Italiano dropdown-ico

Manuale per l’uso Middleby Marshall 60254

36 pagine 3.43 mb
Scarica

Vai alla pagina of 36

Summary
  • Middleby Marshall 60254 - page 1

    OWNER'S OPERATING AND INSTALLATION MANUAL for domestic and standard export ovens ©2012 Middleby Marshall Inc. is a registered trademark of Middleby Marshall, Inc. All rights reserved. Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • (847)741-3300 • FAX (847)741-4406 PS740 Series Electric Ovens P/N 60254 Sept ...

  • Middleby Marshall 60254 - page 2

    II P/N60254September28,2012 WARNING FOR YOUR SAFETY, DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. WARNING Improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury, or death. Read the installation, operation, and maint ...

  • Middleby Marshall 60254 - page 3

    III P/N60254September28,2012 MIDDLEBY MARSHALL INC. OVEN LIMITED WARRANTY (Non U.S.A.) The Seller warrants equipment manufactured by it to be free from defects in material and workmanship for which it is responsible. The Seller’s obligation under this warranty shall be limited to replacing or repairing, at Seller’s option, withou ...

  • Middleby Marshall 60254 - page 4

    IV P/N60254September28,2012 NOTE Wiring Diagrams are in Section 6 of this Manual. The diagram for each oven is also on the lower inner surface of its Control Console. Page SECTION 1 – DESCRIPTION ............................................ 1 I. OVEN USES ............................................................. 1 II. OVEN COMP ...

  • Middleby Marshall 60254 - page 5

    1 P/N60254September28,2012 I. OVEN USES PS740 Series Ovens can be used to bake and/or cook a wide variety of food products, such as pizza, pizza –type products, cookies, sandwiches and others. II. OVEN COMPONENTS – see Figure 1-1. A. Conveyor Drive Motor: Moves the conveyor. B. Crumb Pans: Catch crumbs and other materials that dr ...

  • Middleby Marshall 60254 - page 6

    2 P/N60254September28,2012 NOTE Wiring Diagrams are contained in Section 6 of this Manual and are also located inside the oven at the bottom of the Control Panel This Manual Must Be Kept For Future Reference I. OVEN SPECIFICATIONS Table 1-1 Dimensions Single Oven Double Oven Triple Oven Overall Height 48-3/16 ″ (1219mm) 62-3/4 ″ ...

  • Middleby Marshall 60254 - page 7

    3 P/N60254September28,2012 WARNING - Keep the appliance area free and clear of combustibles. WARNING – The oven must be installed on an even (level) non-ammable ooring and any adjacent walls must be non-ammable. Recommended minimum clearances are specied in the Description section of this manual. WARNING – Do not obst ...

  • Middleby Marshall 60254 - page 8

    4 P/N60254September28,2012 PARTS LIST FOR SERIES PS740 ELECTRIC OVEN INSTALLATION KIT P/N 61453 (Two required for double oven) (Three required for triple oven) ITEM NO. QTY PART NO. DESCRIPTION 1 1 61823 CONVEYOR END STOP 2 1 31461 CONVEYOR LEFT REAR STOP 3 1 42612 SERVICE AGENCY DIRECTORY 4 1 22500-0080 LABEL, MM 5 1 51054 ASSY, HAN ...

  • Middleby Marshall 60254 - page 9

    5 P/N60254September28,2012 PS740 OVEN INSTALLATION REQUIRED KITS AND EQUIPMENT PS740 PS740 PS740 PS740 Electric Oven Single Oven DoubleOven TripleOven Installation Option Base w/ OptionBase w/ OptionBase w/ TYPE OF INSTALLATION Kit 15 ″ Legs, 6 ″ Legs, Casters& Top Casters & Top Casters & Top Kit Kit Kit P/N61824 P/N6 ...

  • Middleby Marshall 60254 - page 10

    6 P/N60254September28,2012 Figure 2-2A. Model PS740 24 ″ Single Oven Option Base with Legs and Top PARTS LIST FOR PS740 SERIES 24 ″ SINGLE OVEN OPTION - BASE w/15 ″ LEGS & TOP P/N 67027 HARD W ARE BAG 5, 6, 7, 10 & 1 1 1 2 4 9 8 ITEM NO. QTY PART NO. DESCRIPTION 1 1 64943 COMPLETE BASE WELDMENT 2 4 66851 TOP PLATE, LEG ...

  • Middleby Marshall 60254 - page 11

    7 P/N60254September28,2012 Figure 2-2B. Model PS740 32 ″ Single Oven Option Base with Legs and Top PARTS LIST FOR PS740 32 ″ SERIES SINGLE OVEN OPTION - BASE w/15 ″ LEGS & TOP P/N 67025 HARD W ARE BAG 5, 6, 7, 10 & 1 1 1 2 4 9 8 ITEM NO. QTY PART NO. DESCRIPTION 1 1 66159 COMPLETE BASE WELDMENT 2 4 66851 TOP PLATE, LEG ...

  • Middleby Marshall 60254 - page 12

    8 P/N60254September28,2012 ITEM NO. QTY PART NO. DESCRIPTION 1 1 64943 COMPLETE BASE WELDMENT 2 4 66853 TOP PLATE, LEG WELDMENT 4 4 58930 SWIVEL CASTER FLAT PLATE 5 32 2000531 3/8 ″ -16 × 1 HEX SCREW, SST 6 32 21416-0001 3/8 ″ FLAT WASHER, SS 7 32 21422-0001 3/8 ″ SPLIT LOCK WASHER, ZP 8 1 22450-0228 RESTRAINT CABLE ASSEMBLY 9 ...

  • Middleby Marshall 60254 - page 13

    9 P/N60254September28,2012 ITEM NO. QTY PART NO. DESCRIPTION 1 1 66159 COMPLETE BASE WELDMENT 2 4 66853 TOP PLATE, LEG WELDMENT 4 4 58930 SWIVEL CASTER FLAT PLATE 5 32 2000531 3/8 ″ -16 × 1 HEX SCREW, SST 6 32 21416-0001 3/8 ″ FLAT WASHER, SS 7 32 21422-0001 3/8 ″ SPLIT LOCK WASHER, ZP 8 1 22450-0228 RESTRAINT CABLE ASSEMBLY 9 ...

  • Middleby Marshall 60254 - page 14

    10 P/N60254September28,2012 ITEM NO. QTY PART NO. DESCRIPTION 1 1 64943 COMPLETE BASE WELDMENT 2 4 45209 QUAD OUTRIGGER WELDMENT 3 2 22290-0010 SWIVEL CASTER, FLAT PLATE 4 2 22290-0009 SWIVEL CASTER, FLAT PLATE, W/BRAKE 5 4 45206 INSERT,QUAD ADJUSTMENT FOOT 6 4 45205 SPACER,QUAD CASTER 7 32 A27727 3/83 -16x1-1/4 HEX BOLT 8 32 A21924 ...

  • Middleby Marshall 60254 - page 15

    11 P/N60254September28,2012 ITEM NO. QTY PART NO. DESCRIPTION 1 1 66159 COMPLETE BASE WELDMENT 2 4 45209 QUAD OUTRIGGER WELDMENT 3 2 22290-0010 SWIVEL CASTER, FLAT PLATE 4 2 22290-0009 SWIVEL CASTER, FLAT PLATE, W/BRAKE 5 4 45206 INSERT,QUAD ADJUSTMENT FOOT 6 4 45205 SPACER,QUAD CASTER 7 32 A27727 3/83 -16x1-1/4 HEX BOLT 8 32 A21924 ...

  • Middleby Marshall 60254 - page 16

    12 P/N60254September28,2012 III. VENTILATION SYSTEM NOTE THAT THE HOOD DIMENSIONS SHOWN IN FIGURE 2-5 ARE RECOMMENDATIONS ONLY . LOCAL, NATIONAL AND INTERNATIONAL CODES MUST BE FOLLOWED WHEN INSTALLING THE VENTILATION SYSTEM. ANY APPLICABLE CODES SUPERSEDE THE RECOMMENDATIONS SHOWN IN THIS MANUAL. The rate of air ow exhausted thro ...

  • Middleby Marshall 60254 - page 17

    13 P/N60254September28,2012 IV. ASSEMBLY A. Top Panel and Base Pad Assembly 1. Install the four leg extensions onto the base pad using the 3/8 ″ -16 × 1 ″ screws, 3/8 ″ flat washers, and 3/8 ″ lockwashers supplied in the Base Pad Kit. See Figure 2-6. Check that the nished sides of each leg exten- sion face OUTWARDS. One r ...

  • Middleby Marshall 60254 - page 18

    14 P/N60254September28,2012 NOTE: DO NOT install top panel onto double or triple ovens until AFTER stacking the oven cavities. See Part B, Stacking. B. Stacking For single ovens, skip ahead to Part C, Restraint Cable Installation. IMPORTANT Middleby Marshall STRONGLY RECOMMENDS that PS740 Electric oven cavities be stacked BY AUTHORIZ ...

  • Middleby Marshall 60254 - page 19

    15 P/N60254September28,2012 D. Conveyor Installation 1. Unfold the conveyor as shown in Figure 2-12. Then, begin to slide the conveyor into the end of the oven. The conveyor can only be installed from the end of the oven with the drive motor. 2. Continue moving the conveyor into the oven until the frame protrudes equally from each en ...

  • Middleby Marshall 60254 - page 20

    16 P/N60254September28,2012 5. If it is necessary to add or remove conveyor links to achieve the correct tension, OR if it is necessary to reverse the conveyor belt for correct orientation, the belt will need to be removed from the conveyor frame. If this is necessary, perform the following procedure: • Remove the conveyor assembly ...

  • Middleby Marshall 60254 - page 21

    17 P/N60254September28,2012 III. ELECTRICAL CONNECTION INFORMATION FOR PS740E-SERIES OVENS. WARNING Authorized supplier personnel normally accomplish the connections for the ventilation system, electric supply, as arranged by the customer. Following these connections, the factory-authorized installer can perform the initial startup o ...

  • Middleby Marshall 60254 - page 22

    18 P/N60254September28,2012 UTILITY ROUGH-IN DIMENSIONS AND POSITIONING FOR PS740-SERIES OVENS Figure 2-19. Typical PS740-Series Oven(s) Installation T o O v en T o O v en WARNING DO NOT USE CONDUIT FOR GROUND CONNECTION. CAUTION IT IS RECOMMENDED THAT THE OVEN BE PLACED UNDER A VENTILATION HOOD FOR ADEQUATE AIR SUPPLY AND VENTILATIO ...

  • Middleby Marshall 60254 - page 23

    19 P/N60254September28,2012 SECTION 3 - OPERA TION I. LOCATION AND DESCRIPTION OF CONTROLS A. Main On/Off Button Turns all oven functions on or off. If the oven is below the set point, it will rise to the set point and turn the conveyor on. If it is turned off and the oven is above 200° F, the blowers will remain on until the oven d ...

  • Middleby Marshall 60254 - page 24

    20 P/N60254September28,2012 II. NORMAL OPERATION - STEP-BY-STEP- A. Daily Startup Procedure 1. Check that the circuit breaker/fused disconnect is in the On position. Check that the window is closed. The touch panel display should be lit. 2. Adjust the conveyor to the desired bake time. 3. Press the temperature button to display right ...

  • Middleby Marshall 60254 - page 25

    21 P/N60254September28,2012 III. QUICK REFERENCE: TROUBLESHOOTING SYMPTOM PROBLEM SOLUTION Noelectricalpower • Checkthatthecircuitbreaker/fuseddisconnectison.Make suretheemergenctstopbuttonison. Oven will not turn On. Faulty contactor Faulty heater element • Replace contactor. ...

  • Middleby Marshall 60254 - page 26

    22 P/N60254September28,2012 Vents on front panel of oven Fan grills (3) on rear of oven and control compartment Vent (2) on rear of machinery compartment SECTION 4 - MAINTENANCE WARNING Possibility of injury from moving parts and electrical shock exists in this oven. Switch off and lockout/tagout the electric supply BEFORE beginning ...

  • Middleby Marshall 60254 - page 27

    23 P/N60254September28,2012 II. MAINTENANCE – MONTHLY NOTE: When removing the conveyor, refer to Figure 2-12 (in Section 2, Installation ). A. Check that the oven is cool and the power is disconnected, as described in the warning at the beginning of this Sec - tion. B. Remove the crumb trays from the oven. C. Lift the drive end of ...

  • Middleby Marshall 60254 - page 28

    24 P/N60254September28,2012 III. MAINTENANCE – EVERY 3 MONTHS A. Check that the oven is cool and the power is disconnected, as described in the warning at the beginning of this Section. B. Vacuum both of the blower mounts, and their surrounding compartments, using a shop vacuum. C. Tighten all electrical terminal screws. D. Split B ...

  • Middleby Marshall 60254 - page 29

    25 P/N60254September28,2012 Figure 4-6. Disassembling the drive shaft E. Blower Belt 1. Remove the eight screws shown in Figure 4-7. Then, remove the rear panel from the oven. 2. Check the blower belt for the proper 1/4 ″ (6mm) deection at the center, and for cracking or excessive wear. See Figure 4-7. Overtightening the belt wi ...

  • Middleby Marshall 60254 - page 30

    26 P/N60254September28,2012 V. KEY SPARE PARTS – Available separately. See Figure 4-8. Figure 4-8. Key Spare Parts ITEM QTY . P/N DESCRIPTION  1 1 60190 DIGITAL DISPLAY, PROGRAMMED 2 1 58920 CONVEYOR DRIVE MOTOR W/PICKUP ASSY. 3 1 58679 CONVEYOR SPEED CONTROLER 4 1 60196 KIT, THERMOCOUPLE 6 ″ 5 1 59668 BELT, BLOWER 6 1 57288 M ...

  • Middleby Marshall 60254 - page 31

    27 P/N60254September28,2012 SECTION 5 TROUBLESHOOTING PROBLEM: PRODUCTS ARE OVERCOOKED OR UNDERCOOKED Check for correct setting of conveyor speed control. Set the conveyor speed control at correct setting. Check for correct setting on tempera - ture controller. Turn temperature control to correct setting. If products still cook incor ...

  • Middleby Marshall 60254 - page 32

    28 P/N60254September28,2012 SECTION 6 - WIRING DIAGRAM Middleby-Marshall Model Number E208-240 Volt 50/60 Hz, 3 Phase 60739 Rev. J ...

  • Middleby Marshall 60254 - page 33

    29 P/N60254September28,2012 Middleby-Marshall Model Number E380-480 Volt 50/60 Hz, 3 Phase 60741 Rev. L ...

  • Middleby Marshall 60254 - page 34

    30 P/N60254September28,2012 NOTES ...

  • Middleby Marshall 60254 - page 35

    31 P/N60254September28,2012 NOTES ...

  • Middleby Marshall 60254 - page 36

    P/N60254September28,2012 Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • USA • (847)741-3300 • FAX (847)741-4406 www.middleby.com Middleby is proud to support the Commercial Food Equipment Service Association (CFESA). We recognize and applaud CFESA's ongoing efforts to improve the quality of ...

Fabbricante Middleby Marshall Categoria Oven

I documenti che otteniamo dal fabbricante del dispositivoMiddleby Marshall 60254 possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici Middleby Marshall
- manuali per l’uso 60254
- schede prodotto Middleby Marshall
- opuscoli
- o etichette energetiche Middleby Marshall 60254
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso Middleby Marshall 60254.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione Middleby Marshall 60254, manuali di manutenzione, brevi manuali o manuali utente Middleby Marshall 60254. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto Middleby Marshall 60254.

Manuali per l’uso simili

Manuale completo del dispositivo Middleby Marshall 60254, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare Middleby Marshall 60254 dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti Middleby Marshall 60254.

Il manuale per l’uso completo Middleby Marshall, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale Middleby Marshall 60254 - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice Middleby Marshall 60254, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per Middleby Marshall 60254 che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo Middleby Marshall 60254 - che ci dovrebbe aiutare nei primi passi durante l'uso Middleby Marshall 60254
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del Middleby Marshall 60254
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio Middleby Marshall 60254 in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su Middleby Marshall 60254?

Utilizza il modulo sottostante

Se non hai risolto il problema con Middleby Marshall 60254 con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Middleby Marshall 60254 è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Captcha
Nuova immagine

Commenti (0)