-
Weber PLATINUM 1200 - page 1
® ® P LATINUM SER IE S 98834 12/97 PLA TINUM ™ 12 0 0 Series Natural Gas Barbecue Serial Number Please use this number in registering your w arranty and any correspondence with the f actor y . ® Owner's Manual FOR Y OUR SAFETY Do not store or use gasoline or other flammable v apors and liquids in the vicinity of this or any other applianc ...
-
Weber PLATINUM 1200 - page 2
2 D ANGER Failure to f ollow the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injur y or death, or in a fire or an e xplosion causing damage to property . W ARNINGS Do not store a spare or disconnected LP tank under or near this barbecue. Improper assemb ly ma y be dangerous. Plea ...
-
Weber PLATINUM 1200 - page 3
3 W eber-Stephen Products Co . (W eber) hereby warr ants to the ORIGINAL PURCHASER of this W eber Gas Barbecue that it will be free of def ects in material and workmanship from the date of purchase as f ollows: Aluminum Castings , 10 years , Cooking Grates and Fla v orizer Bars, 3 y ears, All Remaining P ar ts, 5 years , when assembled and oper ate ...
-
Weber PLATINUM 1200 - page 4
© 1997 W eber . Weber , , Flav orizer and Crossov er are registered U .S. trademarks; Platinum, P er ma-Mount, Gas Catcher , FlameCheck, Steam- N-Chips, Spider Stopper , and W arm-Up are U.S . trademarks of Weber- Stephen Products Co ., 200 East Daniels Road, P alatine, IL 60067-6266. U .S.A. Printed in the U .S.A. 4 P A TENTS AND TRADEMARKS ...
-
Weber PLATINUM 1200 - page 5
5 Contents W arnings .................................................................... 2 W arranty & P atents .................................................. 3-4 General Instructions .................................................... 6 Assembly ............................................................... 7-21 Operating Instructions L ...
-
Weber PLATINUM 1200 - page 6
6 General Instructions Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav or izer Bars produce that "outdoor" fla vor in the f ood. The W eber Gas Barbe ...
-
Weber PLATINUM 1200 - page 7
Assembl y T ools needed Screwdriv er Phillips screwdriv er Hammer 7/16 open-end or an adjustable wrench Pliers Block of w ood Supplies needed Y ou will need a soap and water solution to chec k f or gas leaks. (See Step "Chec k f or gas leaks.") Note - The hardware siz e of n uts , bolts and scre ws is given. F or e xample "1/4-20 x 2 ...
-
Weber PLATINUM 1200 - page 8
Left frame Right frame Wheel frame Caster frame T wo frame connectors W ork table Swing table assemb ly Axle T wo accessor y tra ys W ar ming rack W ar m-Up Basket Five long Fla vorizer Bars Eight shor t Flav or izer Bars F ront panel Catch pan holder Catch pan T wo dr ip pans Manif old brac ket Ther mometer T wo wheels T wo casters Spacer brac ket ...
-
Weber PLATINUM 1200 - page 9
T wo plastic buttons (actual size) 1/4-20 keps n ut Fifteen 1/4 inch nylon w ashers T wo hair pin cotters T wo wheel hubcaps T wo Phillips screws/washers Check contents of hardw are packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Swing table end br ack et T wo hinge pins (hardware siz e: 1/4 x 1 1/2 inch cle v ...
-
Weber PLATINUM 1200 - page 10
10 Figure 1 Step 2 Assemble wheels Y ou will need: axle, two wheel hubcaps , two wheels , wheel frame, hammer and a b lock of wood. Place one end of the axle on the bloc k of wood (or other protected surf ace). T ap on one hubcap. Put one wheel on the axle, WEBER side to ward the hubcap . Slide the axle through the frame . Add the other wheel, WEBE ...
-
Weber PLATINUM 1200 - page 11
11 Figure 3 Step 4 Continue frame assemb ly Y ou will need: caster frame, wheel fr ame , f our 1/4-20 x 1/2 inch bolts, f our nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame with the dimple to the inside. Figu ...
-
Weber PLATINUM 1200 - page 12
12 Figure 6 Step 7 Add front panel Y ou will need: front panel and two plastic b uttons. T ur n frame assembly right side up . Inser t the tab on the narrow end of the front panel up through the slot in the frame brace as sho wn in figure 6. Align the panel with the holes in the frame and inser t the plastic buttons through the front panel and fr a ...
-
Weber PLATINUM 1200 - page 13
13 Y our W eber Gas Barbecue b urner assembly has been f actory assembled, pressure and flame tested. As a saf ety precaution we recommend y ou chec k the bur ner alignment: a) Do the valv es fit into the ends of the burners? Figure 9 (a). b) Are the ends of the burners under the washers at the left rear and left front of the cooking bo x? The scre ...
-
Weber PLATINUM 1200 - page 14
14 Step 10 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter . This was done to f actory test the ignition system. The igniter lock n ut and igniter gask et are on the igniter . Route the igniter and wires as shown. Figure 11 (a). Inser t the top of the igniter up through the large par ...
-
Weber PLATINUM 1200 - page 15
15 T ypical natural gas supply installation. Figure 12. Figure 12 The quick disconnect is installed abov e ground Gas supply Shut off Locking shut off Quick disconnect Outside wall Inside wall Male fitting T o barbecue D ANGER Do not use an open flame to chec k f or gas leaks. Be sure there are no sparks or open flames in the area while y ou ch ...
-
Weber PLATINUM 1200 - page 16
Step 13 Check f or gas leaks D ANGER Do not use an open flame to chec k f or gas leaks. Be sure there are no sparks or open flames in the area while y ou chec k f or leaks. This will result in a fire or explosion which can cause serious bodil y injury or death and damage to property . T ur n on gas supply . Check f or leaks by wetting the conne ...
-
Weber PLATINUM 1200 - page 17
17 (a) Figure 15 (c) (b) Check: a) Hose to manif old connection. Figure 15 (a). W ARNING: If there is a leak at connection a, retighten the fitting with a wrench and rechec k for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas . DO NO T OPERA TE THE BARBECUE. Contact your dealer . b) V alv ...
-
Weber PLATINUM 1200 - page 18
18 Step 16 Install Lid Y ou will need: lid, two hinge pins and two hair pin cotters . Set the lid in place. Align the hinges at the rear of the barbecue. Inser t hinge pins from the outside . Insert hair pin cotters into the small holes in the hinge pins. Figure 21. Hair pin cotter Hinge pin Figure 21 Step 15 Install the bottom tra y Y ou will need ...
-
Weber PLATINUM 1200 - page 19
19 Step 17 Add tool holders, control panel and b ur ner control knobs Y ou will need: three tool holders, control panel, two Phillips screws/w ashers, a Phillips scre wdr iv er , and three burner control knobs. Hook the tool holders ov er the frame rail. Figure 22. Set the control panel in place ov er both frame braces. Hold the Crossov er Ignition ...
-
Weber PLATINUM 1200 - page 20
20 Slot in frame (view from belo w) Inser t one end of the hinge rod into the hole in the frame. Figure 24 (a). Inser t the other end into the hole in the s wing table end brac ket. Figure 24 (b). Hold the end br ack et at an angle so the lower tab is inside the fr ame tube. Push the br ack et into the frame. Chec k to see that the lo wer tab of th ...
-
Weber PLATINUM 1200 - page 21
21 Step 19 Complete accessor y installation Y ou will need: W ar m-Up Basket, war ming rack, w ork table, two accessory trays , three tubing plugs, thermometer and a hammer . Inser t one end of the W eber W ar m-Up Bask et into the hole in the right end of the lid and the other end into the slot in the left end of the lid. Figure 27 (a). Set the wa ...
-
Weber PLATINUM 1200 - page 22
22 Lighting Summar y lighting instructions are on the control panel. 5 7 4 6 3 2 1 Figure 1 Crosso ver Ignition System 1) Open the lid. Figure 1. 2) Make sure all burner control knobs are OFF . (Push each burner control knob down and turn clockwise.) 3) T urn gas supply valv e on. W ARNING: Do not lean over open barbecue. Keep your face and bod ...
-
Weber PLATINUM 1200 - page 23
23 Manual Lighting W ARNING: Do not lean over open barbecue. Keep your face and bod y at least one foot awa y fr om the matchlight hole when lighting the barbecue. 5) Push Front b ur ner control knob down and turn to ST ART / HI. 6) Check that the burner is lit by looking through the matchlight hole on the front of the cooking bo x. W ARNIN ...
-
Weber PLATINUM 1200 - page 24
24 Cooking W ARNING: Do not move the W eber Gas Barbecue when operating or hot. Y ou can adjust the FRONT , CENTER and BACK b ur ners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your W eber cookbook. The cookbook uses these notations to describe the settings of the FRONT , CENTER, and BA CK b urne ...
-
Weber PLATINUM 1200 - page 25
25 Inspection and Cleaning of the W eber Spider Stopper Guards T o inspect the Spider Stopper Guards, remov e the control panel and look to see if they ha ve dust or dir t on their outside surf aces. If the y are dir ty , br ush off the outside surf ace of the Spider Stopper Guards with a soft bristle brush (an old toothbr ush f or example). Chec k ...
-
Weber PLATINUM 1200 - page 26
26 General Maintenance W eber Spider Stopper Guards Y our W eber Gas Barbecue , as w ell as an y outdoor gas appliance, is a target f or spiders and other insects. They can nest in the venturi section of the b urner tubes. This bloc ks the nor mal gas flow , and can cause the gas to flow back out of the air shutter . Figure 4. This could result in ...
-
Weber PLATINUM 1200 - page 27
27 e) Remov e the manifold brac k et and unscrew the tw o wing nuts that hold the manif old to the cooking box. Pull the manif old and v alve assemb ly out of the burners and carefully set it down. Figure 10. View from behind cooking bo x Wing nuts Figure 10 Guide screw Figure 11 Crossov er tube Figure 12 Figure 9 d) Unlatch the Spider Stopper Guar ...
-
Weber PLATINUM 1200 - page 28
28 Figure 15 White wire Black wire Crosso ver Ignition System Operations If the Crossov er Ignition System fails to ignite the F ront burner , light the F ront burner with a match. If the F ront burner lights with a match, then check the Crosso v er Ignition System. ■ Check that both the white and b lack ignition wires are attached properly . Fig ...
-
Weber PLATINUM 1200 - page 29
29 29 Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: 몇 CA UTION: Do not line the bottom tray with aluminum f oil. Burner flame pattern is erratic. Flame is low when burner is on HIGH. Flames do not run the whole length of ...
-
Weber PLATINUM 1200 - page 30
30 30 W E B E R W E B E R ® ® ® ® ® ® ® ® 1 2 3 6 7 8 11 9 10 14-15 23 24 16 29 31 32 33 58 51-56 57 59 49 47 46 45 44 43 41 40 39 38 37 36 35 50 48 30 25 42 12 13 17 22 5 4 28 27 26 34 21 10,15 18 19-20,15 ...
-
Weber PLATINUM 1200 - page 31
31 31 1 Lid (assembly) 2 Lid handle 3 W ar m-Up Basket 4 W ar ming rack 5 Shor t Flav or izer bars (8) 6 Long Flav or izer bars (5) 7 Cooking grates (2) 8 W ork table 9 T ubing plugs (5) 10 1/4-20 x 2 inch bolts (5) 11 Spacer brac ket 12 Swing tab le end brac ket 13 Left frame 14 1/4-20 x 1/2 inch bolts (6) 15 1/4 inch n ylon washers (15) 16 Caster ...
-
Weber PLATINUM 1200 - page 32
A F INAL W ORD OF T HANKS hank you for choosing a W eber Barbecue. Our family here at W eber has worked har d to pr oduce the highest quality pr oducts for your satisfaction. While we give much attention to our pr oducts, an occasional err or may occur . Our knowledgeable Customer Ser vice staff is pr epared to help you with any pr oblems with part ...
¿Tienes una pregunta acerca de Weber PLATINUM 1200?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Weber PLATINUM 1200, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Weber PLATINUM 1200 probablemente compartirá una forma de solucionarlo.