-
Harley-Davidson B9784 - page 1
Owner's Manual with Assembly Instructions For Models B3160 and B9784 B3160 B9784 Harley-Davidson is a registered trademark and the motorcycle sound is a trademark of H-D Michigan, Inc. used under license. Fisher-Price, P ower Wheels by Fisher-Price and Pow er Lock are U .S. tr ademarks of Mattel, Inc. Product features ma y vary from the pictur ...
-
Harley-Davidson B9784 - page 2
2 Ta bl e of Contents Impor tant Inf ormation A Impor tant Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 B Wa r nings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
-
Harley-Davidson B9784 - page 3
3 CA UTION • In the unassembled state , this package contains small par ts. Adult assembly is required. • Use the charger in dr y locations only . W ARNING • Prevent Injuries and Deaths • Direct Adult Super vision Required • K eep Children Within Safe Riding Areas . These areas must be: - aw ay from s wimming pools and other bodies of wat ...
-
Harley-Davidson B9784 - page 4
4 Steering Bushing - 2 Steering Stop Pa r t s C Rear Wheel • If you e xper ience a problem with this product, or are missing a part, please call us at 1-800-348-0751, r ather than retur n this product to the store. • Please identify all par ts before assemb ly and sav e all packaging material until assembly is complete to ensure that no par ts ...
-
Harley-Davidson B9784 - page 5
5 Exhaust Pipe Set Pa r t s T achometer Housing Sound Bo x T achometer Cov er F ront Fork Cov er T ank Seat F ront Fork Headlight Lens Headlight Housing Right - Outer Half Left - Outer Half Right - Inner Half Left - Inner Half ...
-
Harley-Davidson B9784 - page 6
6 Handgrip - 2 Handlebar Har ness Pa r t s Right Shock Set Left Shock Set Inner Outer Inner Outer Left Handlebar Right Handlebar T assel - 2 Left Strut Signal Housing - 2 Switch Cov er Right Strut Signal Lens - 2 Wheel Axle - 2 Fo rk Axle Wire Cov er Batter y Clamp ...
-
Harley-Davidson B9784 - page 7
7 12 V olt Batter y Extended He x Bushing - 2 Not Shown: Label Sheet 12-VOL T CHARGER 12 V olt Charger Pb Axle Bushing - 2 Pa r t s All Shown Actual Size .354 (Small Diameter) Cap Nut - 2* .437 (Large Diameter) Cap Nut - 4* *F or your con venience , two extra .437 (large diameter) cap n uts, one e xtra .354 (small diameter) cap nut, one e xtra #8 x ...
-
Harley-Davidson B9784 - page 8
8 T M Pa r ts Diagram D 1. V ehicle F rame 2. V ehicle Body 3. Seat 4. Rear Wheel 5. T ank 6. Left F ootboard 7. Exhaust - Inner Half - 2 8. Exhaust - Outer Half - 2 9. 12 V olt Batter y 10. Axle Bushing - 2 11. He x Bushing - 2 12. Wheel Axle - 2 13. T assel - 2 14. Steering Bushing - 2 15 Headlight Lens 16. Headlight Housing 17. Left Handlebar 18 ...
-
Harley-Davidson B9784 - page 9
9 Battery Charging E Important Notes •Y our new battery must be c harged for at least 18 hours bef ore you use it in y our vehicle f or the first time. •W e recommend that you start charging your batter y bef ore beginning assembly of y our new v ehicle. •T he batter y must be upright while charging. • The charger is not a to y . • Do not ...
-
Harley-Davidson B9784 - page 10
10 Battery Charging T M Pb • Plug the charger connector into the batter y . • Plug the charger into a standard 120 volt w all outlet . Note: If power flo w to the wall outlet is controlled by a s witch, make sure the s witch is “ON”. •B ef ore first-time use, charge the battery for at least 18 hours. Ne ver charge the battery longer than ...
-
Harley-Davidson B9784 - page 11
11 Assembl y F Children can be har med by small par ts, shar p edges and shar p points in the v ehicle’ s unassembled state , or by electrical items. Care should be tak en in unpacking and assemb ly of the vehicle . Children should not handle par ts, including the batter y , or help in assembly of the v ehicle. W ARNING T M • Lift to remov e th ...
-
Harley-Davidson B9784 - page 12
12 Assembl y T M • Fit the motor har ness between the v ehicle body tabs. Motor Har ness Ta b Ta b T op View • Fit the tabs on the left f ootboard into the slots in the left side of the vehicle fr ame. Make sure both tabs are in the slots. Hint: Y ou ma y need to squeeze the left f ootboard in order to align the tabs with the slots. •I nser t ...
-
Harley-Davidson B9784 - page 13
13 Assembl y T M Right Exhaust Pipe - Outer Half • Fit the outer half of the right exhaust pipe (R) to the inner half of the right exhaust pipe . Hint: Use a long-shaft Phillips screwdriv er to complete this assembly step . • Align the holes in the inner half of the right exhaust pipe with the holes in the vehicle fr ame. •I nser t four #8 x ...
-
Harley-Davidson B9784 - page 14
Assembl y 15 Strut Rear F ender #8-32 x 1 5 / 8 " Machine Screw #8-32 x 3 / 4 " Machine Screw • First, inser t a #8-32 x 1 5 / 8 " machine screw through the hole in the side of the right str ut that is closest to the rear of the vehicle body , as shown . • Attach an #8-32 acorn nut to the end of the screw , inside the rear f ende ...
-
Harley-Davidson B9784 - page 15
15 Assembl y • Slide an axle bushing, flat side first , on the wheel axle . Axle Bushing Flat Side Wheel Axle Rear Wheel He x Bushing He x Bushing • Fit two he x bushings, barrel side first, into the hole in the rear wheel. • Separate the f or k axle from the two wheel axles. (The fo rk axle is shor ter than the wheels axles.) Set the f ork a ...
-
Harley-Davidson B9784 - page 16
16 Assembl y T M Steering Bushing V ehicle Fr ame Neck •P osition the v ehicle frame so that the front faces y ou. • Fit a steering bushing underneath the neck of the v ehicle fr ame. •I nser t a #8 x 3 / 4 " screw into each end of the steering b ushing and tighten. Front Vie w 21 • Fit the headlight lens onto the headlight housing. ? ...
-
Harley-Davidson B9784 - page 17
17 Assembl y Wire Cov er Switch Switch Pe g Switch Cov er • Fit the wrapped por tion of the handlebar har ness into the wire cov er . • Fit the tab on the wire cov er into the notch in the switch to lock the tw o par ts together . Handlebar Harness 25 Right Handlebar • Locate the right handlebar . The r ight handlebar has an additional hole i ...
-
Harley-Davidson B9784 - page 18
18 Assembl y T assel Staple Handgrip • Using a slotted screwdriv er , push the staple in the center of a tassel into the hole in the end of a handgrip . • Repeat this procedure to attach the other tassel to the other handlebar . 29 Plug Fo r k C ov e r •P osition the front f or k so that it is upright and facing y ou. •I nser t the handleba ...
-
Harley-Davidson B9784 - page 19
19 Assembl y • Fit the handlebar har ness plug up through the rectangular hole in the vehicle body . TM Handlebar Har ness Plug Rectangular Hole T M See Inset Handlebar Har ness Plug Rectangular Hole 35 • Align the screw holes in each handlebar with the scre w holes in the front f ork. • First, inser t two #8 x 3 / 4 " screws through the ...
-
Harley-Davidson B9784 - page 20
20 Assembl y .354 (Small Diameter) Cap Nut Fo rk Axle • Place a .354 (small diameter) cap nut on a flat surf ace, inside up . Fit the end of the f ork axle into the cap nut. •T ap the opposite end of the fork axle with a hammer to secure the cap nut on the axle. Pull on the cap nut to make sure it is securely assemb led. .354" .354 Cap Nut ...
-
Harley-Davidson B9784 - page 21
21 •I nser t the handlebar har ness into the wire clip on the side of the v ehicle body . Assembl y T M Wire Clip Handlebar Har ness See Inset Wire Clip Handlebar Har ness 41 T M • Slide the f ork axle up through the bottom of the front fo r k, through the frame neck and steering stop , and out the top of the front f ork. • Fit a .354 (small ...
-
Harley-Davidson B9784 - page 22
22 Assembl y T M •I nser t a #8 x 3 / 4 " screw through the hole in each side of the tank and tighten. Hint: To replace the batteries in the sound bo x, simply remov e the screws from the tank and remov e the tank from the vehicle fr ame. After replacing the batter ies, be sure to replace the sound bo x, tank and screws . T ank V ehicle Fr a ...
-
Harley-Davidson B9784 - page 23
23 • Slide the f ender onto the ends of the handlebars. Make sure the pegs on the f ender slide ov er the tabs on the front f ork. Handlebar F ront Fo r k T abs F ront Fo r k T abs Handlebar F ender Assembl y 48 T M • Fit the tachometer to the f ork cover . •I nser t two #8 x 3 / 4 " screws into the tachometer and tighten. T achometer Fo ...
-
Harley-Davidson B9784 - page 24
24 • Fit two e xtended hex b ushings, he x side first, into the hole in the front wheel. Extended He x Bushing Extended He x Bushing F ront Wheel Assembl y • While holding the e xtended hex b ushings in place, position the front wheel between the shoc ks. • Being careful to keep the shoc ks correctly positioned, align the holes in the shocks ...
-
Harley-Davidson B9784 - page 25
25 • Continue to slide the wheel axle through the e xtended he x bushing, wheel, e xtended hex b ushing and then the shock. • Fit a .437 (large diameter) cap nut on the end of the wheel axle. • Suppor t the opposite end of the wheel axle and tap the cap nut with a hammer to secure it on the end of the wheel axle. • Pull on the .437 cap nut ...
-
Harley-Davidson B9784 - page 26
26 Label Decoration - Model B3160 G Proper label application will help to keep the labels looking their best! When applying labels, keep the follo wing guidelines in mind: •W ash y our hands before applying the labels . • Bef ore applying the labels, wipe the surf ace of the vehicle with a clean, dr y cloth to remov e any dust or oils . • Pla ...
-
Harley-Davidson B9784 - page 27
Label Decoration - Model B3160 T M Left Side Right Side 27 5 4 7 27 30 18 28 29 19 31 6 13 14 10 ...
-
Harley-Davidson B9784 - page 28
28 Label Decoration - Model B9784 Proper label application will help to keep the labels looking their best! When applying labels, keep the follo wing guidelines in mind: •W ash y our hands before applying the labels . • Bef ore applying the labels, wipe the surf ace of the vehicle with a clean, dr y cloth to remov e any dust or oils . • Place ...
-
Harley-Davidson B9784 - page 29
Label Decoration - Model B9784 T M Left Side Right Side 29 5 6 27 30 18 28 29 19 31 7 13 14 10 4 ...
-
Harley-Davidson B9784 - page 30
30 T M IMPORT ANT! Use only P ower Wheels ® 12 volt batter y . Use of any other battery will damage your v ehicle. Make sure that you charge the battery for at least 18 hours using the enclosed P ower Wheels ® 12 volt charger bef ore operating your vehic le for the first time. Charge the batter y f or at least 14 hours after each use of the vehic ...
-
Harley-Davidson B9784 - page 31
31 If a battery leak develops, av oid contact with the leaking acid and place the damaged batter y in a plastic bag. See inf or mation below f or proper disposal. If acid comes in contact with skin or eyes, flush with cool water f or at least 15 minutes and call a physician. If acid is internally ingested , giv e water , milk of magnesia or egg whi ...
-
Harley-Davidson B9784 - page 32
32 Rules f or Safe Driving K T each Safety Rules to Children While children can quickly de velop the skill necessary to drive this v ehicle, it is impor tant to remember that their judgment skills are still ve r y immature. Unsuper vised driving by children can lead to serious injur y . Before children use this vehicle , an adult should carefully e ...
-
Harley-Davidson B9784 - page 33
33 Re verse • Press the DRIVE b utton on the tank. • Press the f oot pedal. The v ehicle drives f orward at a maximum of 2 1 / 2 mph. • Help your child pr actice steering to lear n how far and how quic kly to tur n the handlebar when driving forw ard in low speed. •Y our vehicle has a patented, electronic br aking system that automatically ...
-
Harley-Davidson B9784 - page 34
34 Po w er Boost Button • Press the power boost b utton to shift the vehicle into high speed. The vehicle mov es forward at a maxim um of 5 mph. • Help your child pr actice steering to lear n how far and how quic kly to tur n the handlebar when driving forw ard in high speed. Ho w to Operate Y our V ehic le Bumper -to-Bumper* Limited W arranty ...
-
Harley-Davidson B9784 - page 35
35 Problem Possible Cause Solution V ehicle does not r un Undercharged battery Charge the battery . A new batter y should hav e been charged for at least 18 hours bef ore using the vehicle f or the first time. After first-time use, recharge the battery for at least 14 hours after each use. Nev er charge the batter y longer than 30 hours. Check all ...
-
Harley-Davidson B9784 - page 36
36 V ehicle was running but Loose wire or loose connectors Chec k all wires and connectors. Make sure the motor suddenly stopped harness connector is tightly plugged into the batter y , and that there are no loose wires around the motors. Tr ipped thermal fuse Each P ower Wheels ® 12 volt batter y has a built-in thermal fuse. A thermal fuse may &q ...
-
Harley-Davidson B9784 - page 37
37 V ehicle r uns sluggishly (cont.) Battery needs charging Be sure to charge the battery after each use. Battery is old and will not accept Even with proper care , a rechargeable battery does not accept full charge last f ore ver . A verage battery life is 1 to 3 y ears depending on vehicle use and use conditions . Replace only with Po w er Wheels ...
-
Harley-Davidson B9784 - page 38
38 ...
-
Harley-Davidson B9784 - page 39
39 ...
-
Harley-Davidson B9784 - page 40
Printed in Mexico B3160pr-0920 If y ou are missing par ts or need assistance, please call us toll-free: Po wer Wheels ® Consumer Relations 1-800-348-0751 8 AM - 6 PM EST , Monda y through Frida y . Over 400 A uthoriz ed Service Centers! Visit us on-line at www .powerwheels.com f or the location nearest y ou. Or contact your local, independentl y o ...
Avez-vous une question à propos de Harley-Davidson B9784?
Utiliser le formulaire ci-dessous
Si vous n’avez pas résolu votre problème avec Harley-Davidson B9784, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Harley-Davidson B9784 il est probable qu’il a envie de partager la façon de le résoudre.