-
Viper Hayward 5500 - page 1
High P erformance Automatic P ool Cleaner Owner's Guide Model 5500 • Important Safety Instructions • Installation Instructions • Parts List • Consumer Product Safety Registration Card • Wa rranty Attention Installer: This manual contains important information about the installation, operation, and safe use of this automa tic pool cle ...
-
Viper Hayward 5500 - page 2
1 Use Only Genuine Hayward Replacement Parts. Important Safety Instructions Warning Read this entire Owner’ s Guide before installing the Viper c leaner . F ailure to follow safety warnings and owner’ s guide instructions can result in severe injur y , death or property damage. For additional free copies of the Owner’ s Guide you can download ...
-
Viper Hayward 5500 - page 3
2 Use Only Genuine Hayward Replacement Parts. Contents Important Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Disclaimer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . ...
-
Viper Hayward 5500 - page 4
3 Use Only Genuine Hayward Replacement Parts. Introduction Congratulations on your purchase of the Hayward Viper Automatic Pool Cleaner . The Hayward Viper is designed to clean your pool faster than other automa tic pool cleaners so you and your family spend your time enjoying your pool, not maintaining it. This revolutionary design offers the foll ...
-
Viper Hayward 5500 - page 5
4 Use Only Genuine Hayward Replacement Parts. Principle P arts Warning - Risk of Injury Read this entire Owner’ s Guide before installing the Viper cleaner . 1. Installation of the Booster Pump by a licensed electrician should precede installation of the Viper Cleaner . 2. Lay the parts on the ground and check against the illustration below . 3. ...
-
Viper Hayward 5500 - page 6
5 Use Only Genuine Hayward Replacement Parts. Preparing the P ool The Viper c leaner should not be used to clean the pool for spring start-up until the following steps have been taken: 1. Clear the pool of any large objects that might interfere with the cleaner’ s operation. 2. Check to see that the water is at the recommended level. 3. Check the ...
-
Viper Hayward 5500 - page 7
6 Use Only Genuine Hayward Replacement Parts. Connecting The V iper Cleaner T o P ool Warning - Risk of Injury The Booster Pump must be OFF when connecting or disconnecting cleaner or hose. Caution - Risk of Equipment Damage The filter pump must always be run to clear air from the system before turning on the Booster Pump. Never run the Booster Pum ...
-
Viper Hayward 5500 - page 8
7 Use Only Genuine Hayward Replacement Parts. 5' 5' 18" 18" 18" 18" IMPORT ANT : Read Carefully - Don't Cut the Wrong End of the Hose! Note: After measuring the hose following the steps below , if you need to reduce the hose length you will cut the hose from the end with the W all Quick Connect. 1. Insert the Wall ...
-
Viper Hayward 5500 - page 9
8 Use Only Genuine Hayward Replacement Parts. Mender Nut Connections Note: It is easier to install the swivels when the hose and swivels are wet. 1. Slide Mender Nut on to end of the swivel with small end of nut towards pressure hose. 2. Insert end of swivel into Pressure Hose so end of Hose is over reduced diameter of swivel. 3. Slide Mender Nut b ...
-
Viper Hayward 5500 - page 10
9 Use Only Genuine Hayward Replacement Parts. Large Capacity Debris Bag Attaching Debris Bag (Part B, page 4) 1. Place forward edge of Bag Holder under tab to right of Vacuum T ube. 2. With Bag Holder flat on Deck, slide Bag Holder to the left until it locks in place. Removing Debris Bag 1. Push down Locking T ab on Deck. 2. Slide Bag Holder to rig ...
-
Viper Hayward 5500 - page 11
10 Use Only Genuine Hayward Replacement Parts. Operating the V iper Cleaner 1. Be sure all filtration system valves are open and supplying water to the Booster Pump. 2. Be sure valves to and from the Booster Pump and dedicated return line are fully opened. 3. a) The Viper Cleaner and its Booster Pump can onl y operate when the pool's filter pu ...
-
Viper Hayward 5500 - page 12
11 Use Only Genuine Hayward Replacement Parts. Movement When the Viper cleaner is operating properly it will randomly travel around the bottom and sides of the pool. Spin-Out The cleaner will periodically stop and rotate clockwise in order to provide better pool coverage and to escape from corners and other obstacles. If the cleaner is momentarily ...
-
Viper Hayward 5500 - page 13
12 Use Only Genuine Hayward Replacement Parts. Cleaner Adjustments Warning - Risk of Injury T urn the Booster Pump and Filtration Pump OFF before making adjustments to the cleaner . Always make adjustments outside of the pool. Failure to do so may cause injury . Changing Spin-Out Frequency • In most pools it will not be necessary to change the Sp ...
-
Viper Hayward 5500 - page 14
13 Use Only Genuine Hayward Replacement Parts. Adjusting Sweep Hose P ower • In most pools it will not be necessary to adjust the Sweep Hose power . • Observe the Viper cleaner operating in the pool. The Sweep Hose should move in a slow , undulating (snake-like) motion. • Sweep Hose Not Moving: if the sweep hose does not move side-to-side and ...
-
Viper Hayward 5500 - page 15
14 Use Only Genuine Hayward Replacement Parts. Maintenance Removing the Viper Cleaner From The P ool Warning - Risk of Injury The Filtration Pump and Booster Pump must be OFF when connecting or disconnecting cleaner or hose. 1. T urn the Booster Pump and Filtration Pump OFF . If you will not be replacing the cleaner before the next Booster Pump tim ...
-
Viper Hayward 5500 - page 16
15 Use Only Genuine Hayward Replacement Parts. Replacing P arts Some parts will wear with normal use. T o insure the high quality performance, insist on Genuine Hayward replacement parts (using non-Hayward replacement parts will Void the V iper Cleaner’ s Warranty). The following parts are user replaceable and subject to normal wear and tear . 1. ...
-
Viper Hayward 5500 - page 17
16 Use Only Genuine Hayward Replacement Parts. T roubleshooting Problem Cause Solution Slow or no Forward Movement Low or no Wa t er Pressure Check Filtration and Booster Pumps, Val ves, Cleaner Connections. Check Cleaner Pressure. (Page 10) No Spin-Out Cam Not Properly Installed Open Cam Cap. Check that Cam and Thumbscrew are Properly Instal led. ...
-
Viper Hayward 5500 - page 18
17 Use Only Genuine Hayward Replacement Parts. Booster Pump Booster Pump T ypical Installation From Pool T o Pool Filtration Pump Pool Filter Heater T o Spa Plumbing Options Chlorinator Solar System Booster Pump (sold separately) Viper Minimum of 3 Feet Ref. No. P art No. Description 1 AX5060M Motor (3/4 HP 60 cycles) 2a AX5060B Seal Plate (Prior t ...
-
Viper Hayward 5500 - page 19
18 Use Only Genuine Hayward Replacement Parts. V iper P arts Diagram Ref. No. P art No. Description 1 AX5500T A Deck (with Wing and Cam Cap) 2 AX5501F Cam Cap 3 AX5003M Cams (3-pack) 4 AX5500GA Gearbox (with Cams, Hose, and Ties) 5 AX5010D4 Screws (5-pack) 6 AX5009C Front Wheel (with Shaft and Bearings) 7 AX5000D Rollers (7-pack with Bearing) 8 AX5 ...
-
Viper Hayward 5500 - page 20
19 Use Only Genuine Hayward Replacement Parts. Important! Retain Y our Bill of Sale For Proof of Warranty Eligibility T o the Original Retail Consumer / Purchaser (the “PURCHASER”) of the Hayward Viper Automatic Pool Cleaner (the “CLEANER”). Hayward Pool Products, Inc. (“HA YWARD”) warrants the parts for One (1) year from the date of or ...
-
Viper Hayward 5500 - page 21
20 Use Only Genuine Hayward Replacement Parts. Limited W arranty HA YWARD hereby disclaims any and all claims, and PURCHASER releases HA YWARD from any and all claims f or damages to any pool plaster or vinyl liner in PURCHASER'S pool by reason of the use and/or operation of the CLEANER. 8. This Limited Warranty is valid and enforceable only o ...
-
Viper Hayward 5500 - page 22
High P erformance Automatic P ool Cleaner Owner's Guide Model 5500 • Important Safety Instructions • Installation Instructions • Parts List • Consumer Product Registration Card • Warranty Attention Installer: This manual contains important information about the installation, operation, and safe use of this automatic pool cleaner . Th ...
¿Tienes una pregunta acerca de Viper Hayward 5500?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Viper Hayward 5500, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Viper Hayward 5500 probablemente compartirá una forma de solucionarlo.