Manuel d’utilisation Amtrol TD-41ZDW

16 pages 0.4 mb
Télécharger

Aller à la page of 16

Summary
  • Amtrol TD-41ZDW - page 1

    BOILER MA TE TM TOP-DOWN INDIRECT -FIRED W A TER HEA TERS WITH TOP-MOUNTED COIL The heat transfer medium should be water . If any product other than water is used, it must be a non-toxic fluid suitable for human ingestion as determined by the FDA Y our AMTROL BOILER MA TE™ has been carefully assembled and factory tested. T o enjoy the full servic ...

  • Amtrol TD-41ZDW - page 2

    -2- 1. GENERAL SAFETY INFORMA TION ...................................................................................... 3 2. PRE-INST ALLA TION CHECKLIST ........................................................................................ 4 Important Steps and Decisions Required Befor e Installation 3. REQUIRED COMPONENTS AND ACCESSORIES CHEC ...

  • Amtrol TD-41ZDW - page 3

    -3- IMPOR T ANT GENERAL SAFETY INFORMA TION - ADDITIONAL SPECIFIC SAFETY ALER TS APPEAR IN THE FOLLOWING INSTRUCTIONS EXPLOSION HAZARD: DO NOT INST ALL TO A HIGH PRESSURE STEAM BOILER (greater than 15 psig). AN EXPLOSION COULD OCCUR. EXPLOSION HAZARD. THE PRESSURE OF THE HEA T TRANSFER MEDIUM MUST BE LIMITED TO A MAXIMUM OF 30 PSIG BY AN APPROVED S ...

  • Amtrol TD-41ZDW - page 4

    -4- j THIS PRODUCT MUST BE INST ALLED AND MAINT AINED BY A LICENSED PROFESSIONAL. IN ADDITION TO THE INSTRUCTIONS IN THIS MANUAL, FOLLOW ALL APPLICABLE LOCAL AND ST A TE CODES OR IN THE ABSENCE OF SUCH CODES, THE CURRENT EDITIONS OF THE NA TIONAL PLUMBING CODE AND THE NA TIONAL ELECTRIC CODE. j DRIP P AN AND DRAIN: T o avoid leaking and/or property ...

  • Amtrol TD-41ZDW - page 5

    -5- TD-7Z, TD-41Z, TD-7ZDW , TD-41ZDW COMPONENTS CHECKLIST The following is a checklist of components requir ed for proper installation of these BOILER MA TE™ models, both Priority and Non-Priority: A. Separate circulator • 1 each - circulator (4-8 gpm) • 1 each - positive shut-of f weighted check valve B. Use of heating system zone cir culat ...

  • Amtrol TD-41ZDW - page 6

    -6- A. General Installation Requir ements 1. Do not "short circuit" the boiler Do not connect boiler supply and return lines to the same section or in the same flow circuit in a boiler , because the boiler water returning from the BOILER MA TE™ will "short circuit" and exit the boiler too cold for pr oper heat transfer . 2. Av ...

  • Amtrol TD-41ZDW - page 7

    -7- B. PIPING PIPING SHOULD BE ACCOMPLISHED WITH UNIONS. Step 1 - Locate the BOILER MA TE™ near boiler . Step 2 - Connect the cold water piping. a. Shut off the cold water supply at the main shut-of f valve. b. Drain existing domestic water system. Open 1 or more system faucets to pr event vacuum. c. When the system is drained, for boilers that h ...

  • Amtrol TD-41ZDW - page 8

    -8- Step 5 - Connect boiler supply pipe. Figure 1. a. Shut off the cold water supply valve to the boiler , and drain it using a hose attached to the drain valve at the boiler . b. When the boiler system piping is drained, cut the piping to accommodate the supply line tee. Install the tee between the boiler supply outlet and any system zone valve or ...

  • Amtrol TD-41ZDW - page 9

    -9- the service switch). c. Switch of f the branch cir cuit breaker . Step 2 - Remove electrical box cover . Step 3 - Remove existing wir e fr om boiler aquastat terminal C1 and connect to terminal #2 on DPDT relay . Step 4 - Install wire fr om DPDT relay terminal #1 to boiler aquastat terminal C1. Step 5 - Connect terminals of 4 and 6 of DPDT rela ...

  • Amtrol TD-41ZDW - page 10

    -10- ...

  • Amtrol TD-41ZDW - page 11

    - 11 - The BOILER MA TE™ is intended to pr ovide a tank service life of many years. Components, however , may be subject to failur es that requir e service. Failure to use the corr ect procedur es or parts in these circumstances may make the unit unsafe. • DO NOT OPEN DOWN-STREAM FIXTURE IF YOU HA VE LOOSENED THE TOP CONNECTIONS. • DO NOT OVE ...

  • Amtrol TD-41ZDW - page 12

    -12- RESIDENTIAL BOILER MA TE™ CLASSIC (TD-7Z and TD-41Z) ELECTROCUTION HAZARD. THE BOILER MA TE™ MUST BE ELECTRICALL Y GROUNDED. NOTES: 1. THE BOILER MA TE™ MUST BE ELECTRI- CALL Y GROUNDED AND INST ALLED IN ACCORDANCE WITH LOCAL CODES, OR IN THE ABSENCE OF LOCAL CODES, WITH THE NA TIONAL ELECTRIC CODE. 2. HEA T EXCHANGER P ACKAGE INCLUDE IT ...

  • Amtrol TD-41ZDW - page 13

    - 13 - PROBLEM CAUSE SOLUTION 1. No hot water at faucet. 1. Boiler does not operate. 1. a. Press reset button on boiler . b. Check main cut-off switch. c. Check fuse. 2. Circulator does not operate. 2. a. Check power supply . b. Check shaft coupling. c. Check impeller for locking. 3. Improper BOILER MA TE™ 3. Set BOILER MA TE™ temperature to se ...

  • Amtrol TD-41ZDW - page 14

    -14- DA TE SERVICE PERFORMED COMMENTS CONTRACTOR 9. SERVICE RECORD ...

  • Amtrol TD-41ZDW - page 15

    AMTROL ® BOILERMA TE ™ CLASSIC AND TOP-DOWN™ LIMITED PRODUCT WARRANTY This W arranty cannot be transferred - it is extended only to the original Purchaser or First User of the Product. By accepting and keeping this Product you agree to all of the warranty terms and limitations of liability described below . I MPOR T ANT W ARNING: READ CAREFULL ...

  • Amtrol TD-41ZDW - page 16

    West W arwick, Rhode Island 02893 Part #: 9040-628 REV B (7/04) -16- ...

Fabricant Amtrol Catégorie Electric Heater

Les documents que nous recevons du fabricant de l'appareilAmtrol TD-41ZDW peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Amtrol
- manuels d’utilisations TD-41ZDW
- fiches produit Amtrol
- dépliants
- ou étiquettes-énergie Amtrol TD-41ZDW
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Amtrol TD-41ZDW.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Amtrol TD-41ZDW, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Amtrol TD-41ZDW. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Amtrol TD-41ZDW.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Amtrol TD-41ZDW, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Amtrol TD-41ZDW par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Amtrol TD-41ZDW.

Le manuel d’utilisation complet Amtrol, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Amtrol TD-41ZDW - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Amtrol TD-41ZDW, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lAmtrol TD-41ZDW qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Amtrol TD-41ZDW - qui devraient nous aider dans les premières étapes lors de l'utilisation Amtrol TD-41ZDW
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Amtrol TD-41ZDW
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Amtrol TD-41ZDW dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Amtrol TD-41ZDW?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Amtrol TD-41ZDW, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Amtrol TD-41ZDW il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Commentaires (0)