-
Lenovo U530 TOUCH - page 1
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual ...
-
Lenovo U530 TOUCH - page 2
Note: Before usi ng this information and the product it supports, be sure to read the general information under “Notices” on page 72. First Editi on (Aug ust 2013) © Copyright Lenovo 2013. All rights reserved. LENOVO products, data, co mputer software, ...
-
Lenovo U530 TOUCH - page 3
iii About this manual ................................. ....... iv Safety informat ion.............................. ........... 1 General safety ............................ ....................... ... 2 Electrical safety ...................... .................. ............ 3 Safety inspec tion guide ................. ........... ...
-
Lenovo U530 TOUCH - page 4
iv This manual contains service and reference information for the following Lenovo product: Lenovo IdeaPad U5 30 Touch Use this manual to troubleshoot problems. The manual is di vided into the foll owing sections: • The common sections provide ...
-
Lenovo U530 TOUCH - page 5
Lenovo IdeaPad U530 Touch 1 This chapter presents the following safety in formation that you need to get familiar with befo re you service a Lenovo computer: • “General safety” on page 2 • “Electri cal safety” on page 3 • “Safety ...
-
Lenovo U530 TOUCH - page 6
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 2 Follow the following rules to ensure general safety: • Observe a good housekeeping in the area where the mac hines are put during and after the maintena nce. • When lifting any heav y ? ...
-
Lenovo U530 TOUCH - page 7
Lenovo IdeaPad U530 Touch 3 Observe the following rules when working on electrical equipments. • Find the room emergency pow er ‐ off (EPO) switch, discon necting switch, or electrical outlet. If an electrical accident occurs, yo u ca n t ...
-
Lenovo U530 TOUCH - page 8
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 4 • Always look carefully for possible hazards in your wo rk area. Examples of these hazards are moist floors, nong rounded power extension cables, pow er surges, and missing safety groun ds ...
-
Lenovo U530 TOUCH - page 9
Lenovo IdeaPad U530 Touch 5 The purpose of this inspection guide is to assist you in identifying potential unsafe conditio ns. As each machine was designed and built, required safety items were installed to protect users and s ...
-
Lenovo U530 TOUCH - page 10
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 6 Any computer part containing tran sistors or integrated circu its (ICs) should be considered sensitive to electrostatic discharge (ESD). ESD damage can occur when there is a difference in ? ...
-
Lenovo U530 TOUCH - page 11
Lenovo IdeaPad U530 Touch 7 The safety notices in this section are provided in English, French, German, Hebrew , Italian, Japane se, and Spanish. Safety notices: multilingual translations Safety not ice 1 Before the computer is powered on after FRU repla ...
-
Lenovo U530 TOUCH - page 12
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 8 Safety n otice 2 DANGER Some standby batt eries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it in to fire or water, or short ‐ ci ...
-
Lenovo U530 TOUCH - page 13
Lenovo IdeaPad U530 Touch 9 Safety n otice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short ‐ circuit it. Dispose of the ba ttery pack as required by local ...
-
Lenovo U530 TOUCH - page 14
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 10 Safety n otice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polariz ed connector, disassemble it, heat it above 100°C ( ...
-
Lenovo U530 TOUCH - page 15
Lenovo IdeaPad U530 Touch 11 Safety n otice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical ? ...
-
Lenovo U530 TOUCH - page 16
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 12 Safety n otice 6 DANGER To avoid shock, do not remove the pla stic cover that prote cts the lo wer part of the inverter ca rd. Afin d’éviter tout risque de choc électrique, ne retirez p ...
-
Lenovo U530 TOUCH - page 17
Lenovo IdeaPad U530 Touch 13 Safety n otice 8 DANGER Before removing any FRU, turn off the comput er, unplug all pow er cord s from electrical outlets, rem ove the battery pack, an d then disconnect any interconnecting cables. Avant de retirer ? ...
-
Lenovo U530 TOUCH - page 18
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 14 Some models of Lenov o comp uter ar e equipped from the factory with an optical storage device such as a CD ‐ ROM dri ve or a DVD ‐ ROM drive. Such devices are also sold sep ...
-
Lenovo U530 TOUCH - page 19
Lenovo IdeaPad U530 Touch 15 A CD ‐ ROM drive, a DVD ‐ ROM driv e, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser ra ...
-
Lenovo U530 TOUCH - page 20
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 16 This chapter presents the following impo rtant service inf ormation : • “Strategy for replacing FRUs” on page 16 – “Strategy for repl acing a hard disk drive” on page 17 – “Importan t notice ? ...
-
Lenovo U530 TOUCH - page 21
Lenovo IdeaPad U530 Touch 17 Use the following strategy to prevent unnecessary expense for replacing and servicin g FRUs: • If you are instructed to repla ce an FRU, but the replacement does not solve the problem, reinstall the ...
-
Lenovo U530 TOUCH - page 22
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 18 RoHS, The Restrictio n of Hazardous Subs tances in Electrical and Electronic Equi pment Directi ve (2002/ 95/EC) is a European Union le gal requirement affect ing the global elec tr onics industry. RoHS req uirements must be implemente d on Lenovo product s placed on the market aft er June 20 ...
-
Lenovo U530 TOUCH - page 23
Lenovo IdeaPad U530 Touch 19 This chapter presents the following information: • “What to do first” on page 20 • “P ower system checkout” on page 21 Before you go to the checkout, make sure to read th e following important notes: G ...
-
Lenovo U530 TOUCH - page 24
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 20 When you do return an FRU, you must include the follow ing inform ation in the parts exchange form or parts return form that you attach to it: 1. Name and phone number of se ...
-
Lenovo U530 TOUCH - page 25
Lenovo IdeaPad U530 Touch 21 To verify a symptom, fol low the steps below: 1. Turn off the computer. 2. Remove the battery pack. 3. Connect th e AC adapter. 4. Make sure that power is supplied when you turn on the computer. 5. Turn off ? ...
-
Lenovo U530 TOUCH - page 26
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 22 Perform operational charging. If the battery status indicator or icon does not light on, remove the battery pack an d let it return to roo m tem peratur e. Reinstall the battery pac ...
-
Lenovo U530 TOUCH - page 27
Lenovo IdeaPad U530 Touch 23 This chapter presents the following information: • “Restoring the factor y contents by using Recovery Disc Set” on page 23 • “P assword s” on page 24 • “P ower management” on page 25 When the hard disk drive ...
-
Lenovo U530 TOUCH - page 28
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 24 7. When all of the data has been copied from the last disc in the set, remove the disc and restart the comp uter. 8. When the recovery process is complete, the Welcome to th ...
-
Lenovo U530 TOUCH - page 29
Lenovo IdeaPad U530 Touch 25 Note: Power management modes are not supported for APM operating system. To reduce power consumption, the computer has three power mana gement modes: screen blank, sleep (standby ), and hibernation. Screen blan k stat ...
-
Lenovo U530 TOUCH - page 30
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 26 Shutting down the computer If you are not go ing to use your computer for a long ti me, shut it down. To shut down your computer: • Open the charms bar, then select Set tings . • Se ...
-
Lenovo U530 TOUCH - page 31
Lenovo IdeaPad U530 Touch 27 This chapter presents the following product ‐ specific service references and product ‐ specific parts information: • “Specificat i ons” on page 27 • “Status indicators” on page 29 • “Fn key combinations” on page 30 • ...
-
Lenovo U530 TOUCH - page 32
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 28 Table 1. Specification s (continued) Feature Descri ption I/O ports • HDMI port × 1 • USB 2.0 × 2, USB 3.0 × 1 • 2 in 1 slot × 1 (MMC, SD) • RJ45 × 1 Audio • Combo audio jack ...
-
Lenovo U530 TOUCH - page 33
Lenovo IdeaPad U530 Touch 29 The system status indicators below show the computer status: Table 2. Status indicators Symbol Indicator status Meaning On (solid white) T he computer is powered on. Blinking The computer is in sleep mode. Off The computer is ...
-
Lenovo U530 TOUCH - page 34
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 30 The following table shows the function of each combinatio n of Fn with a function key. Table 3. Fn key combinat ions The hotkeys are located in th e function key row of the key ...
-
Lenovo U530 TOUCH - page 35
Lenovo IdeaPad U530 Touch 31 This secti on presents notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the Lenovo computer, ...
-
Lenovo U530 TOUCH - page 36
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 32 This section presents exploded figures with the instructions to indicate how to remove and replace the FRU . Make sure to observ e the following gener a l rules: 1. Do not attempt to ? ...
-
Lenovo U530 TOUCH - page 37
Lenovo IdeaPad U530 Touch 33 1010 Battery pack Figure 1. Re moval steps of batte ry pack Remove the twelve screws and two screws . Open the back cover in the direction shown by arrow . Step Screw (qua ntity) Color Torq ue M 2.0 × 4.0 mm, ...
-
Lenovo U530 TOUCH - page 38
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 34 Figure 1. Re moval steps of batte ry pack (continued) Unplug the battery connector in the direction shown by arrow first, then remove five screws . Remove the battery in the directio ...
-
Lenovo U530 TOUCH - page 39
Lenovo IdeaPad U530 Touch 35 1020 Dummy card Figure 2. Re moval steps of dum my card Remove the dummy card in the direction shown by arrows . a b b a ...
-
Lenovo U530 TOUCH - page 40
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 36 1030 Hard disk drive For access, remove this FRU: • “1010 Battery pack” on page 33 Figure 3. Re moval steps of hard disk drive Remove th e fr ame fixing screws . Pull the ta b to disc ...
-
Lenovo U530 TOUCH - page 41
Lenovo IdeaPad U530 Touch 37 Figure 3. Re moval steps of hard disk drive (continue d) Lift up to remove the hard disk drive in the direction shown by arrow . Disconnect the co nnector of the hard disk dr ive in the d irect ...
-
Lenovo U530 TOUCH - page 42
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 38 1040 DIMM For access, remove this FRU: • “1010 Battery pack” on page 33 Figure 4. Re moval steps of DIM M Release the two latches on both edges of the socket at the same time in ? ...
-
Lenovo U530 TOUCH - page 43
Lenovo IdeaPad U530 Touch 39 1050 PCI Express Mini Card for wi reless LAN/WAN For access, remove this FRU: • “1010 Battery pack” on page 33 Figure 5. Re moval steps of PCI Express Mi ni Card for wire less LAN/WAN Disconnect the two wireless LAN cab ...
-
Lenovo U530 TOUCH - page 44
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 40 Figure 5. Removal ste ps of PCI Expres s Mini Card for wireless LAN/WAN (continued) Remove the card in the direction shown by arrow . When installing: • In models with a wireless LAN ...
-
Lenovo U530 TOUCH - page 45
Lenovo IdeaPad U530 Touch 41 1060 Fan assembly and Heat Si nk assembly For access, remove this FRU: • “1010 Battery pack” on page 33 Figure 6. Re moval steps of fan as sembly and heat sink assembly Unplug the fan connector in the direction show ...
-
Lenovo U530 TOUCH - page 46
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 42 Figure 6. Re moval steps of fan as sembly and heat sink assembly (continue d) Lift up to remove the fan assembly an d heat sink assembly in the direction shown by arrow . Be ...
-
Lenovo U530 TOUCH - page 47
Lenovo IdeaPad U530 Touch 43 1070 Power assembly For access, remove these FRUs in order: • “1010 Battery pack” on page 33 Figure 7. Re moval steps of pow er assembly Unplug the connector in th e direction shown by arrow and re move ...
-
Lenovo U530 TOUCH - page 48
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 44 1080 USB board For access, remove these FRUs in order: • “1010 Battery pack” on page 33 Figure 8. Re moval steps of USB bo ard Unplug the connector in the direction shown by arrow and ...
-
Lenovo U530 TOUCH - page 49
Lenovo IdeaPad U530 Touch 45 1090 Power board For access, remove these FRUs in order: • “1010 Battery pack” on page 33 Figure 9. Re moval steps of pow er board Unplug the connect or in th e direction shown by ar row and , Remove tw ...
-
Lenovo U530 TOUCH - page 50
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 46 1100 System board For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1020 Dummy card” on page 35 • “1030 Hard disk drive” on page 36 • “1040 DIMM” on page 3 ...
-
Lenovo U530 TOUCH - page 51
Lenovo IdeaPad U530 Touch 47 Figure 10. Removal steps of syste m board (continu ed) Remove screws . Remove the system board in the direction shown by arrow . When instal ling: When attaching th e system board to the base cover, adjust ...
-
Lenovo U530 TOUCH - page 52
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 48 1110 Base cover For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1020 Dummy card” on page 35 • “1030 Hard disk drive” on page 36 • “1040 DIMM” on page 38 ...
-
Lenovo U530 TOUCH - page 53
Lenovo IdeaPad U530 Touch 49 Note: Applyi ng labels to the base cover The new base cover FRU is shipped with a kit contai ning labels of several kinds. When you replace the base cover, you need to apply the following labels: The follo ...
-
Lenovo U530 TOUCH - page 54
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 50 1120 LCD unit For access, remove these FRUs in order: • “1010 Battery pack” on page 33 Figure 11. Removal steps of LCD uni t Remove four screws . When installing: • Route the an tenna cables al ...
-
Lenovo U530 TOUCH - page 55
Lenovo IdeaPad U530 Touch 51 Figure 8. Re moval steps of LCD unit (continued) Detach th e LCD unit from the upper case in the direction shown by arrow . b 2 ...
-
Lenovo U530 TOUCH - page 56
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 52 1130 Hinge cover For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1120 LCD unit ” on pa ge 50 Figure 12. Removal steps of hinge cover Release the hooks of the ...
-
Lenovo U530 TOUCH - page 57
Lenovo IdeaPad U530 Touch 53 1140 Hinges For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1120 LCD unit ” on pa ge 50 • “1130 Hinge cov er ” on page 52 Figure 13. Removal steps of hinges Remove six screws ...
-
Lenovo U530 TOUCH - page 58
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 54 1150 LCD panel, LCD bezel, and LCD cover assembly For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1120 LCD unit ” on pa ge 50 • “1130 Hinge cov er ” on page 52 • “1140 ...
-
Lenovo U530 TOUCH - page 59
Lenovo IdeaPad U530 Touch 55 1160 Integrated camera For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1120 LCD unit ” on pa ge 50 • “1130 Hinge cov er ” on page 52 • “1140 Hinges” on page 53 • “1150 LCD p ...
-
Lenovo U530 TOUCH - page 60
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 56 1170 Antenna assembly and LCD cover For access, remove these FRUs in order: • “1010 Battery pack” on page 33 • “1120 LCD unit ” on pa ge 50 • “1130 Hinge cov er ” on page 52 • “1140 Hinges” ...
-
Lenovo U530 TOUCH - page 61
Lenovo IdeaPad U530 Touch 57 Front view Integrated camera Built-in micropho ne Multi-to uch display Power button Touchpad Ventilatio n slots Wireless antenn as Locations a b c d e f 7 1 2 3 4 5 7 6 ...
-
Lenovo U530 TOUCH - page 62
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 58 Right-side vi ew System status indicators Power i ndicator Battery status indica tor Memory card slot USB port AC power adapter ja ck a b c d d b a c ...
-
Lenovo U530 TOUCH - page 63
Lenovo IdeaPad U530 Touch 59 Bottom and left- side view Novo button RJ-45 port HDMI port USB ports Combo audio jack Speakers Louvers a b c d e f 7 7 2 3 4 5 6 6 1 ...
-
Lenovo U530 TOUCH - page 64
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 60 This section presents the f ollowing service parts: • “Overall” on page 61 • “LCD FRUs ” on page 65 • “Miscell aneous parts” on page 67 • “A C adapt ers” on page 68 • “P ower cords” on ? ...
-
Lenovo U530 TOUCH - page 65
Lenovo IdeaPad U530 Touch 61 Overall 1 2 3 8 (9) 4 6 5 7 8 (9) 10 11 12 15 16 17 13 a 14 b ...
-
Lenovo U530 TOUCH - page 66
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 62 Table 5. Parts list—Overall No. FRU FRU no. CRU ID 1L Z B LCD Module FHD 90400216 N 1L Z B LCD Module HD 90400217 N 2 Keyboard 3L Z B Upper Case W/KB ‐ TWN 90204064 N 3L Z B Upper Case W/KB ‐ GRE 90204065 N 3L Z B Upper ...
-
Lenovo U530 TOUCH - page 67
Lenovo IdeaPad U530 Touch 63 5L Z B MB W8P DIS I3 ‐ 4010U 2G 90 004523 N 5L Z B MB W8S DIS I3 ‐ 4010U 2G 90004524 N 5L Z B MB DIS I5 ‐ 4200U 2G 90004525 N 5L Z B MB W8P DIS I5 ‐ 4200U 2G 90 004526 N 5L Z B MB W8S DIS I5 ‐ 4200U 2G 90004527 N 5L ...
-
Lenovo U530 TOUCH - page 68
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 64 13 LZ9 Power Board 90003351 N 14 LZ9 USB Board 90003352 N 15 Battery 7.4V 52Wh 4cell 2S2P P510 SP/A L12M 4P62 121500199 N 15 Battery 7.4V 52Wh 4cell 2S2P P510 LG L12L4P62 121500200 N 16 LZB Lower Case ...
-
Lenovo U530 TOUCH - page 69
Lenovo IdeaPad U530 Touch 65 LCD FRUs In Lenovo IdeaPad U530 Touch , there are the follow ing types of LCD: • “14.0 ‐ in. HD TFT” U5 30 To u c h 6 7 5 4 3 2 1 2 ...
-
Lenovo U530 TOUCH - page 70
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 66 Table 7. Parts list—14.0 ‐ in. HD TFT No. FRU FRU no. CR U ID 1T o u c h AUO I156FGT05.1 OGS Na At P510 TSP 73045768 N 2L Z B Hinge L+R 90204060 N 3L Z B Hinge Cover 90204056 N 4P a n e l HD ‐ S ‐ AG ? ...
-
Lenovo U530 TOUCH - page 71
Lenovo IdeaPad U530 Touch 67 Miscellaneo us parts Table 8. Parts list—Miscellaneou s parts FRU P/N CR U ID (a) LZB Po w e r Board Cable 90204057 N (b) LZB USB Board C able 90204058 N Note: Italicized letters in parentheses ar e references to the exploded view ...
-
Lenovo U530 TOUCH - page 72
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 68 AC adapters Table 9. Parts list—3 ‐ pin AC adapte rs Screws Table 10. Screw list FRU P/N CR U ID Adapter 45W 3pin Delta ADLX45 NDC3A 20V2.2 5A adapter 36200245 * Adapter 45W 3pin Liteon ADLX45NLC3A 20V2.25A ? ...
-
Lenovo U530 TOUCH - page 73
Lenovo IdeaPad U530 Touch 69 Power cords A Leno vo power cord for a specific country or region is usually available only in that country or regi on: Table 11. Parts lis t—3 ‐ pin power cords Region P/N CR U ID CCC • LINETEK PC323+R VV300/3 00+L ...
-
Lenovo U530 TOUCH - page 74
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 70 Table 11. Parts lis t—3 ‐ pin power cords (continued) Region P/N CR U ID Brazil • Longwell LP ‐ 46+H03VV ‐ F+LS ‐ 18 1m 145000564 * Israel • Longwell LP ‐ 41+H03VV ‐ F+LS ‐ 18 1m 145000563 UL • Longwell LP ‐ 30B+SPT ‐ 2 ...
-
Lenovo U530 TOUCH - page 75
Lenovo IdeaPad U530 Touch 71 Table 11. Parts lis t—3 ‐ pin power cords (continued) Region P/N CRU ID Brazil • VOLEX CH10S3+H03VV ‐ F+ V AC5S 1m 145000527 * Israel • VOLEX SI16S3+H03VV ‐ F+V AC5S 1m 145000526 CE • VOLEX M2511+HO3VV ‐ F+V AC5S 1m 145000525 Switzerland • VOLEX M ...
-
Lenovo U530 TOUCH - page 76
Lenovo IdeaPad U530 Touch Hardware Maintenance Manual 72 Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult your local Lenovo representative for information on the produc ts and servi ...
-
Lenovo U530 TOUCH - page 77
Lenovo IdeaPad U530 Touch 73 Any performance data contained herein was determined in a controlled environment. Therefore, the result obtained in other operating environments may vary significantly. Some measurements may have been made on ...
Avez-vous une question à propos de Lenovo U530 TOUCH?
Utiliser le formulaire ci-dessous
Si vous n’avez pas résolu votre problème avec Lenovo U530 TOUCH, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Lenovo U530 TOUCH il est probable qu’il a envie de partager la façon de le résoudre.