-
FMI MF42OPE - page 1
For more information, visit www .fmiproducts.com VENTED GAS LOG APPLIANCE OWNER’S OPERA TION AND INST ALLA TION MANU AL WHEN USED AS AN OUTDOOR APPLIANCE WHEN USED AS INDOOR VENTED APPLIANCE REMO TE-READ y LOG SET AND BURNER Sy STEM MODELS MF42ONE, MF42OPE, MF48ONE, MF48OPE MF42 MODELS MA Y BE USED WITH LMF42-SC LOGS ONL Y MF48 MODELS MA Y BE USE ...
-
FMI MF42OPE - page 2
www .fmipr oducts.com 125636-01A 2 SAFETy DAN GER: Car bon m ono xide poi son ing m ay lead to death! Carbon Monoxide Poisoning: Early signs of carbon mon- oxide poisoning resemble the u, with headaches, dizziness or nausea. If you have these signs, the replace may not be working properly. Get fresh air at once! Have replace ser - viced. S ...
-
FMI MF42OPE - page 3
www .fmipr oducts.com 125636-01A 3 SAFETy Continued 1. This appliance is only for use with the type of gas indic ated on the rat ing plate. This ap plianc e is not convert ible for use with other gases. 2. Do not place propane/LP supply tank(s) inside any struc - ture. Locate propane/LP supply tank(s) outdoors (propane/ LP units only). 3. If you sm ...
-
FMI MF42OPE - page 4
www .fmipr oducts.com 125636-01A 4 LOCAL CODES Install and use appliance with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code, ANSI Z223.1/NFP A 54 *. *Available from: American National Standards Institute, Inc. 1430 Broadway New Y ork, NY 10018 National Fire Protection Association, ...
-
FMI MF42OPE - page 5
www .fmipr oducts.com 125636-01A 5 LOG SIZING REqUIREMENTS Log Size Minimum Firebox Size Height Depth Front Width Rear* Width 42" 29" 15.5" 39" 26.75" 48" 29" 20" 47" 33" Carefully follow the instructions below . This will ensure safe installation into a masonry , UL127-listed manufactured re - p ...
-
FMI MF42OPE - page 6
www .fmipr oducts.com 125636-01A 6 NOTICE: Surface temperatures of adjacent walls and mantels become hot during opera - tio n. Wall s and man te ls abov e th e re box may bec ome ho t to the tou ch . If ins ta ll ed p rop er ly , th es e tem pera tu res me et the re qu ir em en t of th e nat ional prod uc t sta nd ard . Fol lo w all min imu m cl ...
-
FMI MF42OPE - page 7
www .fmipr oducts.com 125636-01A 7 INST ALLA TION Continued INST ALLING APPLIANCE BASE ASSEMBL y Area of V arious Standard Round Flues Diameter Area 5" 20 sq. inches 6" 29 sq. inches 7" 39 sq. inches 8" 51 sq. inches Chimney Height Minimum Permanent Flue Opening 6' to 15' 39 sq. inches 15' to 30' 29 sq. inche ...
-
FMI MF42OPE - page 8
www .fmipr oducts.com 125636-01A 8 optional equipment shutoff valve from your dealer . For propane/LP units, the installer must supply an external regulator . The external regulator will reduce incoming gas pressure. Y ou must reduce incoming gas pressure to be - tween 1 1" and 14" of water . If you do not reduce incoming gas pressure , a ...
-
FMI MF42OPE - page 9
www .fmipr oducts.com 125636-01A 9 INST ALLA TION Continued We recommend that you install a sediment trap in supply line as shown in Figure 12. Locate sediment trap where it is within reach for cle aning. Install in pip ing system between fuel supply and appliance. Locate sediment trap where trapped matter is not likely to freeze. A sediment trap t ...
-
FMI MF42OPE - page 10
www .fmipr oducts.com 125636-01A 10 INST ALLING BA TTERIES IN HAND HELD REMOTE CONTROL AND BA TTERY P ACK Installing Batteries in Battery pack 1. Remove access cover on battery pack. 2. Install 4 AA batteries, included, into battery pack following positive and negative directions. 3. Replace access cover on battery pack. 4. Place battery pack next ...
-
FMI MF42OPE - page 11
www .fmipr oducts.com 125636-01A 11 INST ALLA TION Continued Figure 17 - Installing Right Front Log Figure 17A - Installing Right Front Log, Top V iew Burner T ube Grate Finger Right Front Log (D-019 or D027) Round T ube Burner Grate Finger Figure 18 - Installing Back Left Log Figure 17B - Installing Right Front Log, T op View Figure 17C - Installi ...
-
FMI MF42OPE - page 12
www .fmipr oducts.com 125636-01A 12 INST ALLA TION Continued Figure 18A - Installing Back Left Log Figure 18B - Installing Back Left Log (D-018) Rear V iew Figure 19 - Installing Front Left Log Grate Fingers Front Left Log (D-017 or D025) Burner T ube Log Notch Find the charred log (D-020). See Figures 20, 20A, and 4. 20B. The log has a slot in the ...
-
FMI MF42OPE - page 13
www .fmipr oducts.com 125636-01A 13 INST ALLA TION Continued Find the middle split log (LMF42-SC: D-021 or LMF48-SC: 5. D028). See Figures 21 and 21A. The split side of the log faces forward. The log has a notch that ts around the bur ner tub e on the righ t side . The lef t si de of the bur ne r tube ts into the notch on the back side of thi ...
-
FMI MF42OPE - page 14
www .fmipr oducts.com 125636-01A 14 INST ALLA TION Continued Figure 24 - Installing Back T op Log and Final Assembly Figure 24A - Installing Back Top Log, T op V iew Right Split Crossover Log (D-022) Back T op Log (D-023 or D029) Find the back top log (LMF-SC: D-023 or LMF48-SC: 8. D029).See Figures 24, and 24A. The left end of this log has a round ...
-
FMI MF42OPE - page 15
www .fmipr oducts.com 125636-01A 15 OPERA TION Continued Figure 25 - Turning Equipment Shutof f Valve to the OFF Position MAIN IN OUT PILOT ADJ PILOT Equipment Shutoff V alve Incoming Gas Line GAS CONTROL MODULE Sy STEM REMOTE CONTROL FEA TURE The module has a built in remote control receiver that allows the user to program the remote transmitter a ...
-
FMI MF42OPE - page 16
www .fmipr oducts.com 125636-01A 16 CLEANING AND MAINTENANCE Continued INSPECTING B URNERS Continued Figure 30 - Incorrect Burner Flame Pattern Dark Orange Flames CLEANING AND MAINTENANCE W ARNING: T urn off appliance and let cool before cleaning. CAUTION: Y ou must keep control areas, burners and cir culating air pas sageways of ap - pliance clean ...
-
FMI MF42OPE - page 17
www .fmipr oducts.com 125636-01A 17 WIRING DIAGRAM Orange Orange Orange Re d Brow n Black Solenoid White Brow n Brow n Green Ignitor Pilot I S A UX AF-5000MOD AF-4000 AF-4000B/P Co ntrol Module Black Black Optional DC Battery Back-up Re d SWI SWI (GND) Black Re d HI/L O Main Black These wires are not used on this application ...
-
FMI MF42OPE - page 18
www .fmipr oducts.com 125636-01A 18 TROUBLESHOO TING W ARNING: T urn off appliance and let cool before servicing. Only a qualied service person should service and repair appliance. Note: All troubleshooting items are listed in order of operation. POSSIBLE CAUSE 1. Ignitor electrod e not conn ected to ignitor cable 2. Ignitor cable pinched or wet ...
-
FMI MF42OPE - page 19
www .fmipr oducts.com 125636-01A 19 POSSIBLE CAUSE 1. Manifold pressure is too low 2. Burner orice clogged 1. Burner orice is clogged or dam - aged 2. Damaged burner 1 . Residues from manufacturing processes and logs curing 1. Air in gas line 2. Air passageways on appliance blocked 3. Dirty or partially clogged burner orice. 1. When heated ...
-
FMI MF42OPE - page 20
www .fmipr oducts.com 125636-01A 20 TROUBLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier ’ s instruc - tions. ? ...
-
FMI MF42OPE - page 21
www .fmipr oducts.com 125636-01A 21 ACCESSORIES Purchas e these appl iance accessorie s from your local dealer . If they can not supply these accessories, call FMI PROD - UCTS, LLC at 1-866-328-4537 for referral information. Y ou can also write to the address listed on the back page of this manual. FIREPLACE HOOD Black - GA6050 Antique Brass - GA60 ...
-
FMI MF42OPE - page 22
www .fmipr oducts.com 125636-01A 22 P ARTS REMOTE-READY CONTROL MODELS MF42ONE, MF42OPE, MF48ONE, MF48OPE 1 2 4 5 6 7 8 9 10 11 12 13 15 16 18 19 20 21 23 24 25 26 22 17 14 8 3 ...
-
FMI MF42OPE - page 23
www .fmipr oducts.com 125636-01A 23 P ARTS REMOTE-READY MODELS MF42ONE, MF42OPE, MF48ONE, MF48OPE This list contains replaceable parts used in your appliance. When ordering parts, follow the instructions listed under Replace- ment Parts on page 25 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 125593-01 Burner Stainless MF • • • • 1 ...
-
FMI MF42OPE - page 24
www .fmipr oducts.com 125636-01A 24 P ARTS LOG SETS FOR MODELS MF42ONE, MF42OPE, MF48ONE, MF48OPE This list contains replaceable parts used in your appliance. When ordering parts, follow the instructions listed under Replacement Parts on page 25 of this manual. Each log includes a reference number . The rst number indicates the order it is place ...
-
FMI MF42OPE - page 25
www .fmipr oducts.com 125636-01A 25 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . Contact authorized dealers of this product. If they can’t supply original replacement part(s), call FMI PRODUCTS, LLC at 1-866-328-4537. When calling, have ready: • your n ...
-
FMI MF42OPE - page 26
www .fmipr oducts.com 125636-01A 26 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ________________________________________ ...
-
FMI MF42OPE - page 27
www .fmipr oducts.com 125636-01A 27 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ________________________________________ ...
-
FMI MF42OPE - page 28
125636-01 Rev . A 10/10 WARRANTy kEEP THIS WARRANTy FMI PRODUCTS, LL C LIMITED WARRANTIES New Products Standard Warranty: F M I P R O DU C TS , LL C w ar r an t s t h i s n e w p r od u ct a n d a n y p a rt s th e re o f t o b e f r e e f r om d ef e ct s i n m a te r ia l a nd workmanship for a period of four (4) years from the date of rst pur ...
¿Tienes una pregunta acerca de FMI MF42OPE?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con FMI MF42OPE, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con FMI MF42OPE probablemente compartirá una forma de solucionarlo.