRCLE, P . O. Box 280 V erdi, NV 89439 telephone: 775-689-5707 fax: 775-689-5976 www .wellsbloomfield.com p/n 76580 Rev. G ECN-13387 M712 07 1120 cps 712 OWNERS MANUAL for HOT WATER DISPENSER 2 GALLON MODELS: 1222 1222CA 5 GALLON MODELS: 1225 1226 Includes: Installation Operation ...
-
Wells 1222 1222CA - page 2
712 76580 Owne rs Manual Hot Water Dispenser NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged by skilled personnel before leaving the factory. Upon acceptance of this shipment, the transportation company assumes full responsibility for its safe delivery. IF SHIPMENT ARRIVES DAMAGED: 1. VISI ...
-
Wells 1222 1222CA - page 3
MODEL VOLTS 1ø 50/60Hz WATTS AMPS 1ø POWER SUPPLY CORD 1222 120 1800 15.0 NEMA 5-15P 1222CA k 120 1500 12.8 1225 k 208 4000 19.0 1226 k 240 4000 16.5 NEMA 6-30P 1 TABLE OF CONTENTS SPECIFICATIONS Thank You for purchasing this Wells Bloomfield appliance. Proper installation, professional operation and consistent maintenance of this appliance will ...
-
Wells 1222 1222CA - page 4
FEATURES AND OPERATING CONTROLS 2 712 76580 Owne rs Manual Hot Water Dispenser ...
-
Wells 1222 1222CA - page 5
PRECAUTIONS AND GENERAL INFORMATION 3 WARNING: ELECTRIC SHOCK HAZA RD All servicing requiring access to no n-in sulat ed components must be performed by qualified service personnel. Do not open any access panels which requi re the use of tools. Failure to heed this warnin g can result in electri cal shock. WARNING: INJURY HAZARD All installation pr ...
-
Wells 1222 1222CA - page 6
INSTALLATION 4 READ THIS CAREFULL Y BEFORE ST ARTING THE I NST ALLA TION REFER TO EXPLODED VIEWS PAGE 14 FOR COMPONENT NAMES/NUMBERS. Unpack the unit. Inspect all component s for completeness and condition. Ensure that all packing materials have bee n remove d from the unit. LEVELING THE UNIT Two Gallon Dispenser is NOT provided with adju stable le ...
-
Wells 1222 1222CA - page 7
INSTALLATION (continued) 5 NOTE: This equipment m ust be installed to comply with applicable federal, state and local plumbing codes and ordinances. CAUTION: SHOCK HAZARD Dispenser must be prope rly grounded to prevent possible shock hazard. DO NOT assume a plumbing line wil l provide such a ground. Electrical shock will cause death or serious inju ...
-
Wells 1222 1222CA - page 8
OPERATION 6 Fig. 3 Dispenser Operation Diag ram A. START-UP For initial start-up, or if the disp en ser has not been used for an extended period of time: • Be sure the water supply is properly connected and the water supply valve is turned ON . • Be sure the WATER TANK IS FILLED. IMPORTANT: Fill the water tank befor e energizing tank heater: 1. ...
-
Wells 1222 1222CA - page 9
CLEANING INSTRUCTIONS PROCEDURE: Clean Hot Water Dispenser PRECAUTIONS: Disconnect di spenser from electric power. Allow dispenser to cool. FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush 1. Disconnect dispe nser from electric power. Allow to cool before cleaning. 2. Wipe exterior of dispenser with a soft cle an clo ...
-
Wells 1222 1222CA - page 10
TROUBLESHOOTING SUGGESTIONS SUGGESTED REMEDY Check power sup ply cord Check / reset cir cuit breaker Press switch to "ON" Adjust thermostat for desired temperature Allow to cool hi-limit will self- reset Examine wiring & connectors, controller, power board an d heating element Repair/replace as neede d Turn water supply ON Clean strai ...
-
Wells 1222 1222CA - page 11
SERVICING INSTRUCTIONS CAUTION: SHOCK HAZARD Opening access panels on this dispenser may expose uninsulated electrical components. Disconnect dispenser from electrical power before removing any panel. ACCESS PANELS REAR PANEL: Remove rear panel to access hot water tank, the rmostat, heating elements, tubing, water level co ntrol and plumbing connec ...
-
Wells 1222 1222CA - page 12
SERVICING INSTRUCTIONS (continued) TEMPERATURE ADJUSTMENT Check temperature at discharge of faucet. Remove thermostat access butt on plug to ac cess thermostat. Turn thermostat shaft clockwis e to increase temperature. REMOVE TANK LID ASSEMBLY Unplug dispense r or turn circuit brea ker OFF . Turn OFF water supply. Remove rear panel. Disconnect fill ...
-
Wells 1222 1222CA - page 13
SERVICING INSTRUCTIONS (continued) IMPORTANT: When replacing heating element, also replace seal gaskets. NOTE: Any abrasion or roughness on the flat end of the seat cup will require replacing the seat cup: REPLACE HEATING ELEMENT Remove tank lid assembly as detailed on page 10. Remove two hex nuts holding element to cover. Pull element from mountin ...
-
Wells 1222 1222CA - page 14
CAUTION: CHEMICAL BURN HAZARD Deliming chemicals may be caustic. Wear appropriate protective gloves and goggles during this procedure. Ne ver siphon deliming chemicals or solutions by mouth. This operation should only be performed by qualified and experienced service personnel. IMPORTANT: DO NOT spill, splash or pour water or deli ming solution int ...
-
Wells 1222 1222CA - page 15
EXPLODED VIEWS AND PARTS LISTS 13 SERVICE KITS FAUCET REPAIR KITS 84686 Faucet & Shank Complete 8700-25 L Seat Cup (only) SOLENOID REPAIR KITS 83612 Solenoid Complete, Single 120V (1222 , 1222CA) 83760 Solenoid Complete, Single 240V (1225 , 1226) 85218 Inlet Fitting Kit (includes cap, fitting, washer & screen) 85219 Inlet Strainer (only) 71 ...
-
Wells 1222 1222CA - page 16
EXPLODED VIEW & PARTS LIST 14 NOTE: Model 1225/1226 shown. Model 1222/12 22 CA is similar. 712 76580 Owne rs Manual Hot Water Dispenser 38 39 37 1 34 27 2 REQD 36 28 35 31 29 40 18 26 24 22 21 21 20 2 REQD 19 17 16 15 14 13 12 11 10 9 7 8 6 5 4 3 30 2 23 25 ...
-
Wells 1222 1222CA - page 17
EXPLODED VIEW & PARTS LIST (continued) 15 ITEM DESCRIPTION 1222 P/N 1222CA P/N 1225 P/N 1226 P/N 1 WRAP, BODY 2 TANK ASSY 3 PANEL, TOP BACK 4 PLUG, BUTTON 7/8" 8705-36 8705-36 8705-36 8705-36 5 SUPPORT, TANK 6 LIGHT, PIL OT GREEN 8718-31 8718-31 8718-31 8718-31 7 LABEL, HW DISPENSER 8 LIGHT, PILOT AMBER 61178 61178 61178 61178 9 CONTROL, L ...
-
Wells 1222 1222CA - page 18
WIRING DIAGRAM 16 2-GALLON MODELS 1222 and 12 22CA 712 76580 Owne rs Manual Hot Water Dispenser 7 7 9 10 12 13 6 8 3 2 5 4 11 1 BLACK WHITE GREEN WHITE WHITE WHITE GREEN WHITE WHITE WHITE BLACK BLACK BLACK BLACK BLACK BLACK BLACK HOT W A TER READY LIGHT (AMBER) POWER LIGHT (GREEN) THERMOST A T W A TER LEVEL CONTROL BOARD W A TER LEVEL PROBE HEA TIN ...
-
Wells 1222 1222CA - page 19
WIRING DIAGRAM (continued) 17 5-GALLON MODELS 1225 and 12 26 712 76580 Owne rs Manual Hot Water Dispenser MODEL 1225 and 1226 W A TER LEVEL CONTROL BOARD MAX COMM COMM N.O. N.C. INPUT BLACK WHITE GREEN WHITE WHITE WHITE RED 12 ga. RED 12 ga. WHITE GREEN WHITE BLACK 12 ga. BLACK 12 ga. BLACK BLACK BLACK BLACK BLACK BLACK BLACK HOT W A TER READY LIGH ...
-
Wells 1222 1222CA - page 20
Genuine Parts Protect - YOU - All - W ays SER VICE TRAINING - QUALITY SER VICE SER VICE TRAINING - QUALITY SERVICE CUSTOMER SA TISF ACTION CUSTOMER SA TISF ACTION Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association Commercial Food Equipment Service Association PRINTED IN UNITED ST A TES OF AMERICA WELLS BLOOMFIELD ...
¿Tienes una pregunta acerca de Wells 1222 1222CA?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Wells 1222 1222CA, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Wells 1222 1222CA probablemente compartirá una forma de solucionarlo.