Français dropdown-ico

Manuel d’utilisation LG Electronics LMV1625B

45 pages 2.23 mb
Télécharger

Aller à la page of 45

Summary
  • LG Electronics LMV1625B - page 1

    MICROW A VE OVEN SE R VICE MANUAL MODEL : LMV1625B LMV1625W CAUTION BEFORE SERVICING THE UNIT , READ THE SAFETY PRECAUTIONS IN THIS MANUAL. website: http://www .lgservice.com ...

  • LG Electronics LMV1625B - page 2

    CAUTION SAFETY PRECAUTIONS PRECAUTIONS T O BE OBSER VED BEFORE AND DURING SER VICING T O A VOID POSSIBLE EXPOSURE T O EXCESSIVE MICROW A VE ENERGY a. Do not operate or allow the oven to be operated with the door open. b. Make the following safety checks on all ovens to be serviced before activating the magnetron or other microwave source, and make ...

  • LG Electronics LMV1625B - page 3

    FOREWORD Read this Manual carefully. Failure to adhere to or observe the information in this Manual may result in exposing yourself to the Microwave Energy normally contained within the oven cavity. T ABLE OF CONTENTS (Page) SAFETY PRECAUTIONS ........................................................................................................ I ...

  • LG Electronics LMV1625B - page 4

    1-1 SPECIFICA TIONS Rated Power Consumption .................................... 1,500W maximum (Microwave oven+Cook top lamp+Ventilation fan) Microwave Output .................................................. 1,000W (IEC 60705) Adjustable 100W through 1000W, 10 steps Frequency .............................................................. 2,450 M ...

  • LG Electronics LMV1625B - page 5

    2-1 CAUTIONS • DO NOT operate on a 2-wire extension cord during repair and use. • NEVER TOUCH any oven components or wiring during operation. • BEFORE TOUCHING any parts of the oven, always remove the power plug from the outlet. • For about 30 seconds after the oven stops, an electric charge remains in the high voltage capacitor. When repla ...

  • LG Electronics LMV1625B - page 6

    3-1 INST ALLA TIONS PRECAUTIONS ON INST ALLA TION A. Plug the power supply cord into a 120V AC, 60Hz, single-phase power source with a capacity of 15A or 20A. B. Avoid placing the unit in a location where there is direct heat or splashing water. C. Install the unit on the mounting plate firmly. D. Place the unit as far away as possible from TV, rad ...

  • LG Electronics LMV1625B - page 7

    4-1 OPERA TING INSTRUCTIONS CONTROL P ANEL 4 7 10 14 15 16 19 9 21 24 26 23 1 5 8 17 20 22 25 18 11 13 6 3 2 12 ...

  • LG Electronics LMV1625B - page 8

    4-2 CONTROL P ANEL INSTRUCTIONS 1. DISPLAY: The Display includes a clock and indicators to tell you time of day, cooking time settings and cooking functions selected. 2. POPCORN: Touch this pad when popping popcorn in your microwave oven. 3. PIZZA: Touch this pad to reheat 1 to 3 slices. 4. COOK: Touch this pad to cook vegetables, rice, or casserol ...

  • LG Electronics LMV1625B - page 9

    5-1 OVERALL CIRCUIT DIAGRAM SCHEMA TIC DIAGRAM ...

  • LG Electronics LMV1625B - page 10

    5-2 MA TRIX CIRCUIT FOR TOUCH KEY BOARD TIME COOK FAN HI/LO/OFF HELP COOK POPCORN AUTO DEFROST LIGHT HI/LO/OFF CUSTOM SET REHEAT POTATO KITCHEN TIMER CLOCK LESS Ez On BEVERAGE POWER LEVEL CUSTOM COOK LIGHT TIMER N.C PIZZA HOLD WARM T/TABLE ON/OFF STOP CLEAR START N.C N.C N.C MORE N.C N.C N.C N.C ...

  • LG Electronics LMV1625B - page 11

    6-1 GENERAL INFORMA TION FOR SERVICE GENERAL PRECAUTIONS IN USE A. Never operate the unit when it is empty. Operating the oven with no load may shorten the life of the magnetron. Whenever cooking dry foods (dried fish, bread, etc.) or a small amount of food, be sure to put a glass of water into the cooking compartment. The glass turntable may becom ...

  • LG Electronics LMV1625B - page 12

    7-1 SER VICE INFORMA TION PRECAUTIONS AND REP AIR SERVICE TIPS PRELIMINAR Y A. SINCE NEARLY 2,100 VOLTS EXISTS IN SOME CIRCUITS OF THIS UNIT REPAIRS SHOULD BE CARRIED OUT WITH GREAT CARE. The filament leads of magnetron carry High Voltage with respect to ground. Extreme caution must be exercised. Never plug the unit into a power source to determine ...

  • LG Electronics LMV1625B - page 13

    7-2 CAUTIONS • Be sure to check microwave leakage prior to servicing the oven if the oven is operative prior to servicing. • The service personnel should inform the manufacture importer, or assembler of any certified oven unit found to have a microwave emission level in excess of 5 mW/cm 2 and should repair any unit found to have excessive emis ...

  • LG Electronics LMV1625B - page 14

    (1) Microwave power output measurement is made with the microwave oven supplied at its rated voltage and operated at its maximum microwave power setting with a load of (1000± 5) g of potable water. (2) The water is contained in a cylindrical borosilicate glass vessel having a maximum material thickness of 1/8 ” (3 mm) and an outside diameter of ...

  • LG Electronics LMV1625B - page 15

    IMPORT ANT NOTES: UNIT MUST BE DISCONNECTED FROM ELECTRICAL OUTLET WHEN MAKING REPAIRS, RE-PLACEMENTS, ADJUSTMENTS AND CONTIN- UITY CHECKS. WAIT AT LEAST ONE MINUTE, UNTIL THE HIGH VOLTAGE CAPACITOR IN THE HIGH VOLTAGE POWER SUPPLY HAS FULLY DISCHARGED. THE CAPACITOR SHOULD BE DISCHARGED BY USING INSULATED WIRE - I.E. TEST PROBE CONNECTED TO 10K-OH ...

  • LG Electronics LMV1625B - page 16

    7-5 HOW TO REMOVE THE F .P .C. CONNECTOR Follow the steps below as illustrated in Figures 4 and 5 to remove the F.P.C. connector. (1) Hold the edges of the plastic fastener withthumb and forefinger. (Figure 4) (2) Lift up the lever of the plastic fastener from the terminal socket by lightly pressing the lever end with forefinger. (Figure 5) (3) Rem ...

  • LG Electronics LMV1625B - page 17

    B. REMOVING THE OUT CASE(Figure 8) (1) Remove the vent grille by removing two screws securing it to the out case. (2) Remove two screws securing it to the front bracket. (3) Remove two screws securing it to the air duct. (4) Remove the mounting plate by turning the two screws securing it to the out case. (5) Remove the base plate by removing six sc ...

  • LG Electronics LMV1625B - page 18

    7-7 C REMOVING THE DOOR INTERLOCK SWITCHES (Figures 9,10) (1) Disconnect the wire leads from the interlock switches. (2) Remove two screws securing the Latch Board. (3) Make necessary replacements and check microwave energy leakage according to “ ADJUSTMENT PROCEDURE ” on page 7-12. Latch Board WH (from H.V .Transformer) WH(from Monitor S/W) WH ...

  • LG Electronics LMV1625B - page 19

    7-8 D. REMOVING MAGNETRON (Figures 11 Through 13) (1) Remove vertgrille. (2) Remove mount all. (3) Remove outcase. (4) Discinnect the wireleads. (5) Remove the 3 screws and Magnetron very carefully. NOTE: • When removing the magnetron, make sure that its dome does not hit any adjacent parts, or it may be damaged. • When replacing the magnetron, ...

  • LG Electronics LMV1625B - page 20

    Door Screen Door Screen Figure 15 Figure 14 F . REMOVING DOOR (Figure 14) (1) Remove the vent grille by two screws securing it to the outcase loosening. (2) Lift up and draw the door. NOTES: • After replacing the door, be sure to check that the primary interlock switch, the secondary interlock switch and the interlock monitor switch is in good op ...

  • LG Electronics LMV1625B - page 21

    H. ASSEMBLING DOOR (1) When mounting the door assembly to the oven assembly, be sure to adjust the door assembly parallel to the chassis. Also adjust so the door has no play between the inner door surface and oven frame assembly. If the door assembly is not mounted properly, microwaves may leak from the clearance between the door and the oven. I. R ...

  • LG Electronics LMV1625B - page 22

    K. REMOVING THE TURNT ABLE MOTOR (1) Remove the turntable. (2) Remove the turntable shaft VERY CAREFULLY with a slotted screwdriver. (Figure 19) (3) Remove the base plate by removing 6 screws securing it to the oven cavity. (Figure 20) (4) Disconnect the leadwire from the turntable motor terminals. (5) Remove the 2 screws securing the turntable mot ...

  • LG Electronics LMV1625B - page 23

    7-12 ADJUSTMENT PROCEDURES To avoid possible exposure to microwave energy leakage, adjust the door latches and interlock switches, using the following procedure. The Interlock Monitor and Primary Interlock Switch act as the final safety switch protecting the user from microwave energy. The terminals between “ COM ” and “ NC ” of the Interlo ...

  • LG Electronics LMV1625B - page 24

    7-13 TEST THE LATCH AND SWITCH SEQUENCE (5) Open the oven door slowly. Watch the door latch, the Secondary Switch. Release Rod and Lever on the switches to make sure they are zero to the body of the switches in the following sequence: - Primary Interlock Switch - Secondary Interlock Switch - Interlock Monitor Switch Adjust the latch board until the ...

  • LG Electronics LMV1625B - page 25

    7-14 A. PRIMARY INTERLOCK SWITCH TEST When the door is opened slowly, an audible click should be heard at the same time or successively at intervals and the latches should activate the switches with an audible click . If the latches do not activate the switches when the door is closed, the switches should be a adjusted in accordance with the adjust ...

  • LG Electronics LMV1625B - page 26

    7-15 - CAUTIONS - -DISCONNECT THE POWER SUPPLY CORD FROM THE WALL OUTLET WHENEVER REMOVINGING THE CABINET FROM THE UNIT. PROCEED WITH THE TESTS ONLY AFTER DISCHARGING THE HIGH VOLTAGE CAPACITOR AND REMOVING THE WIRE LEADS FROM THE PRIMARY WINDING OF THE HIGH VOLTAGE TRANSFORMER. (SEE FIGURE 24) - ALL OPERATIONAL CHECKS WITH MICROWAVE ENERGY MUST BE ...

  • LG Electronics LMV1625B - page 27

    7-16 COMPONENTS TEST PROCEDURES RESULTS HIGH-VOLTAGE CAPACITOR HIGH-VOLTAGE DIODE Measure the resistance: (1) Terminal to terminal Ohm- meter (2) Terminal to case Ohm- meter Measure the continuity: (1) Forward Ohm- meter (1) Reverse Ohm- meter Normal reading: Momentarily indicates several ohms, and then gradually returns to infinite ohms. Abnormal ...

  • LG Electronics LMV1625B - page 28

    1 2 3 4 5 6 7 8 9 10 11 12 13 Figure 28 Figure 27 TIME COOK FAN HI/LO/OFF HELP COOK POPCORN AUTO DEFROST LIGHT HI/LO/OFF CUSTOM SET REHEAT POTATO KITCHEN TIMER CLOCK LESS Ez On BEVERAGE POWER LEVEL CUSTOM COOK LIGHT TIMER N.C PIZZA HOLD WARM T/TABLE ON/OFF STOP CLEAR START N.C N.C N.C MORE N.C N.C N.C N.C Measure the resistance between terminal pin ...

  • LG Electronics LMV1625B - page 29

    7-18 COMPONENTS TEST PROCEDURES RESULTS RELAY2 Check for continuity of relay 2 with an ohm-meter. (Remove wire leads from relay 2 and operate the unit.) w w CAUTION : The relay connector 2(White) and 5(Red) must be correctly connected Relay 6. These two connectors are not Inter- changeable. NOTES: • A MICROWAVE ENERGY TEST MUST ALWAYS BE PERFORME ...

  • LG Electronics LMV1625B - page 30

    (2) CHECKOUT PROCEDURES FOR RELAY. - PROBLEM (A) - TT motor and oven lamp turn on without touching START key when the door is closed. Remove the mate connector of I/O CON from the circuit board. Does the unit still operate? GOOD Replace the circuit board Replace RELAY3 - PROBLEM (B) - TT motor and oven lamp turn on When the door is closed and START ...

  • LG Electronics LMV1625B - page 31

    7-20 (3) CHECKOUT PROCEDURES FOR CIRCUIT BOARD The following symptoms indicate a defective circuit board. 1) The start function fails to operate but the high voltage Systems, the interlock switches, the door sensing and the relay check good. 2) The unit with a normal relay continuously operates. 3) Proper temperature measurement is not obtained. 4) ...

  • LG Electronics LMV1625B - page 32

    7-21 PROBLEM - A: “ PLEASE SET TIME OF DAY ” does not appear in display window when power supply cord is plugged into wall outlet. PROBLEM - B: Display does not show correct numbers and/or correct indications when programmed. Check: 1. POWER SUPPLY 2. FUSE (See “ CHECKOUT PROCEDURES FOR FUSE BLOWING: on page 7-18) 3. OVEN CAVITY THERMOSTAT 1 ...

  • LG Electronics LMV1625B - page 33

    7-22 Resistance incorrect Check the continuity of H.V.C. (see page 7-16) Normal H.V.T. Resistance incorrect Normal H.V.C. Abnormal Replace H.V.D. Normal Magnetron Replace Magnetron Normal Normal H.V.D. Check the continuity of H.V.D. (see page 7-16) Replace H.V.C. Normal resistance Replace H.V.T. Normal resistance Runs Runs Runs Contact OK Replace c ...

  • LG Electronics LMV1625B - page 34

    7-23 PROBLEM - D : No buzzing when touching the key, between stages or at end of cooking 1 Normal circuit board Check normal operation circuit board Replace circuit board Runs ...

  • LG Electronics LMV1625B - page 35

    7-24 PROBLEM - E : Ventilation fan does not operate when “ FAN HIGH/LOW ” key is touched. 1 Check: 1. POWER SUPPLY 2. FUSE Runs Runs Runs Runs Contact OK NO contact Replace oven thermostat Poor contact Replace circuit board Normal circuit board Contact OK Normal contact Correct seating Check contact of connector S1 (see page 7-4) Replace ventil ...

  • LG Electronics LMV1625B - page 36

    8-1 EXPLODED VIEW DOOR PARTS 13581A 13552A 13536A 13213A 14890A 13720D 13650A 14970A 14026A WTT021 ...

  • LG Electronics LMV1625B - page 37

    8-2 CONTROLLER PARTS 24810P 23572A 23506A *07 26871 1 24781M WTP018 WTT029 ...

  • LG Electronics LMV1625B - page 38

    OVEN CAVITY PARTS 36912C 33550L 63302A WTT022 WTT028 WTT029 331 12U 368771 WTT029 34810T 33530A 34930R 35026G 33052A *05 34890C WTT022 35230A 63303A 34810Q 34960A WTT021 *02 *01 *04 8-3 ...

  • LG Electronics LMV1625B - page 39

    8-4 LA TCH BOARD P ARTS 466001 43500A 466003 466001 44510A 43501A WSZ084 ...

  • LG Electronics LMV1625B - page 40

    8-5 INTERIOR PARTS(I) WTT021 56170D WTT028 33390G 34370T 35889A 36549S WTP013 WTT021 33740A 54810C 50CZZH WSZ002 56851D WSZ002 533001 533002 56324A WSZ002 ...

  • LG Electronics LMV1625B - page 41

    8-6 INTERIOR PARTS (II) 36549V 56912B 53550L 55262A 55231C 56804A WTT028 WSZ002 56930V 55006F 50FZZA 568771 56411A 340511 53550F 55892A 54930F ...

  • LG Electronics LMV1625B - page 42

    8-7 INSTALLATION PARTS WSZ133 WSZ204 44360A WWZ068 63300M 65862D 65862B WSZ203 WSZ098 WWZ068 63861A WSZ136 ...

  • LG Electronics LMV1625B - page 43

    8-12 SCHEMA TIC DIAGRAM TIME COOK FAN HI/LO/OFF HELP COOK POPCORN AUTO DEFROST LIGHT HI/LO/OFF CUSTOM SET REHEAT POTATO KITCHEN TIMER CLOCK LESS Ez On BEVERAGE POWER LEVEL CUSTOM COOK LIGHT TIMER N.C PIZZA HOLD WARM T/TABLE ON/OFF STOP CLEAR START N.C N.C N.C MORE N.C N.C N.C N.C ...

  • LG Electronics LMV1625B - page 44

    8-13 PRINTED CIRCUIT BOARD ...

  • LG Electronics LMV1625B - page 45

    May , 2003 P/NO. 3828W5S3242 Printed in Korea ...

Fabricant LG Electronics Catégorie Microwave Oven

Les documents que nous recevons du fabricant de l'appareilLG Electronics LMV1625B peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques LG Electronics
- manuels d’utilisations LMV1625B
- fiches produit LG Electronics
- dépliants
- ou étiquettes-énergie LG Electronics LMV1625B
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation LG Electronics LMV1625B.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation LG Electronics LMV1625B, manuels d’entretien, brefs manuels ou manuels de l’utilisateur LG Electronics LMV1625B. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit LG Electronics LMV1625B.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil LG Electronics LMV1625B, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser LG Electronics LMV1625B par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs LG Electronics LMV1625B.

Le manuel d’utilisation complet LG Electronics, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel LG Electronics LMV1625B - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières LG Electronics LMV1625B, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lLG Electronics LMV1625B qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil LG Electronics LMV1625B - qui devraient nous aider dans les premières étapes lors de l'utilisation LG Electronics LMV1625B
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de LG Electronics LMV1625B
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service LG Electronics LMV1625B dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de LG Electronics LMV1625B?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec LG Electronics LMV1625B, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec LG Electronics LMV1625B il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)