-
Tecumseh tecumsehpower engine operator - page 1
T ecumsehPower OVRM 120 Engine Operator’s Manual Four-Cycle Engine • V ertical Crankshaf t • Air-Cooled T able of Content s IMPORT ANT NOTICE! Safety Definit ions .................................. ...... ii I. General Safety Precautions ............................................. ................ 1 II. How to Get Service .................. ...
-
Tecumseh tecumsehpower engine operator - page 2
Page ii Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 IMPORT ANT NOTICE! Safety Definitions Statements in this manual preceded by the following wor ds and graphics are o f special significance: Or WARNING indicat es a potent ially hazardous situation which if NOT avoided, could result in death or ser ious injury. NOTE Refers ...
-
Tecumseh tecumsehpower engine operator - page 3
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 1 I. General Safety Precautions ! W ARNING A. A void Carbon Monoxide Poisoning All engine exhaust contain s carbon monoxide, a dead ly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, co nfusion and eventually death. Carbon monoxide is a col ...
-
Tecumseh tecumsehpower engine operator - page 4
Page 2 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 18 1-1216-14 E. DO NOT Modify Engine To avoid serio us injury or death, DO NOT modify engine in any way. Tampering with the governor setting can lead to a runaway engine and cause it to operate at unsa fe speeds. NEVER tamper with factory se tting of engi ne governor. ! W ARNING F . A ...
-
Tecumseh tecumsehpower engine operator - page 5
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 3 II. How to Get Service For engine adjustme nts, repairs or warranty service NOT covered in this manual, cons ult your loca l Authorized Tecumseh Servicing Dealer, call 1-800-5 58-5402, or go to www.Tecumse hPower.co m for additi onal informat ion. A. Engine Identification ...
-
Tecumseh tecumsehpower engine operator - page 6
Page 4 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 18 1-1216-14 III. Oil and Fuel S pecifications A. Oil To operate engine you ne ed to use a clean, high quality, detergent oil. Fo r recommended en gine oil, see Table 1. NOTES Be sure original cont ainer is marked A.P .I. Se rvice “SL/SJ”. Using multigrade o il above 32°F (0°C) w ...
-
Tecumseh tecumsehpower engine operator - page 7
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 5 B. Filling Oil Sump I. Oil Fill Cap With Dip stick If your engine has a dipstick go to step 1. If your engine does NOT have a dipstick, see "II. Oil Fill Cap Without Dipstick (Oil Fill Plug)" instructions below . 1. Be sure engine is upright and level. 2. Unscrew ...
-
Tecumseh tecumsehpower engine operator - page 8
Page 6 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 18 1-1216-14 C. Filling Fuel T ank An adult should fuel this engin e. NEVER allow children to refuel this engine. Gasoline (fuel) vapors are hig hly flammable and can explode . Fuel vapo rs can sprea d and be ig nited by a spark or flame many feet away from engine. To preven t injury o ...
-
Tecumseh tecumsehpower engine operator - page 9
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 7 V . St arting Y o ur Engine An adult should start the engine. Only allow children to start engine if an adult has determined they are exp erienced and capable of such operation. If you are unable to star t this engine after following instru ctions in this manual, contact y ...
-
Tecumseh tecumsehpower engine operator - page 10
Page 8 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 18 1-1216-14 NOTE DO NOT operate an electric st arter for more than 5 seconds each attempt. 5. Push starter button or turn ignition switch key to start engine. 6. When eng ine starts, release starter bu tton or igniti on switch key . 7. If engine fails to start af ter 3 attempt s repea ...
-
Tecumseh tecumsehpower engine operator - page 11
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 9 III. Primer Bulb and Choke In Temperatures above 40°F (5°C): Follow instructions in Section A .I. See "I. Primer Bulb Only" instructions on page 7. See Table 3 on page 7. In Temperatures below 40°F (5° C): 1. T o avoid carbon monoxide poisoning , be sure engi ...
-
Tecumseh tecumsehpower engine operator - page 12
Page 10 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 7. If engine fires but does NOT continu e to run, move engine thr ottle control to “F AST” position and start engine. 8. If engine fails to start af ter 3 attempts in the “F AST” position, move engine throttle contr ol to “CHOKE” position and start engine. 9. ...
-
Tecumseh tecumsehpower engine operator - page 13
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 11 3. When starting a cold en gine, push primer bulb firmly 3 times, allowing primer bulb to return completely to orig- inal position between pushes. See Figure 24. NOTES Be sure to c over vent hole w hen pressin g primer bulb . See Figure 24 . Cooler temperatur es may requi ...
-
Tecumseh tecumsehpower engine operator - page 14
Page 12 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 III. Primer Bulb and Choke In Temperatures above 40°F (5°C): Follow instructions in Section B .I. See "I. Primer Bulb Only" instructions on page 10. See Tab le 4 on page 10. In Temperatures below 40°F (5° C): 1. T o avoid carbon monoxide poisoning , be sure ...
-
Tecumseh tecumsehpower engine operator - page 15
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 13 VI. S topping Y our Engine and Short-T erm S torage Stop engine according to equipment manufa cturer’s instructions. To avoid unsupervised op eration of an engine, especially by children, NEVER leave it unattended when it is running. Always turn off the engine after use ...
-
Tecumseh tecumsehpower engine operator - page 16
Page 14 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 I. Oil Fill Cap With Dip stick If your engine has a dipstick go to step 1. If your engine does NOT have a dipstick, see "II. Oil Fill Cap Without Dipstick (Oil Fill Plug)" instructions on page 16. 1. Carefully disconnect spark plug wir e and keep it away from sp ...
-
Tecumseh tecumsehpower engine operator - page 17
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 15 5. Place approved recyclable oil container under oil drain plug, if present. See Figure 34 . 6. Remove oil drain plug, if present. 7. T ip engine to position the oil flow , so it will drain from the lowest point on the engine (see equipme nt manu- facturer ’s instructio ...
-
Tecumseh tecumsehpower engine operator - page 18
Page 16 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 II. Oil Fill Cap Without Dip stick (Oil Fill Plug) If your engine does NOT have a dipstick go to step 1. If your engine has a dipstick, see "I. Oil Fill Cap With Dipstick" instructions on page 14. 1. Carefully disconnect spark plug wir e and keep it away from sp ...
-
Tecumseh tecumsehpower engine operator - page 19
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 17 5. Place approved recyclable oil container under oil drain plug. 6. T ip engine to position the oil drain plug at the lowest point on the engine (see equipme nt manufacturer ’s instructions). See Figure 41. 7. Remove oil drain plug and drain oil into an approved recycla ...
-
Tecumseh tecumsehpower engine operator - page 20
Page 18 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 B. Removing Debris from Engine Before each use, remove the air cleaner cover . Discard grass clippings, dirt and debris from the followin g areas: • Levers and Linka ge • Cooling Fins • Air Intake Screen • Air Inlet • Guards Removing debris will insure adequate ...
-
Tecumseh tecumsehpower engine operator - page 21
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 19 II. Servicing Paper Filters Paper filters cannot b e cleane d and must be repla ced once a year or every 100 operat ing hours; more often if used in extremely dusty condition s. Replacement filters are available at an Authorized Tecumseh Servicing Dealer. Follow the instr ...
-
Tecumseh tecumsehpower engine operator - page 22
Page 20 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 E. Carburetor If you think your carburetor needs adjusting, see your nearest Authorized Tecumseh Ser vicing Dealer. Engine performance should NOT be affected at altitudes up to 7,000 feet (2,134 meters) . For operation at higher elevations, contact your Autho rized Tecums ...
-
Tecumseh tecumsehpower engine operator - page 23
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 21 IX. S toring Y our Engine A. Short-T erm/Seasonal Storage I. Clean Engine Before servicing the en gine remove the air cleaner cover and/or blower housing. Discard grass clippings, dir t and debris from the following areas: • Cooling Fins • Air Intake Screen • Levers ...
-
Tecumseh tecumsehpower engine operator - page 24
Page 22 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 II. Oil Cylinder Bore When lubricatin g cylinder bor e, fuel may spray from spar k plug hole. To prevent se rious injury fro m fuel fires, follow these instructions: 1. Carefully disconnect spark plug wir e and keep it away from spar k plug. See Figu res 49 and 50. See ? ...
-
Tecumseh tecumsehpower engine operator - page 25
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 23 X. Preventing Forest, Brush and Grass Fires Local, state and federal laws may require use of a spark arrester to prevent fires. For examp le, it is a violation of California Public Resource s Code (section 4442) to use or operate engine on any forest-cover ed, brush-cover ...
-
Tecumseh tecumsehpower engine operator - page 26
Page 24 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 Before Each Use Scheduled Maintenan ce Every 5 Hours or Before Each Use 1. Check Oil Level 2. Clean Cooling Fins Date____________ ___Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/D ...
-
Tecumseh tecumsehpower engine operator - page 27
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 25 Every 25 Hours or 3 Month s Scheduled Maintenance 1. Change Oil Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date____________ ___Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date______ ...
-
Tecumseh tecumsehpower engine operator - page 28
Page 26 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 ...
-
Tecumseh tecumsehpower engine operator - page 29
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 27 NOTES ...
-
Tecumseh tecumsehpower engine operator - page 30
Page 28 Four-Cycle Engine • Vertical Crankshaft • Air-Cooled 181-1216- 14 CALIFORNIA & US EP A EMISSION CONTROL W ARRANTY S T ATEMENT The U. S. Environmental Protection Agency (“EPA”), the California Air Resources Board (“CARB”) and Tecumseh Power Company are pl eased to explain the Federal and California Emission Control Systems Wa ...
-
Tecumseh tecumsehpower engine operator - page 31
181-1216-14 Fou r-Cycle Engine • Vertical Crankshaft • Air-Cooled Page 29 EMISSION CONTROL SYSTEM W ARRANTY Emission Contro l System Warr anty (“ECS Warranty”) for 1995 and later model year California small off-road engines (for other states, 1997 and later model year engi nes): A . APPLICABILITY : This warra nty shall apply to 1995 and lat ...
-
Tecumseh tecumsehpower engine operator - page 32
T ecumsehPower LIMITED WARRANTY FOR NE W TECUMSEH ENGINES AND ELECTRONIC IGNITION MODULES For the time period shown be low from the date of pur chase and su bject to the exceptions and limita tions described herei n, Tecum seh Power Company will, at its option as the exclusive remedy, either repair or repl ace for the original purchaser, free of ch ...
Avez-vous une question à propos de Tecumseh tecumsehpower engine operator?
Utiliser le formulaire ci-dessous
Si vous n’avez pas résolu votre problème avec Tecumseh tecumsehpower engine operator, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Tecumseh tecumsehpower engine operator il est probable qu’il a envie de partager la façon de le résoudre.