Manuel d’utilisation Eaton Electrical 110

12 pages 0.4 mb
Télécharger

Aller à la page of 12

Summary
  • Eaton Electrical 110 - page 1

    No. 7-309 August, 1999 Char -L ynn ® Power Steering 110, 230 and 450 Series Steering Control Units Repair Information 001 002 ...

  • Eaton Electrical 110 - page 2

    110, 230, and 450 Series Steering Control Units 2 See Note Below (lower right) Cast End Cap Special Tools Available 600057-000 Spring Installation Tool 5422-000 12 Point Drive Socket ( 5/16 in.) — -001 64489-000 6 Point (E10) Torx Drive Socket ( 5/16 in.) — -002 Note: Current -002 uses a Hex Head bolt – 1/2 inch across flats O-ring Groove Cap ...

  • Eaton Electrical 110 - page 3

    110, 230, and 450 Series Steering Control Units 3 Tools required for disassembly and reassembly. — Screwdriver (102-152 mm [4 in. - 6 in.] long, x 3 mm [118 in.] wide flat blade). — 6 Point (E10) Drive part No. 64489-000* or 1/2 inch socket for current hex head cap screws. — Breaker bar wrench. — Torque wrench (30 Nm [275 lb-in] capacity). ...

  • Eaton Electrical 110 - page 4

    110, 230, and 450 Series Steering Control Units 4 Cleanliness is extremely important when repairing a steering control unit. Work in a clean area. Before disconnecting lines, clean port area of unit thoroughly. Use a wire brush to remove foreign material and debris from around exterior joints of the unit. Although not all drawings show the unit in ...

  • Eaton Electrical 110 - page 5

    110, 230, and 450 Series Steering Control Units 5 12 Carefully remove anti-cavitation valves and manual steering check valve (roll pin and ball – if applicable) from bolt holes by tipping housing as shown (see figure 5). Control End Seal Gland Bushing Special Seal Gland Marked with Groove for Identification Replacement Teflon Seal (1 Piece) Sprin ...

  • Eaton Electrical 110 - page 6

    110, 230, and 450 Series Steering Control Units 6 17 Remove two bearing races and needle thrust bearing and seal from spool and sleeve assembly. 18 Tip housing onto port face. Remove spool and sleeve assembly from 14 hole end of housing (Figure 10). Attention: Do not bind spool and sleeve in housing. Rotate spool and sleeve assembly slowly when rem ...

  • Eaton Electrical 110 - page 7

    110, 230, and 450 Series Steering Control Units 7 Low T orque Spring Spacers (2) Standard T orque 23 Screw a #10-24 machine screw into end of check ball seat. Then lift seat out of housing by pulling on screw with pliers. 24 Remove two seals from check valve seat. 25 Tip housing to remove check ball and check ball retainer. 26 Do not remove any val ...

  • Eaton Electrical 110 - page 8

    110, 230, and 450 Series Steering Control Units 8 spring slots of spool and sleeve. Position centering springs on bench so that extended edge is down and arched center section is together (figure 15). Next, with spring notches facing sleeve, insert one end of entire spring set into spring installation tool. 8 Compress extended end of centering spri ...

  • Eaton Electrical 110 - page 9

    110, 230, and 450 Series Steering Control Units 9 17 Install retaining ring in housing (figures 19 and 20). After installing ring, pry around ring circumference with screwdriver to properly seat ring in groove. 18 Clamp housing in vise, as shown in Figure 21. Clamp lightly on edges of mounting area; do not overtighten jaws. Note: Check to insure th ...

  • Eaton Electrical 110 - page 10

    110, 230, and 450 Series Steering Control Units 10 23 Lubricate and install 72,6 mm [2.86 in.] ID seal in spacer plate or gerotor (meter), (ref.) see note page 2. The lubrication will hold seal in place. 24 Align star valleys (reference A) with marked drive (reference B). Valleys must align with pin. Note parallel relationship of reference lines A, ...

  • Eaton Electrical 110 - page 11

    110, 230, and 450 Series Steering Control Units 11 28 Install 7 dry cap screws (and seal washers if applicable – see figure 26) in end cap. Pretighten screws to 17 Nm [150 lb-in], then torque screws to 25-30 Nm [225-275 lb-in] in sequence shown in figure 27. Eaton Corp. Hydraulics Div. Eden Prairie, MN 55344 Char-Lynn ® 000-0000-000 000-0000-000 ...

  • Eaton Electrical 110 - page 12

    Form No. 7-309 Copyright Eaton Corporation, 1981, 1988, 1993, and 1999 All Rights Reserved Printed in USA Each Order Must Include the Following: How to Order Replacement Parts 1. Product Number 2. Date Code 3. Part Name 4. Part Number 5. Quantity of Parts For additional literature contact Eaton Corp. Hydraulics Division 15151 Highway 5 Eden Prairie ...

Fabricant Eaton Electrical Catégorie Power Supply

Les documents que nous recevons du fabricant de l'appareilEaton Electrical 110 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Eaton Electrical
- manuels d’utilisations 110
- fiches produit Eaton Electrical
- dépliants
- ou étiquettes-énergie Eaton Electrical 110
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Eaton Electrical 110.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Eaton Electrical 110, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Eaton Electrical 110. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Eaton Electrical 110.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Eaton Electrical 110, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Eaton Electrical 110 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Eaton Electrical 110.

Le manuel d’utilisation complet Eaton Electrical, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Eaton Electrical 110 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Eaton Electrical 110, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lEaton Electrical 110 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Eaton Electrical 110 - qui devraient nous aider dans les premières étapes lors de l'utilisation Eaton Electrical 110
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Eaton Electrical 110
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Eaton Electrical 110 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Eaton Electrical 110?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Eaton Electrical 110, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Eaton Electrical 110 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Commentaires (0)