Manuel d’utilisation KTM DUAL SPORT KIT INSTALLATION MANUAL

10 pages 2.42 mb
Télécharger

Aller à la page of 10

Summary
  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 1

    ’04-‘05 KTM 450/525 EXC & MXC DUAL SPORT KIT INSTALLATION MANUAL 1. Get a degree in Mechanical and Elec trical Engineering. (kidding) 2. Remove the seat and fuel tank. Unplug and remove the kill button and its wiring. 3. EXC – Unplug and remove the headlight. MXC – Remove the front number plate. 4. EXC - Unplug the stock taillight from ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 2

    failure to do it correctly will make the brake inoperable. Remove the stock banjo bolt and replac e with the hydraulic switch as shown. Make sure to install the copper crush washer from the stock bolt under the switch (Photo 2). Torque to 25 lbs. Photo 3 Bleeding the Brake: (do not begin this process unless you have a fresh can of brake fluid.) Rem ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 3

    9. Rear Turn Signal Installation: Looking at the inside edge of the taillight, locate the slightly raised “guides” on each side (see Photo 5). These are where the rear turn signals will mount on the taillight. Mark the center of these guides with an awl and drill a 13/32” hole through the center of each one. Mount two of the turn signals to t ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 4

    Attach one of the two wires (doesn’t matter which) from the left turn signal to the white wire from the gray cable. • • Photo 8 MXC Taillight Mounting Hardw are Locations Attach the two remaining wires from the turn signals to the black double-female connector from the gray cable. Once the connections are made, drill several small holes and z ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 5

    Photo 14 Photo 12 13. Front Turn - Signal Installation: Mount the front turn-signal mounting bracket to the upper triple- clamp as shown in Photo 12. Mount the front turn- signals to this bracket. EXC’s use the existing bolts to mount this bracket. MXC’s use the two 6x12mm bolts found in the parts bag to mount this bracket. 14. Lens, Flasher, H ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 6

    17. Kill Wire Extension Installation: Locate the black/white and green two- wire extension in the dual-sport kit par ts bag. It has a ring terminal and female connector on one end and two females on the other. Secure the ring-terminal to the ground bolt under the fuel tank (same bolt the stock kill button was removed from in step 3.) Attach the fem ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 7

    19. Mid-Harness Connections: You will now make all the necessary wiring connections under the fuel tank and seat. Under the fuel tank, locate the unused white 2-wire connector from the stock wiring harness (see Photo 14.) It may be bundled up in the stock wiring. Free this connector and attach it to the corresponding 2-wire connector from the Baja ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 8

    The switch panel in this kit controls all the lighting functions in one compact package. Using the lighti ng selector, push the switch to the second position. The rear taillight should come on. Test t he brake-light. Test the turn signals. Honk the horn (unless its after 11 PM!). Because the headlight is powered directly off the coil, (not backed u ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 9

    off the road. Make sure all the silicone rubber connector boots and the connectors are pushed firmly together and no bare metal is exposed. TROUBLESHOOTING Nothing happens when you turn the power switch on: • • • • • • • • • • Fuse is blown. Check for bare wir e or terminal shorting against the frame or another wire. 6-pin conne ...

  • KTM DUAL SPORT KIT INSTALLATION MANUAL - page 10

    Baja Designs 185 Bosstick Blvd. San Marcos, California 92069 760.560.2252 www.bajadesigns.com ...

Fabricant KTM Catégorie Motorcycle Accessories

Les documents que nous recevons du fabricant de l'appareilKTM DUAL SPORT KIT INSTALLATION MANUAL peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques KTM
- manuels d’utilisations DUAL SPORT KIT INSTALLATION MANUAL
- fiches produit KTM
- dépliants
- ou étiquettes-énergie KTM DUAL SPORT KIT INSTALLATION MANUAL
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation KTM DUAL SPORT KIT INSTALLATION MANUAL.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation KTM DUAL SPORT KIT INSTALLATION MANUAL, manuels d’entretien, brefs manuels ou manuels de l’utilisateur KTM DUAL SPORT KIT INSTALLATION MANUAL. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit KTM DUAL SPORT KIT INSTALLATION MANUAL.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil KTM DUAL SPORT KIT INSTALLATION MANUAL, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser KTM DUAL SPORT KIT INSTALLATION MANUAL par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs KTM DUAL SPORT KIT INSTALLATION MANUAL.

Le manuel d’utilisation complet KTM, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel KTM DUAL SPORT KIT INSTALLATION MANUAL - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières KTM DUAL SPORT KIT INSTALLATION MANUAL, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lKTM DUAL SPORT KIT INSTALLATION MANUAL qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil KTM DUAL SPORT KIT INSTALLATION MANUAL - qui devraient nous aider dans les premières étapes lors de l'utilisation KTM DUAL SPORT KIT INSTALLATION MANUAL
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de KTM DUAL SPORT KIT INSTALLATION MANUAL
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service KTM DUAL SPORT KIT INSTALLATION MANUAL dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de KTM DUAL SPORT KIT INSTALLATION MANUAL?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec KTM DUAL SPORT KIT INSTALLATION MANUAL, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec KTM DUAL SPORT KIT INSTALLATION MANUAL il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Commentaires (0)