Français dropdown-ico

Manuel d’utilisation FMI BVC-36Y

44 pages 3.77 mb
Télécharger

Aller à la page of 44

Summary
  • FMI BVC-36Y - page 1

    FIREBO X MODELS BV C-36Y , BV C-42Y AND BVC-50Y NA TURAL GAS MODULE MODELS BBM-36N-TKA, BBM-42N-TKA AND BBM-50N-TKA PROP ANE/LP MODULE MODELS BBM-36P-TKA, BBM-42P-TKA AND BBM-50P-TKA SPLIT BRICK P ANELS WITH BRICKS SERIES MBK-36,42,50(SS) (SH)-(R)I) MASONR Y RADIANT GAS FIREPLACE WITH ELECTRONIC IGNITION OWNER’S OPERA TION AND INST ALLA TION MANU ...

  • FMI BVC-36Y - page 2

    www .fmiproducts.com 122280-01E 2        -         ...

  • FMI BVC-36Y - page 3

    www .fmiproducts.com 122280-01E 3 SAFETY W ARNING: This product con -         ? ...

  • FMI BVC-36Y - page 4

    www .fmiproducts.com 122280-01E 4 1 1. Keep the area arou nd y our repl ace clear of combustible materials, gasoline and other ammable vapor and liquids. Do not run re place where t hese a re use d or st ored . Do not pl ace it ems su ch as clo thin g or decorations on or around replace. 12. Do not use this replace to cook food or bu ...

  • FMI BVC-36Y - page 5

    www .fmiproducts.com 122280-01E 5 INTRODUCTION Models BBM-36(N,P)-TKA, BBM-42(N,P)- TKA and BBM-50(N,P)-TKA are vented gas appliances that use an electronic control valve and electronic ignition system. A FMI PRODUCTS, LLC venting system and vent cap are not supplied but are required for proper operation If a B-type venting system is installed, tra ...

  • FMI BVC-36Y - page 6

    www .fmiproducts.com 122280-01E 6 SPECIFICA TIONS GAS RA TING - NA TURAL BBM-36N-TKA BBM-42N-TKA BBM-50N-TKA Max. Input Rating: 52,000 Btu/Hr 56,000 Btu/Hr 60,000 Btu/Hr Manifold Pressure: 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) Min. Supply Pressure: 4.5" WC (1.12 kPa) 5.0" WC (1.24 kPa) 5.0" WC (1.24 kPa ...

  • FMI BVC-36Y - page 7

    www .fmiproducts.com 122280-01E 7 29" 14 1 / 2 " 22 1 / 2 " 26 5 / 8 " 4 1 / 2 " 15 5 / 8 " 4 1 / 2 " 1" 58" 7 1 / 4 " 1 1 " 15 1 / 4 " 3 1 / 2 " 9 1 / 2 " 10 1 / 2 " 67" 61" 49" 1 1 " 7" 30" 1" 45 1 / 8 " 36" OUTSIDE AIR ACCESS G ...

  • FMI BVC-36Y - page 8

    www .fmiproducts.com 122280-01E 8 PRODUCT DIMENSIONS Continued 22 3 / 4 " 30 1 / 2 " 29" 4 3 / 8 " 15 3 / 4 " 5/8" 17 5 / 8 " 67" 61" 49" 7" 1" 30" 1 1 " 58" 42" 51 1 / 8 " 4 1 / 2 " 3 1 / 2 " 9 1 / 2 " 10 1 / 2 " 8 1 / 2 " 13" 17" ...

  • FMI BVC-36Y - page 9

    www .fmiproducts.com 122280-01E 9 PRODUCT DIMENSIONS Continued 38 1 / 2 " 28 1 / 2 " 4 3 / 8 " 17 5 / 8 " 19 1 / 4 " 24" 49" 30" 1 1 " 61" 67" 58" 7" 1" 59" 50" 4 1 / 2 " 3 1 / 2 " 9 1 / 2 " 10 1 / 2 " 8 1 / 2 " 13" 17" GAS LINE ACCESS ...

  • FMI BVC-36Y - page 10

    www .fmiproducts.com 122280-01E 10 Figure 6 - Rough Opening Dimensions for Installing in a Wall 59 1 / 4 " (50") 58 1 / 8 " 30 1 / 8 " (42", 50") 28 1 / 4 " (36") 67 1 / 8 " 51 1 / 4 " (42") 45 1 / 4 " (36") SELECTING LOCA TION T o determine the safest and most efcient location for ...

  • FMI BVC-36Y - page 11

    www .fmiproducts.com 122280-01E 11 PREINST ALLA TION PREP ARA TION Continued 6. Using screws or nails, secure replace to framing through anges located on sides of replace.        - ? ...

  • FMI BVC-36Y - page 12

    www .fmiproducts.com 122280-01E 12 VENTING INST ALLA TION A FMI PRODUCTS, LLC or an 8" B-type vent - ing sys tem mus t be con nect ed to appli ance for venting to the outside of building. T ransition pipe model BTC-8 is required for use with B-type venting. Standing codes requirements concerning vent installations may vary within your state, p ...

  • FMI BVC-36Y - page 13

    www .fmiproducts.com 122280-01E 13 Figure 12 - T ypical Residential Installations VENTING INST ALLA TION Continued VENTING INST ALLA TION USING FMI  FMI PRODUCTS, LLC chimney system consists of 12", 18", 24", 36" and 48" snap- lock, double-w ...

  • FMI BVC-36Y - page 14

    www .fmiproducts.com 122280-01E 14 VENTING INST ALLA TION Continued ASSEMBL Y AND INST ALLA TION OF DOUBLE W ALL CHIMNEY SYSTEM Each double wall chimney section consists of a galvanized outer pipe, a stainless steel in - ner ue pipe and a wire spacer . Pipe sections mus t be assem bled in depe nden tly as chi mney is inst alled. When con nectin ...

  • FMI BVC-36Y - page 15

    www .fmiproducts.com 122280-01E 15 VENTING INST ALLA TION Continued Pitch Slope Opening  Used Flashing Model No. Flat 0° 15" V6F-8DM 0-6/12 26.6° 16 1 / 8 " V6F-8DM 6/12- 12/12 45.0° 20 3 / 8 " V12F-8DM FL AS HIN G I NS T ALL A TIO N ( V6 F-8 DM OR V12F-8DM) Determine ashing to be used with roof open ...

  • FMI BVC-36Y - page 16

    www .fmiproducts.com 122280-01E 16    Fireplace system must be terminated with listed round top or chase terminations. In any case, refer to insta llation instructions supplied with termination. T erminations approved for this replace are RT -8DM and R TL-8DM that c ...

  • FMI BVC-36Y - page 17

    www .fmiproducts.com 122280-01E 17 Check this area along entire top edge of replace opening. Smoke or ame should be drawn into appliance opening. Figure 21 - Checking for Spillage VENTING INST ALLA TION Continued FINISHING FIREPLACE Combustible materials, such as wallboard, gypsum board, sheet rock, drywall, plywood, etc. may make direct cont ...

  • FMI BVC-36Y - page 18

    www .fmiproducts.com 122280-01E 18 IN PI L O T IN OUT VENT TH TP TH TP INST ALLA TION Continued Figure 25 - Connecting Incoming Gas Line to Flex Gas Line Gas Shutoff V alve Flexible Gas Line Do NOT Kink 1/2" NPT Incoming Gas Line Note: 1) Wire connections not shown for clarity 2) * 1/8" NPT Plugged T apping Red Surface Indicates For Propa ...

  • FMI BVC-36Y - page 19

    www .fmiproducts.com 122280-01E 19 REMOVING AND INST ALLING SMOKE SHELF                 1. Remove screws that attach sm ...

  • FMI BVC-36Y - page 20

    www .fmiproducts.com 122280-01E 20 INST ALLA TION Continued RED IVOR Y QTY FULL (1 12140-01) FULL (1 12140-05) 4* ASH BRICK (120848-01) ASH BRICK (120848-02) 1 F012R F012W 2 F036R F036W 2 F079R F079W 2 F104R F104W 2 F128R F128W 2 F140R F140W 2 S109R S109W 2 * Includes 2 extra bricks. 120848-01 FULL FULL F140 F140 F013 F013 F036 F079 F079 F036 F078 ...

  • FMI BVC-36Y - page 21

    www .fmiproducts.com 122280-01E 21 INST ALLA TION Continued 36" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 16 S043R S043W 1 S044R S044W 1 S045R S045W 1 S046R S046W 6 S047R S047W 6 S050R S050W 5 S095R S095W 1 S047 S046 S046 S050 S050 S050 S050 S050 S043 S046 S046 S046 S046 FULL FULL FULL FUL ...

  • FMI BVC-36Y - page 22

    www .fmiproducts.com 122280-01E 22 INST ALLA TION Continued 42" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 17 S045R S045W 1 S046R S046W 5 S050R S050W 6 S076R S076W 6 S077R S077W 6 S080R S080W 1 S081R S081W 1 REAR REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 16 S051R S051W 2 ...

  • FMI BVC-36Y - page 23

    www .fmiproducts.com 122280-01E 23 INST ALLA TION Continued 50" SPLIT ST ACKED BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 16 S043R S043W 1 S045R S045W 1 S046R S046W 6 S050R S050W 5 S076R S076W 6 S077R S077W 6 S095R S095W 1 S096R S096W 1 FULL FULL FULL FULL FULL FULL FULL FULL FULL FULL FULL FULL FULL FULL ...

  • FMI BVC-36Y - page 24

    www .fmiproducts.com 122280-01E 24 INST ALLA TION Continued 36" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVORY QTY FULL (1 12140-02) FULL (1 12140-06) 12 S001R S001W 1 S002R S002W 1 S003R S003W 1 S004R S004W 1 S032R S032W 1 S058R S058W 7 S069R S069W 7 S071R S071W 1 S072R S072W 1 S073R S073W 1 S074R S074W 1 S075R S075W 1 S103R S103W ...

  • FMI BVC-36Y - page 25

    www .fmiproducts.com 122280-01E 25 INST ALLA TION Continued 42" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 19 S001R S001W 2 S002R S002W 9 S003R S003W 2 S004R S004W 1 S054R S054W 1 S075R S075W 1 S074R S074W 1 S085R S085W 7 S087R S087W 1 S088R S088W 1 S103R S103W 1 F071R F071W 1 F131R F131 ...

  • FMI BVC-36Y - page 26

    www .fmiproducts.com 122280-01E 26 INST ALLA TION Continued 50" SPLIT HERRINGBONE BRICK MA TRIX LEFT REFRACTOR Y RED IVOR Y QTY FULL (1 12140-02) FULL (1 12140-06) 18 S001R S001W 2 S002R S002W 1 S003R S003W 2 S004R S004W 2 S007R S007W 8 S067R S067W 1 S093R S093W 1 S097R S097W 6 S098R S098W 1 S099R S099W 1 S105R S105W 1 S106R S106W 1 F120R F120 ...

  • FMI BVC-36Y - page 27

    www .fmiproducts.com 122280-01E 27 Figure 29 - Grouting Brick GROUTING INSTRUCTIONS Material provided: 1 or 2 - 10 lb. bags of cement (depending on model) 1 or 2 - 10 lb. bags of sand (depending on model) Material required: 1 - Piping bag 1 - Joints striker 1 - Heavy duty mixing bucket 1 - T rowel 1. Moisten brick surface with damp sponge or spray ...

  • FMI BVC-36Y - page 28

    www .fmiproducts.com 122280-01E 28 INST ALLING MODULE Before installing module, make sure all bat - teries have been installed (see Installing Bat- teries in Wireless Hand-Held Remote Control and Receiver . See Removing and Installing Smoke Shelf on page 18 to reinstall limit switch and smoke shelf. INST ALLING BA TTERIES IN WIRELESS HAND-HELD REMO ...

  • FMI BVC-36Y - page 29

    www .fmiproducts.com 122280-01E 29 INST ALLA TION Continued Figure 34 - Installing Fireplace Screen Ring Screen Push On Nut Screen Rod Bracket Smoke Shelf Screen Rod Fireplace Front CAUTION: Gloves should      ? ...

  • FMI BVC-36Y - page 30

    www .fmiproducts.com 122280-01E 30 INST ALLA TION Continued Figure 37 - Installing Bi-Fold Doors Spring Clip Insert Pin into Spring Clip Pivot Hole Insert Bottom Pivot Pin into Hole Fold Door and Slide T op Pins Into T rack INST ALLING OPTIONAL GLASS DOOR ACCESSORY IMPORT ANT : Install glass door       ? ...

  • FMI BVC-36Y - page 31

    www .fmiproducts.com 122280-01E 31 OPERA TION FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not fol-             ? ...

  • FMI BVC-36Y - page 32

    www .fmiproducts.com 122280-01E 32 OPERA TION Continued COMBUSTION AIR KIT MODEL AK4 (OPTIONAL) The outside air kit lever is located at the left and right hand sides of replace (see Figure 40). The vent can be installed through any outside wall a minimum of three feet below replace termination cap. Lifting lever up will free the outside air d ...

  • FMI BVC-36Y - page 33

    www .fmiproducts.com 122280-01E 33 CLEANING AND MAINTENANCE W ARNING: Installation and        -      -      ? ...

  • FMI BVC-36Y - page 34

    www .fmiproducts.com 122280-01E 34 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . Contact authorized dealers of this product. If they can’t supply original replacement part(s), call FMI PRODUCTS, LLC at 1-866-328-4537. When calling FMI PRODUCTS, LLC, have ...

  • FMI BVC-36Y - page 35

    www .fmiproducts.com 122280-01E 35 CONTROL MODULE BA TTERY RELA Y BA TTER Y PACK REMOTE RECIEVER V A L V E THTP TP TH Red Bk Bn Bk "D" SIZE "D" SIZE Bn 4 "AA" SIZE BA TTERY (NOTE: CUT CONNECTOR & STRIP 1/4") NOTE: CONNECTION IN FIELD LIMIT SWITCH Red Bu Yl Bu Bk Og Gn Yl Gn Bn Bk Og Bk Bk Bn Bu Bu TO J-BOX ADA ...

  • FMI BVC-36Y - page 36

    www .fmiproducts.com 122280-01E 36 TROUBLESHOO TING Note: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Constructiondebriscloggingthepilotand/orgascontrolvalvelter OBSERVED PROBLEM Ignitor wil ...

  • FMI BVC-36Y - page 37

    www .fmiproducts.com 122280-01E 37 TROUBLESHOO TING Continued           ...

  • FMI BVC-36Y - page 38

    www .fmiproducts.com 122280-01E 38 P ARTS    1 22 27 21 6 7 10 9 1 1 12 13 15/16 14 8 26 25 2 3 28 17 23 24 5 19 18 4 20 ...

  • FMI BVC-36Y - page 39

    www .fmiproducts.com 122280-01E 39 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 ** Face Assembly • • • 1 2 ** Firebox Bottom Assembly • • • 1 3 ** Firebox Bottom ••• 1 4 ...

  • FMI BVC-36Y - page 40

    www .fmiproducts.com 122280-01E 40 P ARTS    1 9 6 8 7 10 1 1 4 2 12 3 5 ...

  • FMI BVC-36Y - page 41

    www .fmiproducts.com 122280-01E 41 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 ** Base Weldment • • • • • • 1 2 122122-01 Pilot, NG • • • 1 122122-02 Pilot, LP • • ? ...

  • FMI BVC-36Y - page 42

    www .fmiproducts.com 122280-01E 42 P ARTS This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this manual. MKB-36SS-(R)(I) P ART NO. DESCRIPTION QTY . 120842-01 36" Split Stack Left Panel Assembly • 1 120842-02 42" Split Stack Left Panel Ass ...

  • FMI BVC-36Y - page 43

    www .fmiproducts.com 122280-01E 43 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _________________________________________ ...

  • FMI BVC-36Y - page 44

    122280-01 Rev . E 04/10 WARRANTY KEEP THIS WARRANTY FMI PRODUCTS, LL C LIMITED WARRANTIES  Standard Warranty: F MI P RO D UC TS , LL C wa r ra nt s th is n ew p ro d uc t an d an y pa r ts t he re o f t o be f re e fr o m d e fe ct s i n ma te ri a l an d wo r km an s hi p fo r a pe r io d of t wo ( 2 ) ye ar s f ...

Fabricant FMI Catégorie Indoor Fireplace

Les documents que nous recevons du fabricant de l'appareilFMI BVC-36Y peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques FMI
- manuels d’utilisations BVC-36Y
- fiches produit FMI
- dépliants
- ou étiquettes-énergie FMI BVC-36Y
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation FMI BVC-36Y.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation FMI BVC-36Y, manuels d’entretien, brefs manuels ou manuels de l’utilisateur FMI BVC-36Y. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit FMI BVC-36Y.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil FMI BVC-36Y, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser FMI BVC-36Y par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs FMI BVC-36Y.

Le manuel d’utilisation complet FMI, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel FMI BVC-36Y - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières FMI BVC-36Y, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lFMI BVC-36Y qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil FMI BVC-36Y - qui devraient nous aider dans les premières étapes lors de l'utilisation FMI BVC-36Y
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de FMI BVC-36Y
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service FMI BVC-36Y dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de FMI BVC-36Y?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec FMI BVC-36Y, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec FMI BVC-36Y il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)