-
Harmar Mobility AL055 - page 1
1 Inside S tyle Lif t AL200 / AL400 / AL055 Installation Guide & Owners Manual A L 200 Manual Rotation L ift A L400 Fully Po wered Lift AL055 Economy Lift Congratulations on your new lift purchase. The Universal Insi de Lift line is o ne of the easiest and most trouble free ways to transport your scooter or power c hair. This manual is written ...
-
Harmar Mobility AL055 - page 2
2 Section 1 - Unpacking the Lift Your Fully Powered Inside Lift was factory pre-assembl ed to require little assembly before installation. AL200 / AL400 Box contents should include: Package Check List Hard w are Package Lifting Arm (# 1) Contents include: Standard Post (# 2) Vehicle Wiring Harness (# 7) Base (# 3) Hand Control (#8) Strap & Hook ...
-
Harmar Mobility AL055 - page 3
3 Section 2 - Vehicle Prep aration The Inside Lift has been designed w ith the s hortest height and smallest footprint requirements to allo w m aximum room for the loading and unloading of y our scooter or pow er chair. If there is 30” of headroom and room for the scooter or chair in the vehicle, then our lift should be able to be installed and o ...
-
Harmar Mobility AL055 - page 4
4 Inst alling the V ehicle Wiring Harness Important Note: IM PROPER WIRING IS THE #1 CAUSE OF PROBLEMS IN THE OPERATION OF A VEHICLE LIFT. FOLLOW THE WI RING INSTRUCTIONS CA REFULLY Located in the hardware package is the vehicle wiring harness. The harness is manufactured to, and complies with the SAE J1128 requirements. The w ire har- ness is appr ...
-
Harmar Mobility AL055 - page 5
5 ...
-
Harmar Mobility AL055 - page 6
6 Section 4 - Installing th e A L200 Lift • You shou ld hav e established a mounting position for the lift during the “trial fit” as describ ed in Section #2 of this manual. If not, it is recommended that you go through that procedu r e. • Mount the lift in the location determined during the “trial fi t” in the vehicle. The Leg Extensio ...
-
Harmar Mobility AL055 - page 7
7 Section 4 - Operating the A L200 Lift Trunk A pplications: Operational Guidelines: • Inspect the Lifting Strap prior to each use. Contact yo ur distributor if it shows signs of w ear or f raying. • Do not operate this lift until you dealer has satisfactorily instructed you in the proper operation of this lift. • Always mak e sure the vehicl ...
-
Harmar Mobility AL055 - page 8
8 Section 4 - Operating the A L200 Lift continued Trunk A pplications • If preparations needed to be made to secure the scoote r or ch air for transp ort, such as parking brakes or wh eel chocks, do these now. Dealers should instruct operators on how, if necessary, to secure the scoo t er or chair for transport. Close the trunk and you are ready ...
-
Harmar Mobility AL055 - page 9
9 Section 4 - Operating the A L200 Lift Enclosed Vehicl e A pplications: Operational Guidelines: • Inspect the Lifting Strap prior to each use. Contact yo ur distributor if it shows signs of w ear or f raying. • Do not operate this lift until you dealer has satisfactorily instructed you in the proper operation of this lift. • Always mak e sur ...
-
Harmar Mobility AL055 - page 10
10 Section 4 - Operating the A L200 Lift continued Enclosed Vehicl e A ppli cations Unloading Your Scooter or Power Chair —Enclose d Vehicle A pplications • Undo any prepara ti ons made to secure th e scooter or powe r chair f or transp ort. • Raise the scooter or chair by pressing the UP bu tt on on the Hand Control until the tires are high ...
-
Harmar Mobility AL055 - page 11
11 ...
-
Harmar Mobility AL055 - page 12
12 Section 5 - Installing the AL40 0 Full y Powered Lift • You should hav e establishe d a mounting po sition for the lif t dur ing the “trial fit” as described in Section #2 of this manual. If not, it is recommended that yo u go through that procedure. Note: The Base should be mounted as far to the rea r corner of the vehicle as possible in ...
-
Harmar Mobility AL055 - page 13
13 Section 5 - Installing the AL400 Continued IMPORTANT! Make sure that the Post is seated completely down into the w hite Po wer Base bushing. If there is any wobble to the post, rotate it in the base bushing un til it drops completely onto the pin located in the bott om of the base unit. DO NOT ATTEMPT TO OPERAT E THE LIFT IF THE POST IS NO T SEC ...
-
Harmar Mobility AL055 - page 14
14 Section 5 - Operating the A L400 Lift Operational Guidelines: • Inspect the Lifting Strap prior to each use. Contact yo ur distributor if it shows signs of w ear or f raying. • Do not operate this lift until you dealer has satisfactorily instructed you in the proper operation of this lift. • Always mak e sure the vehicle’s parking brak e ...
-
Harmar Mobility AL055 - page 15
15 Section 5 - Operating the AL400 Lift continued Unloading Your Scooter or Power Chair • Undo any prepara ti ons made to secure the scoo ter or pow er chair f or transport. • Raise the scooter or chair by pre s sing the UP button on the Hand Control until the tires are high en o ugh to clear the highest obstacle, usuall y the door sill or tail ...
-
Harmar Mobility AL055 - page 16
16 ...
-
Harmar Mobility AL055 - page 17
17 Section 6 - Installing the AL055 Economy Lift • You should hav e establishe d a mounting po sition for the lif t dur ing the “trial fit” as described in Section #2 of this manual. If not, it is recommended that yo u go through that procedure. • Mount the lift in the location determined du ring the “trial fit” in the vehicle. Mark the ...
-
Harmar Mobility AL055 - page 18
18 Section 6 - Operating the AL055 Econ om y Lift Trunk A pplications: Operational Guidelines: • Inspect the Lifting Strap prior to each use. Contact y our distributor if it shows signs of wear or fra y ing . • Do not oper ate this lift u ntil you dealer has satis factoril y instructed you in the prope r operation of this lift. • Always make ...
-
Harmar Mobility AL055 - page 19
19 Section 6 - Operating the AL055 Lift continued Trunk A pplications: • If preparations needed to be made to secure the scooter or chair for transpo rt, such as parking bra kes or wheel chocks, do these now. Dealers should instruct operators on how , if necessary , to secure the scooter or chair f or transport. Close the tru nk and you are rea d ...
-
Harmar Mobility AL055 - page 20
20 Section 6 - Operating the AL055 Lift continu ed Enclosed Vehicle A ppli cations: Operational Guidelines: • Inspect the Lifting Strap prior to each use. Contact y our distributor if it shows signs of wear or fra y ing . • Do not oper ate this lift u ntil you dealer has satis factoril y instructed you in the prope r operation of this lift. • ...
-
Harmar Mobility AL055 - page 21
21 Section 6 - Operating the Lift continued Enclosed Ve hicle Applic ations: Unloading Your Scooter—Enclo sed Vehicle Applications • Undo any prepara ti ons made to secure the scoo ter or pow er chair f or transport. • Raise the scooter or chair by pre s sing the UP button on the Hand Control until the tires are hig h enough to clear the high ...
-
Harmar Mobility AL055 - page 22
22 ...
-
Harmar Mobility AL055 - page 23
23 Section 7 - Safety & Maintenance SAFETY : • Caution: Do not operate this lift until y our dealer has satisf ac torily instructed y ou in the proper operation of the lift. • Your Harmar Inside Lift has been engine ered and designed for years of trouble free use. Although, with every- day use, some parts may become loose or w orn. IMPORT A ...
-
Harmar Mobility AL055 - page 24
24 TROUBLESHOOTING: PROBLEM : The lift will not operate or operates sl ow l y. Possible Causes : Bad Ground —Verify the ground end of the Vehicle Ha rness is touching the vehicle fr a m e in an area that is free o f paint and corrosion. If the lift does no t have a good ground, the motor w ill n ot run under full power and will affect the lifting ...
¿Tienes una pregunta acerca de Harmar Mobility AL055?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Harmar Mobility AL055, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Harmar Mobility AL055 probablemente compartirá una forma de solucionarlo.