Français dropdown-ico

Manuel d’utilisation Greenheck Outdoor Air Ventilator

20 pages 0.18 mb
Télécharger

Aller à la page of 20

Summary
  • Greenheck Outdoor Air Ventilator - page 1

    GREENHECK P .O. BOX 410 SCHOFIELD, WISCONSIN 54476-0410 PH. 715-359-6171 ® Installation, Operation and Maintenance Instructions for Neutralizer 100% Outdoor Air V entilators W ARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation, operating, and maintenance i ...

  • Greenheck Outdoor Air Ventilator - page 2

    2 T ABLE OF CONTENTS W arrant y ............................................................................................................ Pg. 2 Installation Instructions: N V -45 • Horizontal Discharg e ................................................................................ Pg. 3 • Downblast Discharg e .............................. ...

  • Greenheck Outdoor Air Ventilator - page 3

    INT AKE DISCHARGE DISCHARGE INT AKE C L C L Equipment Support Footprint C L A A ( fig. 4) Roof mounted arrangement HZ with weatherhood, mounted on three equipment supports. Ductwork is attached to discharge collar with rubber boot transition. ( fig. 5) Arrangement HZ shown as an indoor hanging installation with intake and discharge ductwork install ...

  • Greenheck Outdoor Air Ventilator - page 4

    4 B C L C* Rectangular Curb Footprint C L C L A A/2 A Roof Opening A/2 C* C* *C- Determine equal dimension for these 3 locations Sealant Ductwork Duct Adaptor Supply Ductwork by Others Step 1 Roof Opening Determine the center of the supply duct roof opening. The chart below shows the maximum recommended roof opening dimensions. These sizes can be s ...

  • Greenheck Outdoor Air Ventilator - page 5

    5 Model TSU Supply Unit Lifting Lugs (4 places) Step 5 Install Supply Unit Use a crane and a spreader bar hooked to the factory lifting lugs (as shown in the diagram) to lift and center the NV unit on the curb and equipment support. Use self-tapping sheet metal screws to fasten unit to the curb and equipment support through holes provided. Electric ...

  • Greenheck Outdoor Air Ventilator - page 6

    6 GREENHECK ® Before beginning this installation: Make sure that there is room to access the unit from all sides. Make sure inlet of unit is located well away from any exhaust fans. Installation Instructions for: SLAB, RAIL, AND CURB MOUNTING NV -90 and NV -120 w/Horizontal Dischar ge Lifting Lugs (4) Spreader Bar NV Unit Intake 1a. Slab Construct ...

  • Greenheck Outdoor Air Ventilator - page 7

    7 Rails located 6-12" in from sides of unit. Rails extend 6" from end of filter section Rails extends 6" from discharge end of unit Lifting Lugs (4) Spreader Bar 2. Rail Mounting For proper support, rails should be located 6-12" in from sides of unit and should extend at least 6" beyond both discharge end of unit and filter ...

  • Greenheck Outdoor Air Ventilator - page 8

    8 Straight A B C D Duct Length NV-90 16 1 / 4 24 34 1/ 2 22 3 / 8 81 NV-120 16 1 / 4 25 1 / 2 34 23 1 / 4 96 5. Attach Ductwork to Unit Discha r ge Chart and drawing below show opening size (ID) and location for discharge collar. Also included is the recommended straight duct lengths for optimal performance. Greenheck recommends attaching ductwork ...

  • Greenheck Outdoor Air Ventilator - page 9

    9 Installation Instructions for: CURB MOUNTING* NV -90 and NV -120 *For installations using Greenheck's optional roof curb. 1. Assemble Roof Curb Curbs are shipped knockdown and require assembly by others. Assembly instructions are also included with curb. Assemble curb sections as shown using hex bolts and lock nuts supplied with curb. Detail ...

  • Greenheck Outdoor Air Ventilator - page 10

    10 5. Install Unit. Use a crane and spreader bar to prevent damage to unit. Lifting lugs are provided as shown in illustration. It is highly recommended that all accessory items be lifted separately and attached after the unit is in place. Electrical and pipe connections can be made at this time. Lifting Lugs (2) Spreader Bar Butt units together Fa ...

  • Greenheck Outdoor Air Ventilator - page 11

    11 Weatherhood fastener locations typical for entire section. T op fasteners are accessed fr om outside, side and bottom fasteners are accessed from inside. Lifting Lugs (2) Spreader Bar 7. Attach W eatherhood Use a crane and spreader bar hooked to factory lifting lugs (as shown in diagram) to lift and center the weatherhood on the filter section ( ...

  • Greenheck Outdoor Air Ventilator - page 12

    12 Sequence for wiring NV unit: For units without contr ol centers: The motor nameplate is to be used for determining the voltage and amperage required by the unit. For units with control centers: 1. The unit’s nameplate states the voltage and total amperage required. The main feeder supplying power to the unit should be sized for the label’s v ...

  • Greenheck Outdoor Air Ventilator - page 13

    SYSTEM ST AR TUP For proper unit function and safety, follow everything in this startup procedure in the order presented. This is to be done after the electrical connections are complete. • Voltage meter • Incline manometer or equivalent Special T ools Requir ed • Tachometer • Thermometer • Amperage meter 1. Check V oltage Before starting ...

  • Greenheck Outdoor Air Ventilator - page 14

    14 Steam Coils Application Recommendations: Satisfactory operation and service life are best ensured when coils are installed with proper piping, trap, and support arrangement. The following notes and figure 1 ( page 15 ) are recommended for the coil unit installation and operation. General: 1. Provide separate supports and hangers for the unit and ...

  • Greenheck Outdoor Air Ventilator - page 15

    15 Steam Main Return Main Gate V alve Control V alve, Modulating T wo-Position Check V alve-V acuum Breaker Float and Thermostat T rap Strainer Dir ect Expansion Coils Application Recommendations: 1. Piping should be in accordance with accepted industry standards. 2. The condensate drain pipe should be sized adequately to ensure the condensate drai ...

  • Greenheck Outdoor Air Ventilator - page 16

    16 Coil Maintenance Filters: Filters upstream of the coil should be checked regularly for dirtiness and clogging. If the filters are dirty, they should be cleaned or replaced. It is important that the coils stay clean to maintain maximum heat transfer capability. Cleaning: 1. Coils must be clean to obtain maximum performance. Soiled fins reduce the ...

  • Greenheck Outdoor Air Ventilator - page 17

    17 TROUBLE SHOOTING Blower Unit Symptom Possible Cause Corrective Action Blower fails Blown fuse or open circuit breaker Replace fuse or reset circuit breaker and to operate check amps Broken fan belt Replace Defective motor or capacitor Replace Motor starter overloaded Reset starter and check amps Motor overamps CFMs too high Check CFMs and adjust ...

  • Greenheck Outdoor Air Ventilator - page 18

    18 General Dimensions and W eights PLAN VIEW Motor Control Center Optional Filter/Heating Section Optional Heating Coil Cooling Coil 110 1 / 2 ELEV A TION VIEW 88 Optional Curb or Support Blower/Motor Access Door 50 1 / 2 17 46 1 / 4 Optional Weatherhood 50 1 / 2 (NV -90) 62 (NV -120) Optional Inlet Damper Optional Motorized Damper PLAN VIEW Heat P ...

  • Greenheck Outdoor Air Ventilator - page 19

    19 Maintenance Greenheck recommends these procedures to insure trouble free operation of this unit. Most unit failures can be attributed to poor setup or poor maintenance. A record of maintenance performed on this unit should be kept. This information will provide essential information if problems are encountered. A section at the back of this manu ...

  • Greenheck Outdoor Air Ventilator - page 20

    20 Job Information Job Name: ________________________________________ Address: _________________________________________ City: ________________ State: ________ Zip: __________ Phone: __________________ Fax: ____________________ Contact Person: ___________________________________ Service Organization: ______________________________ Address: ________ ...

Fabricant Greenheck Catégorie Ventilation Hood

Les documents que nous recevons du fabricant de l'appareilGreenheck Outdoor Air Ventilator peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Greenheck
- manuels d’utilisations Outdoor Air Ventilator
- fiches produit Greenheck
- dépliants
- ou étiquettes-énergie Greenheck Outdoor Air Ventilator
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Greenheck Outdoor Air Ventilator.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Greenheck Outdoor Air Ventilator, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Greenheck Outdoor Air Ventilator. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Greenheck Outdoor Air Ventilator.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Greenheck Outdoor Air Ventilator, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Greenheck Outdoor Air Ventilator par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Greenheck Outdoor Air Ventilator.

Le manuel d’utilisation complet Greenheck, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Greenheck Outdoor Air Ventilator - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Greenheck Outdoor Air Ventilator, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lGreenheck Outdoor Air Ventilator qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Greenheck Outdoor Air Ventilator - qui devraient nous aider dans les premières étapes lors de l'utilisation Greenheck Outdoor Air Ventilator
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Greenheck Outdoor Air Ventilator
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Greenheck Outdoor Air Ventilator dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Greenheck Outdoor Air Ventilator?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Greenheck Outdoor Air Ventilator, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Greenheck Outdoor Air Ventilator il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)