Français dropdown-ico

Manuel d’utilisation Empire Comfort Systems VFCM-25-3. VFCR-25-3

24 pages 2.7 mb
Télécharger

Aller à la page of 24

Summary
  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 1

    Page 1 16937-4-0806 I NST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL CAST IRON UNVENTED ROOM HEA TER MODELS VFCM-25-3 VFCR-25-3 VFCT -25-3 WAT E R V A P O R : A B Y- P R O D U C T O F UNVENTED ROOM HEA TERS W ater vapor is a by-product of gas combustion. An unve nted r oo m heater pr oduce s appr oxi matel y one (1) ounce (30ml) of water for ev ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 2

    Page 2 16937-4-0806 SECTION P AGE Important Safety Information ....................................................................................................................................................... 3 Safety Information for Users of LP Gas .............................................................................................. ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 3

    Page 3 16937-4-0806 When used without adequate combustion and ventilation air, heater may give off CARBON MONOXIDE, an odorless, poisonous gas. Do not install heater until all necessary provisions are made for combustion and ventilation air . Consult the writ- ten instructions provided with the heater for information concerning combustion and venti ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 4

    Page 4 16937-4-0806 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. Y ou must find out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detect that odor . Sometimes other odors in the area ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 5

    Page 5 16937-4-0806 INTRODUCTION I nstructions to Installer 1. Installer must leave instruction manual with owner after installation. 2. Installer must have owner fill out and mail warranty card supplied with unvented room heater . 3. Installer should show owner how to start and operate unven ted room heater . Always consult your local Building De ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 6

    Page 6 16937-4-0806 W A TER V APOR: A BY -PRODUCT OF UNVENTED ROOM HEA TERS W ater vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for every 1,000 BTU's (.3KW's) of gas input per hour . Unvented room heaters must be used as supplemental heat (a room) rather than a prima ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 7

    Page 7 16937-4-0806 GAS SUPPL Y Check all local codes for requirements, especially for the size and type of gas supply line required. Note: Never use plastic pipe. Check to confirm whether your local codes allow copper tubing or galvanized. Note: Since some municipalities have additional local codes, it is always best to consult your local authori ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 8

    Page 8 16937-4-0806 Figure 2 Figure 3 Figure 4 When facing the front of the appliance the following minimum clearances to combustible construction must be maintained. T op of appliance (ceiling) 36 inches Rear W all 3 inches Side W all 6 inches Heater Corners (45° angle) to W all 4 inches Floor 0 inches CLEARANCES Provide adequate clearances aroun ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 9

    Page 9 16937-4-0806 Figure 6 Figure 5 FLANGE TOW ARDS BACK DET AIL VIEW RIGHT SIDE REAR COVER LEFT SIDE (4) LEVELING BOL TS Figure 7 CASING BOTTOM ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 10

    Page 10 16937-4-0806 LOG PLACEMENT Every burner is shipped with a protective cover . This cover must be removed before log placement. The posi tio nin g of the logs is crit ic al to th e saf e and cl ean oper ati on of this heater . Sooting and other problems may result if the logs are not properly and firmly positioned in the appliance. PROPER IN ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 11

    Page 1 1 16937-4-0806 Proper Log Placement Log placement is critical to proper burner performance. Logs must be correctly positioned onto the burner . The photos in this manual show the proper pinned position for logs on this set. Owners need to be shown proper log placement and instructed not to move the logs. Logs must fit firmly onto the burne ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 12

    Page 12 16937-4-0806 VFCR -25, VFCT -25 PHOTOS ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 13

    Page 13 16937-4-0806 OPERA TION INSTRUCTIONS/FLAME APPEARANCE Flames from the pilot (rear right back side of the pan burner) as well as the main flame should be visually checked as the log set is installed. In normal operation at full rate after 10 to 15 minutes, the flame appearance should be sets of yellow flames. NOTE: all flames will be ran ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 14

    Page 14 16937-4-0806 FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly . B. BEFORE LIGHTING s ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 15

    Page 15 16937-4-0806 HI/LO REGULA TOR CONTROL KNOB PIEZO IGNITOR FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 16

    Page 16 16937-4-0806 FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly . B. BEFORE LIGHTING s ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 17

    Page 17 16937-4-0806 Figures 13 and 16 show a correct pilot flame pattern. The correct flame will be blue and will extend beyond the thermocouple. The flame will surround the thermocouple just below the tip. A slight yellow flame may occur where the pilot flame and main burner flame meet. Figures 14 and 17 show an incorrect pilot flame patte ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 18

    Page 18 16937-4-0806 PILOT FLAME CHARACTERISTICS (continued) Cleaning and Maintenance/Pilot Oxygen Depletion Sensor Pilot When the pilot has a large yellow tip flame, clean the Oxygen Depletion Sensor as follows: 1. Clean the ODS pilot by loosening nut B from the pilot tubing. When this procedure is required, grasp nut A with an open end wrench. 2 ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 19

    Page 19 16937-4-0806 MILLIVOL T OPERA TING INSTRUCTIONS VFCR-25 ON/OFF/REMOTE Switch VFCR-25 is equipped with an ON/OFF/REMOTE switch which is located on the wiring chase. A wire harness is attached to the ON/OFF/REMOTE switch. The brown, black and green (wires) female push-ons attach to the ON/OFF/REMOTE switch. At the opposit e end of the wire ha ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 20

    Page 20 16937-4-0806 OPERA TING GUIDELINES Before operating this heater , please review the safety warnings pages at the beginning of this manual and those precautions and warnings listed below . 1. Know what type of ignition system this model has (standing pilot) and follow the applicable SAFETY and LIGHTING instructions. 2. Check to ensure there ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 21

    Page 21 16937-4-0806 IMPOR T ANT : Operating heater where impurities in air exist may create odors. Cleaning supplies, paint, paint remover , cigarette smoke, cements and glues, new carpet or textiles, etc., create fumes. These fumes may mix with combustion air and create odors. 1. When ignitor button is pressed, there is no spark at ODS/pilot. a. ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 22

    Page 22 16937-4-0806 1 R-5029 CASTING TOP 2 R-5028 CASTING SIDE LEFT 3 R-5027 CASTING SIDE RIGHT 4 R-5026 CASTING FRONT 5 10659 CASING BOTTOM ASSEMBL Y 6 10541 CASING BACK USE ONL Y MANUF ACTURER'S REPLACEMENT P AR TS. USE OF ANY OTHER P AR TS COULD CAUSE INJUR Y OR DEA TH. Index Part No. Number Description VFCM-25, VFCR-25, VFCT -25 COMMON P ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 23

    Page 23 16937-4-0806 Parts can be ordered only through your service person or dealer . For best results, the service person or dealer should order parts through the distributor . Parts can be shipped directly to the service person/dealer . All parts listed in the Parts List have a Part Number . When ordering parts, first obtain the Model Number fr ...

  • Empire Comfort Systems VFCM-25-3. VFCR-25-3 - page 24

    Page 24 16937-4-0806 SER VICE NOTES Empire Comfort Systems, Inc. Nine Eighteen Freeburg A ve. Belleville, Illinois 62222-0529 PH: 1-800-851-3153 PH: 1-618-233-7420 F AX: 1-800-443-8648 F AX: 1-618-233-7097 E-MAIL: info@empirecomfort.com WEB SITE: www .empirecomfort.com ...

Fabricant Empire Comfort Systems Catégorie Electric Heater

Les documents que nous recevons du fabricant de l'appareilEmpire Comfort Systems VFCM-25-3. VFCR-25-3 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Empire Comfort Systems
- manuels d’utilisations VFCM-25-3. VFCR-25-3
- fiches produit Empire Comfort Systems
- dépliants
- ou étiquettes-énergie Empire Comfort Systems VFCM-25-3. VFCR-25-3
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Empire Comfort Systems VFCM-25-3. VFCR-25-3.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Empire Comfort Systems VFCM-25-3. VFCR-25-3, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Empire Comfort Systems VFCM-25-3. VFCR-25-3. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Empire Comfort Systems VFCM-25-3. VFCR-25-3.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Empire Comfort Systems VFCM-25-3. VFCR-25-3, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Empire Comfort Systems VFCM-25-3. VFCR-25-3 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Empire Comfort Systems VFCM-25-3. VFCR-25-3.

Le manuel d’utilisation complet Empire Comfort Systems, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Empire Comfort Systems VFCM-25-3. VFCR-25-3 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Empire Comfort Systems VFCM-25-3. VFCR-25-3, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lEmpire Comfort Systems VFCM-25-3. VFCR-25-3 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Empire Comfort Systems VFCM-25-3. VFCR-25-3 - qui devraient nous aider dans les premières étapes lors de l'utilisation Empire Comfort Systems VFCM-25-3. VFCR-25-3
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Empire Comfort Systems VFCM-25-3. VFCR-25-3
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Empire Comfort Systems VFCM-25-3. VFCR-25-3 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Empire Comfort Systems VFCM-25-3. VFCR-25-3?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Empire Comfort Systems VFCM-25-3. VFCR-25-3, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Empire Comfort Systems VFCM-25-3. VFCR-25-3 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)