-
Quadra-Fire Isle Royale - page 1
SA VE THESE INSTRUCTIONS www .quadrafire.com This manual contains instructions for Installation, Operation & Maintenance. Please read this entire manual before you install and use your new room heater . Failure to follow instructions may result in property damage, bodily injury , or even death. Isle Royale Non-Catalytic, T op-load, W ood Heate ...
-
Quadra-Fire Isle Royale - page 2
R Page 2 February 4, 2005 Isle Royale W ood Stove 250-5763B and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradi- tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil- ity , and performance. This commitment begins with our research of the mark ...
-
Quadra-Fire Isle Royale - page 3
Page 3 Isle Royale W ood Stove R February 4, 2005 250-5763B Listings & Safety Notices ........................................ 3 Serial Number Label Location ................................. 2 Pre-Use Checklist ..................................................... 3 Dimensions ............................................................... 5 V ...
-
Quadra-Fire Isle Royale - page 4
R Page 4 February 4, 2005 Isle Royale W ood Stove 250-5763B LISTINGS and SAFETY NOTICES W ARNING ! DO NOT A TTEMPT TO OPERA TE THIS WOODSTOVE WITHOUT READING AND UNDERST ANDING THESE OPERA TING I NS T R UC T I O NS T H OR O U G HL Y . FAI L U RE T O O P E RATE T H IS APPLIANCE PROPERL Y MA Y CAUSE A HOUSE FIRE. W ARNI NG ! TH E OU TSID E SU RF ACES ...
-
Quadra-Fire Isle Royale - page 5
Page 5 Isle Royale W ood Stove R February 4, 2005 250-5763B DIMENSIONS FRONT VIEW SIDE VIEW 29" (737mm) 28-3/4" (730mm) 30" (762mm) C L 8-1/4" (210mm) 16-1/2" (419mm) 24-5/8" (625mm) 26-7/16" (570mm) 30" (762mm) 22-3/4" (578mm) 16-3/4" (425mm) VENT SPECIFICA TIONS: Single W all: Six inch (6") ( ...
-
Quadra-Fire Isle Royale - page 6
R Page 6 February 4, 2005 Isle Royale W ood Stove 250-5763B B A C D CLEARANCES T O COMBUSTIBLES (UL and ULC) G H Ceiling E E F F MINIMUM CLEARANCES TO COMBUSTIBLE MA TERIALS In Inches & (Millimeters) NOTE: "A" ,"C" and "F" Dimensions are to the inside diameter of the flue collar . FOR TOP VENT INST ALLA TIONS: SING ...
-
Quadra-Fire Isle Royale - page 7
Page 7 Isle Royale W ood Stove R February 4, 2005 250-5763B FLOOR PROTECTION The floor must be non-combustible material, extending beneath heater and to the front, sides and rear as indicated. The floor must be non-combustible or otherwise adequately protected from radiant heat given off by the unit and from sparks and falling embers. A layer of t ...
-
Quadra-Fire Isle Royale - page 8
R Page 8 February 4, 2005 Isle Royale W ood Stove 250-5763B REVERSIBLE FLUE COLLAR The flue collar is reversible for either a top or rear venting installation. The unit is shipped with the flue collar in the top vent position. CONVERTING COLLAR FOR REAR VENT INST ALLA TION 1. Remove 5 Phillips head screws from the rear shield, lift shield up and ...
-
Quadra-Fire Isle Royale - page 9
Page 9 Isle Royale W ood Stove R February 4, 2005 250-5763B T o be sure that your stove burns properly , the chimney draft (static pressure) should be approximately -.04” water column (W .C.) during a low burn and -.10” W .C. during a high burn, measured 6 inches (152mm) above the top of the stove after one hour of operation at each burn settin ...
-
Quadra-Fire Isle Royale - page 10
R Page 10 February 4, 2005 Isle Royale W ood Stove 250-5763B Thimble Assembly: 12" (305mm) of brick separation between clay liner and combustibles. Fireclay liner 5/8" (16mm) Minimum or Equivalent. Sill support Header Wood Stud 2" (51mm) Clearance from chimney wall Fireclay liner 5/8" (16mm) Minimum or Equivalent. FLUE SYSTEMS F ...
-
Quadra-Fire Isle Royale - page 11
Page 1 1 Isle Royale W ood Stove R February 4, 2005 250-5763B SOLID P ACK CHIMNEY WITH MET AL SUPPORTS AS A THIMBLE Figure 1 1A Center of Hole W a ll Center Line Opening Center Line C L 26-7/16" (570mm) Add the 26-7/16 inches (671mm), center-line measurement to the depth measurement of your floor protector . Mark this combined mea- surement a ...
-
Quadra-Fire Isle Royale - page 12
R Page 12 February 4, 2005 Isle Royale W ood Stove 250-5763B First, make the frame for the thimble, ensuring it is no smaller than 14 inches (356mm) square to maintain a 2 inch (51mm) air space around the chimney section. Attach the wall spacer to the chimney side of the frame. Then insert the frame into the opening, toe nai ling it to the wal l st ...
-
Quadra-Fire Isle Royale - page 13
Page 13 Isle Royale W ood Stove R February 4, 2005 250-5763B CONNECTION T O A MASONR Y FIREPLACE There are several kits available to connect the stove to a masonry fireplace. Look for a listed kit. The kit is an adapter which is installed at the location of the fireplace damper . The existi ng dampe r may have to be remov ed to allow installati o ...
-
Quadra-Fire Isle Royale - page 14
R Page 14 February 4, 2005 Isle Royale W ood Stove 250-5763B When a metal prefabricated chimney is used, the manufac- turer ’s installation instructions must be followed precisely . It will be necessary to install the ceiling support package or wall pass through, “T” section package, firestops (when needed), insulation shield, roof flashing ...
-
Quadra-Fire Isle Royale - page 15
Page 15 Isle Royale W ood Stove R February 4, 2005 250-5763B Spark Arestor Cap Roof Flashing Storm Collar Joist Shield/Firestop Listed Chimney Connector Floor Protector Outside Air Kit Connector Outside Air Floor V ent 1 . An outside air inlet must be provid ed for combustio n and must remai n clear of leaves, debris, ice and/or snow . It must be u ...
-
Quadra-Fire Isle Royale - page 16
R Page 16 February 4, 2005 Isle Royale W ood Stove 250-5763B OUTSIDE AIR TERMINA TION CAP (contains rodent screen) FLEX FLANGE 1 . Remove all materials from packing box. 2. Mount the flex flange (with pipe fitting extending out), over the intake air opening at the rear of stove using the four mounting screws supplied with kit. 3. Cut a 4 inch (1 ...
-
Quadra-Fire Isle Royale - page 17
Page 17 Isle Royale W ood Stove R February 4, 2005 250-5763B BURNING PROCESS In recent years there has been an increasing concern about air quality . Much of the blame for poor air quality has been placed on the burning of wood for home heating. In order to improve the situation, we at Quadra-Fire have developed cleaner-burning wood stoves that sur ...
-
Quadra-Fire Isle Royale - page 18
R Page 18 February 4, 2005 Isle Royale W ood Stove 250-5763B W ARNING! DO NOT LEA VE THE FIRE UNA TTENDED WHEN THE DOOR IS UNLA TCHED OR WHEN USING THE FIRESCREEN. UNST ABLE FIREWOOD COULD F ALL OUT OF THE FIREBOX CREA TING A FIRE HAZARD TO YOUR HOME. W ARNING! AL W A YS OPERA TE THIS APPLIANCE WITH THE DOOR CLOSED AND LA TCHED EXCEPT DURING ST ART ...
-
Quadra-Fire Isle Royale - page 19
Page 19 Isle Royale W ood Stove R February 4, 2005 250-5763B OPERA TING INSTRUCTIONS (Cont’d) OP ACITY This helps to determine how cleanly your stove is burning. Opacity is measured in percent; 100% opacity is when an object is totally obscured by the smoke column from a chimney , and 0% opacity means that no smoke column can be seen. As you beco ...
-
Quadra-Fire Isle Royale - page 20
R Page 20 February 4, 2005 Isle Royale W ood Stove 250-5763B OPERA TING INSTRUCTIONS (Cont’d) WOOD SELECTION AND STORAGE Burn only dry seasoned wood! This will not only minimize creosote formation, but also provide the most efficient heat output. Even dry wood contains at least 15% moisture by weight and should be burned hot enough to keep the c ...
-
Quadra-Fire Isle Royale - page 21
Page 21 Isle Royale W ood Stove R February 4, 2005 250-5763B CHIMNEY CLEANING 1. Remove all ash from the firebox and extinguish all hot embers before disposal. Allow the stove to cool com- pletely . 2. Close the door tightly and proceed with sweeping the chimney . 3. Sweep the collected ashes into the ash removal box, and empty . Clean out the rem ...
-
Quadra-Fire Isle Royale - page 22
R Page 22 February 4, 2005 Isle Royale W ood Stove 250-5763B N OTE: Remove all labels from glass prior to lighting the first fire. GLASS CARE 1. Ensure that the fire is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels. 3. Remove door with broken glass from the appliance by lifting door up and o ...
-
Quadra-Fire Isle Royale - page 23
Page 23 Isle Royale W ood Stove R February 4, 2005 250-5763B DOOR & GASKET Pe riod ica lly che ck the do or gas ket for pr oper se al. As the gasket compresses or “seats” during use, it may become necessary to adjust or tighten the door latch either by removing spacer washers, shown below (at least one washer must be left in place) or , by ...
-
Quadra-Fire Isle Royale - page 24
R Page 24 February 4, 2005 Isle Royale W ood Stove 250-5763B 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 1 1 10 9 8 7 6 5 4 3 2 1 1 Baffle Assembly 1 1 Grate 21 Rear 2 Baffle Filler 12 Griddle 22 Rear Channel 3 Bottom Assembly 13 Griddle Handle 23 Rear Shield 4 Brick Assembly 14 Hopper Lid Stop 24 Side T ertiary Channel, Right 5 Door As ...
-
Quadra-Fire Isle Royale - page 25
Page 25 Isle Royale W ood Stove R February 4, 2005 250-5763B Service Parts Serial No. Part No. Brick Set 834-3860 Brick, single (See page 23 for dimensions) 832-0550 Door Handle Only , Fiber SRV433-1380 Door Handle Assembly ,(includes cam latch & key , gasketing, fiber handle and screw adapter . Also gold or nickel handle depending on order . ...
-
Quadra-Fire Isle Royale - page 26
R Page 26 February 4, 2005 Isle Royale W ood Stove 250-5763B Date of Service Performed By Description of Service Service and Maintenance Log ...
-
Quadra-Fire Isle Royale - page 27
Page 27 Isle Royale W ood Stove R February 4, 2005 250-5763B Lifetime Warranty LIMITED LIFETIME W ARRANTY The Hearth & Home T echnologies limited Lifetime Warranty guarantees that the following components will work as designed for the lifetime of the stove or Hearth & Home T echnologies will repair or replace them. These items include but a ...
-
Quadra-Fire Isle Royale - page 28
R February 4, 2005 Page 28 • Do NOT discard this manual. • Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation. CAUTION This product may be covered by one or more of the following pa ...
Hai una domanda su Quadra-Fire Isle Royale?
Utilizza il modulo sottostante
Se non hai risolto il problema con Quadra-Fire Isle Royale con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Quadra-Fire Isle Royale è probabile che voglia condividere il modo di risolverlo.