-
Alto-Shaam 1200-SK/III - page 1
MN-29758 ( r e v . 4) • 11/13 p r i n t e d i n u . s . a . PHONE: 262.251.3800 • 800.558.8744 U ...
-
Alto-Shaam 1200-SK/III - page 2
MN-29758 (R e v . 4) • TH/III & SK/III I N S T a l l a T I o N / o p e R a T I o N / S e R v I c e M a N u a l Delivery ...................................... 1 Unpacking .................................... 1 Safety Procedures and Precautions ................. 2 Installation Installation Requirements ...................... 3 Clearance Requir ...
-
Alto-Shaam 1200-SK/III - page 3
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .1 DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at onc ...
-
Alto-Shaam 1200-SK/III - page 4
p g .2 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Us ...
-
Alto-Shaam 1200-SK/III - page 5
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .3 SITE INSTALLATION The Alto-Shaam cook and hold oven must be installed in a location that will permit the oven to function for its intended purpose and to allow adequate clearance for ventilation, proper ...
-
Alto-Shaam 1200-SK/III - page 6
p g .4 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l SITE INSTALLATION INSTALLATION 300-th3 2011 lit 25-3/16 " (643mm) Cord Length: 5 ft. (1524mm) 16-13/16 " (426mm) 18-15/16 " (480mm) 3/4 " (19mm) 15-1/4 " (387mm) 40-5/8 " (1031m ...
-
Alto-Shaam 1200-SK/III - page 7
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .5 SITE INSTALLATION INSTALLATION 767-SK/III 750-TH/III PRODUCTPAN CAPACITY 100 lb (45 kg) m a x i m u m v o l u M e MaxiMuM : 53 q u a r t s (67 l i t e r s ) WEIGHT MODeL net WeiGht ship WeiGht 750-TH/I ...
-
Alto-Shaam 1200-SK/III - page 8
p g .6 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l SITE INSTALLATION INSTALLATION 1000-SK/III 1000-TH/III 34" (864mm) 25-1/16" (636mm) 23-1/2" (597mm) 17" (432mm) 51" (1294mm) 72-3/4" (1847mm) 5-1/8" (130mm) 40-3/16" ( ...
-
Alto-Shaam 1200-SK/III - page 9
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .7 SITE INSTALLATION INSTALLATION 1200-SK/III 1200-TH/III 25-1/16" (636mm) 51" (1294mm) 72-3/4" (1847mm) 34-1/2" (876mm) Electrical Connection Pass-Through Option Shown with optional bu ...
-
Alto-Shaam 1200-SK/III - page 10
p g .8 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l SITE INSTALLATION INSTALLATION 1767-SK/III 26-5/8" (676mm) 25-1 1/16" (651mm) 23-5/8" (600mm) Shown with optional bumpe r Electrical Connection 28-5/8" (726mm) 34-7/8" (886mm) 56-3/4 ...
-
Alto-Shaam 1200-SK/III - page 11
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .9 INSTALLATION SMOKER OPTIONS AND ACCESSORIES 767-SK/III 1767-SK/III 1000-SK/III 1200-SK/III Bumper, Full Perimeter ( No t av a i la b l e w i th 2-1/2" c a st e r s ) 5010371 5010371 5009767 5009767 ...
-
Alto-Shaam 1200-SK/III - page 12
p g .10 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l INSTALLATION ST ACKING INSTRUCTIONS 1) If the two appliances were shipped together fr om the factory , the top unit will have the casters already r emoved. A stacking kit will be included with the shipment. ...
-
Alto-Shaam 1200-SK/III - page 13
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .11 SITE INSTALLATION INSTALLATION A number of adjustments are associated with initial installation and start-up. It is important that these adjustments be conducted by a qualified service technician. Inst ...
-
Alto-Shaam 1200-SK/III - page 14
p g .12 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l SITE INSTALLATION INSTALLATION DRIP TRAY INSTALLATION INSTRUCTIONS - 500, 750, 1000, 1200 WARNING FAILURE TO PROPERLY INSTALL THE DRIP TRAY CAN OR WILL CAUSE MAJOR EQUIPMENT DAMAGE AND WILL RESULT IN A LEAK ...
-
Alto-Shaam 1200-SK/III - page 15
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .13 ELECTRICAL CONNECTION INSTALLATION The appliance must be installed by a qualified service technician. The oven must be properly grounded in accordance with the National Electrical Code and applicable l ...
-
Alto-Shaam 1200-SK/III - page 16
p g .14 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ELECTRICAL INSTALLATION Wire diagrams are located inside the bonnet of the unit. 500-TH/III v O L t a G e phase c y c L e / h z a M ps kW cOrD & p L u G 120 1 60 16.0 1.9 N e Ma 5-20 p 2 0 a - 1 2 5 v p ...
-
Alto-Shaam 1200-SK/III - page 17
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .15 OPERATION USER SAFETY INFORMATION The Alto-Shaam cook and hold oven is intended for use in commercial establishments by qualified operating personnel where all operators are familiar with the purpose, ...
-
Alto-Shaam 1200-SK/III - page 18
p g .16 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l OPERATION A B C D E F G H I A B C D E F G H I 1. ON/OFF Key The ON/OFF control system key operates the functions of the control panel. If there is any power loss during operation, the on/off indicator light ...
-
Alto-Shaam 1200-SK/III - page 19
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .17 OPERATION Cook/Hold/Smoke Instructions Press and release control ON/OFF key. The oven will beep for one second and power to the unit will be indicated by an illuminated green indicator light located in ...
-
Alto-Shaam 1200-SK/III - page 20
p g .18 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l To stop an operation at any time Press and hold the s t a r t Key until the control beeps for two seconds, indicating the operation has been cancelled. The oven will remain in a power-on state. To turn ...
-
Alto-Shaam 1200-SK/III - page 21
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .19 Display High/Low Probe Temperatures: To observe the recorded maximum or minimum probe temperature when cooking by probe, press the following keys while the probe remains in the product: ...
-
Alto-Shaam 1200-SK/III - page 22
p g .20 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l Preparation Adjust the inside door vents per the individual cooking procedure selected. Always keep door vents closed when cooking with the smoking function. Insert drip pan on the bottom of the oven cavity ...
-
Alto-Shaam 1200-SK/III - page 23
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .21 OPERATION P r e S e T Keys Lock and Unlock PRESET Keys A through H can be locked in order to prevent storing, altering or erasing a program. To lock the PRESET K eys, press and hold the “I” Key unt ...
-
Alto-Shaam 1200-SK/III - page 24
p g .22 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l OPERATION HACCP HACCP Documentation, Data Logger - Optional This oven meets the requirements of established HACCP criteria by providing automated sampling, record keeping, set-point v alidation, recipe used ...
-
Alto-Shaam 1200-SK/III - page 25
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .23 OPERATION GENERAL HOLDING GUIDELINES Chefs, cooks and other specialized food service personnel employ varied methods of cooking. Proper holding temperatures for a specific food product must be based on ...
-
Alto-Shaam 1200-SK/III - page 26
p g .24 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l CARE AND CLEANING PROTECTING STAINLESS STEEL SURFACES It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely destroy ...
-
Alto-Shaam 1200-SK/III - page 27
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .25 EQUIPM E NT CARE Under normal circumstances, this oven should provide you with long and trouble free service. There is no preventative maintenance required, however, the following Equipment Care Guide ...
-
Alto-Shaam 1200-SK/III - page 28
p g .26 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l CARE AND CLEANING CLEAN THE DOOR VENTS Door vents need to be inspected and cleaned as required. CLEAN THE PROBES DAILY Remove all food soil from probes. Wipe entire probe and cable assembly with warm deterg ...
-
Alto-Shaam 1200-SK/III - page 29
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .27 Food fl avor and aroma are usually so closely related that it is diffi cult, if not impossible, to separate them. There is also an important, inseparable relationship between cleanliness and food fl ...
-
Alto-Shaam 1200-SK/III - page 30
p g .28 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l SERVICE TROUBLESHOOTING Code Description Possible Cause E-10 Cavity air sensor shorted Cavity air sensor reading < 5°F. Verify sensor integrity. See sensor test instructions below. E-11 Cavity air senso ...
-
Alto-Shaam 1200-SK/III - page 31
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .29 SERVICE DANGER DISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING. NOTE If the appliance has been unplugged for an extended period of time, the Real Time Clock may require recharging. Turn ...
-
Alto-Shaam 1200-SK/III - page 32
p g .30 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l SERVICE EXTERIOR VIEW - 300-TH/III 11 7 10 6 8 1 29 16 25 18 23 21 22 20 19 26 15 9 5 4 3 2 28 13 14 12 17 24 27 18 A Part numbers and drawings are subject to change without notice. ...
-
Alto-Shaam 1200-SK/III - page 33
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .31 A EXTERIOR SERVICE VIEW - 300-TH/III SERVICE ITEM DESCRIPTION PART NO. QTY 1 BONNET TOP COVER 1012831 1 2 FAN BOX, 120V F A-3973 1 FAN BOX, 230V F A-34524 1 3 BUSHING, STRAIGHT , STRAIN RELIEF , 230V B ...
-
Alto-Shaam 1200-SK/III - page 34
p g .32 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l EXTERIOR SERVICE VIEW - 500, 750, 1000-TH/III SERVICE 36 35 37 38 1 23 4 5 6 7 9 10 11 12 13 14 15 17 19 20 18 23 21 28 24 26 22 27 25 29 30 32 31 33 34 16 8 22 500-TH/III Shown Part numbers and drawings ar ...
-
Alto-Shaam 1200-SK/III - page 35
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .33 MODEL > 500-TH/III 750-TH/III 1000-TH/III ITEM DESCRIPTION PART NO. QTY PART NO. QTY PART NO. QTY 1 THERMOSTAT, HI LIMIT TT -33476 1 TT -33476 1 TT -33476 1 2 GASKET ADHESIVE 0.125 X 0.375 [LIN FT] ...
-
Alto-Shaam 1200-SK/III - page 36
p g .34 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l DANGER LOCK-OUT OR POST BREAKER PANEL UNTIL SERVICE WORK HAS BEEN COMPLETED. DANGER DISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING. A 8 7 9 1 4 12 11 31 30 29 28 25 16 15 13 14 19 18 20 21 2 ...
-
Alto-Shaam 1200-SK/III - page 37
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .35 EXTERIOR SERVICE VIEW - 767, 1000-SK/III * not Shown MODEL > 767-SK/III 1000-SK/III ITEM DESCRIPTION PART NO. QTY PART NO. QTY 1 TOP COVER 1011872 1 1011534 1 2 THERMOST A T , HI-LIMIT TT -33476 1 T ...
-
Alto-Shaam 1200-SK/III - page 38
p g .36 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l EXTERIOR SERVICE VIEW - 1200-TH/III SERVICE A 7 10 1 5 11 8 29 28 25 27 26 23 13 12 17 16 18 19 22 21 20 18 9 14 4 3 2 24 31 30 6 A 32 33 34 35 15 ** Part numbers and drawings are subject to change without ...
-
Alto-Shaam 1200-SK/III - page 39
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .37 EXTERIOR SERVICE VIEW - 1200-TH/III SERVICE * not Shown DANGER DISCONNECT UNIT FROM POWER SOURCE BEFORE CLEANING OR SERVICING. DANGER LOCK-OUT OR POST BREAKER PANEL UNTIL SERVICE WORK HAS BEEN COMPLETE ...
-
Alto-Shaam 1200-SK/III - page 40
p g .38 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l A 8 11 1 6 12 9 32 31 29 30 26 24 15 13 18 17 19 20 23 22 21 19 10 14 5 4 3 28 34 33 7 A 35 36 37 38 2 16 25 27 EXTERIOR SERVICE VIEW - 1200, 1767-SK/III SERVICE 1200-SK/III Shown Part numbers and drawings ...
-
Alto-Shaam 1200-SK/III - page 41
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .39 EXTERIOR SERVICE VIEW - 1200, 1767-SK/III * not Shown MODEL > 1767-SK/III 1200-SK/III ITEM DESCRIPTION PART NO. QTY PART NO. QTY 1 TOP COVER 1011872 1 1011534 1 2 THERMOST A T , HI-LIMIT TT -33476 2 ...
-
Alto-Shaam 1200-SK/III - page 42
p g .40 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ELECTRONIC COMPONENTS - 300-TH/III SERVICE 4 3 1 2 7 5 6 19 18 17 15 16 9 14 8 13 12 11 10 9 230V Shown Part numbers and drawings are subject to change without notice. ITEM DESCRIPTION PART NO. QTY ITEM DES ...
-
Alto-Shaam 1200-SK/III - page 43
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .41 ELECTRONIC COMPONENTS - 500-TH/III SERVICE Part numbers and drawings are subject to change without notice. ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 BUSHING, 3/8" BLACK HOLE BU ...
-
Alto-Shaam 1200-SK/III - page 44
p g .42 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ELECTRONIC COMPONENTS - 750, 1000, 1200-TH/III 1200-TH/III 230V Shown SERVICE 3 1 19 13 12 14 16 17 11 10 9 8 7 1 5 15 4 2 6 18 6 6 6 Part numbers and drawings are subject to change without notice. ITEM DES ...
-
Alto-Shaam 1200-SK/III - page 45
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .43 SERVICE 4 5 1 3 2 17 16 18 8 21 20 15 14 13 12 8 11 1 9 8 7 6 19 22 10 8 Part numbers and drawings are subject to change without notice. ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 BU ...
-
Alto-Shaam 1200-SK/III - page 46
p g .44 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l CABLE HEATING KITS SERVICE CABLE HEATING KIT > (ONE KIT REQUIRED PER CAVITY) #4880 (500) #4881 (750, 1000, 1200, 1767) #4880 UK ONLY (1200) 4900W ITEM DESCRIPTION QTY QTY QTY CB-3045 CABLE HEA TING ELEME ...
-
Alto-Shaam 1200-SK/III - page 47
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .45 ...
-
Alto-Shaam 1200-SK/III - page 48
p g .46 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ...
-
Alto-Shaam 1200-SK/III - page 49
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .47 ...
-
Alto-Shaam 1200-SK/III - page 50
p g .48 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ...
-
Alto-Shaam 1200-SK/III - page 51
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .49 ...
-
Alto-Shaam 1200-SK/III - page 52
p g .50 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ...
-
Alto-Shaam 1200-SK/III - page 53
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .51 ...
-
Alto-Shaam 1200-SK/III - page 54
p g .52 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ...
-
Alto-Shaam 1200-SK/III - page 55
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .53 ...
-
Alto-Shaam 1200-SK/III - page 56
p g .54 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ...
-
Alto-Shaam 1200-SK/III - page 57
MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l p g .55 ...
-
Alto-Shaam 1200-SK/III - page 58
p g .56 MN-29758(R e v .4)•TH/III&SK/III I N S T a l l a T I o N / o p e R a T I o N / SeRvIce M a N u a l ...
-
Alto-Shaam 1200-SK/III - page 59
TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...
Avez-vous une question à propos de Alto-Shaam 1200-SK/III?
Utiliser le formulaire ci-dessous
Si vous n’avez pas résolu votre problème avec Alto-Shaam 1200-SK/III, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Alto-Shaam 1200-SK/III il est probable qu’il a envie de partager la façon de le résoudre.