Italiano dropdown-ico

Manuale per l’uso United States Stove 1600M

20 pagine 1.19 mb
Scarica

Vai alla pagina of 20

Summary
  • United States Stove 1600M - page 1

    1 Installation/Operator's Manual #851547A MODEL: 1600M MODEL: 1600M MODEL: 1600M MODEL: 1600M MODEL: 1600M WOOD and COAL FURNACE SAFETY NOTICE: IF THIS FURNACE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. FOR YOUR SAFETY, FOLLOW THE INSTALLATION DIRECTIONS. CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION REQ ...

  • United States Stove 1600M - page 2

    2 INTRODUCTION Thank you for your purchase of a U.S. Stove Wood and Coal burning furnace. Your decision to buy our Clayton Furnace was undoubtedly reached after much careful thought and considera- tion. We are very proud you chose the U.S. Stove furnace and trust you will receive the comfort and economy that others realize when heating with a U.S. ...

  • United States Stove 1600M - page 3

    3 NOTE: Type of chimney: Class A All-Fuel UL 103HT 1. The furnace should be the only heating appliance using a chimney flue. One furnace per flue. 2. A masonry chimney should have a tile or stainless steel liner. 3. The masonry chimney should not have any missing mortar or loose bricks. 4. There should be no mortar or parts of the chimney blocking ...

  • United States Stove 1600M - page 4

    4 maintains clearances, keeps condensation and creosote within the pipe, and is capable of withstanding a two to three thousand degree chimney fire. 1. The connector pipe should slant down toward the furnace a minimum of 1/4" to the foot. At no time should the pipe turn downward toward the chimney or run horizontal. 2. There should be no more ...

  • United States Stove 1600M - page 5

    5 COMBUSTION AIR All fires need air (specifically oxygen) to burn. Furnaces, fire- places, and wood-burning furnaces need enough oxygen for complete combustion of their fuels. The incomplete combustion that takes place when a furnace is "air starved" causes carbon monoxide (CO) to be formed in quantities that can be dangerous inside a wel ...

  • United States Stove 1600M - page 6

    6 Your furnace is shipped from the factory in four (2) packages. 1) the furnace, 2) the blower. The draft kit and parts box containing all parts necessary, and the fan thermodisc kit is boxed and packed in the firebox or ash pan. Before assembling the furnace, check to make sure there is no shipping damage, and that all necessary parts are located ...

  • United States Stove 1600M - page 7

    7 SMOKE CHAMBER (If re-assembly is necessary): 1. Place #1 firebrick in the back of smoke chamber. 2. Slide baffle plate into smoke chamber, flat side down. 3. Place remaining firebrick in smoke chamber as numbered below. (In placing the firebrick in the smoke chamber, lift the left side of firebrick first and drop into place.) See Illustra tions b ...

  • United States Stove 1600M - page 8

    8 DISTRIBUTION BLOWER INSTALLATION Distribution blower slides onto rear of furnace. Engage blower flange with channels and press down. SHAKER GRATE HANDLE INSTALLATION 1. Attach angle with two 1/4" x 3/4" hex bolts and two 1/4" lock nuts. 2. Attach handle with 1/4" x 1" hex bolt and 1/4" lock nut. 3. Put brass knob ont ...

  • United States Stove 1600M - page 9

    9 ALL WIRING MUST BE DONE BY A QUALIFIED ELECTRICIAN Predrilled holes are provided on the back of the furnace for mounting the electrical box. ELECTRICAL INSTALLATION ...

  • United States Stove 1600M - page 10

    10 ALL WIRING MUST BE DONE BY A QUALIFIED ELECTRICIAN ...

  • United States Stove 1600M - page 11

    11 5. Close the spin draft cap on ash door. 6. The motorized natural draft cycles on demand from the U.S. Stove wall thermostat. Setting the thermostat four degrees higher that your existing thermostat is recom- mended. During operation, the motorized natural draft remains open until the thermostat temperature setting is reached. CAUTION: Hot Surfa ...

  • United States Stove 1600M - page 12

    12 OPERATING NOTES  Do not over draft the furnace! It is designed to operate at .06 inches of water column and must be set with a draft gauge to maintain a steady draft. (Barometric Damper recommended.)  Do not allow ashes to build up higher than 2" above grates.  Be extremely careful when removing furnace ash pan; it can get very hot ...

  • United States Stove 1600M - page 13

    13 TROUBLE SHOOTING AND PROBLEM SOLVING 1. Problem: Smoke puffs from furnace Solution: A . Check chimney draft. Check for blocked chimney or flue pipe. Use mirror to check chimney clearance. B . Check ash pit — if it is too full, empty. C . Make sure furnace room is not too airtight. D . Make sure all of chimney mortar connections are airtight. E ...

  • United States Stove 1600M - page 14

    14 ITEM DECRIPTION PART # 1 5 Baffle Rod 86603 1 6 Top Insulation C98871 1 7 Front Filler 23817 1 8 Draft Cover 23818 1 9 Top Flue Ring 22761 2 0 Draft Cap (2) 23859 2 1 3/8" x 2-1/2" Bolt (2) 83835 2 2 Back Liner 40313 2 3 Front Liner 40344 NOTE: 1600 = 16 - FULL BRICK 3- HALF BRICK PARTS LIST MODEL 1600M * = NOT SHOWN !! IMPORTANT !! Wh ...

  • United States Stove 1600M - page 15

    15 PARTS LIST 29 35 33 27 34 26 30 40 37 39 38 ITEM DESCRIPTION PART# 2 6 Top Safety Latch 23786 2 7 Feed Door 69091 2 8 Ash Door 68880 2 9 Door Latch Handle 24179(2) 3 0 Ash Door Latch 23823 3 1 1/2" Flat Washer 83835(2) 3 2 1/2" Lock Nut 83444(3) 3 3 5/16" x 1" Hinge Pin C21399(4) 3 4 1/2" Rope for Fire Door 52" 8805 ...

  • United States Stove 1600M - page 16

    16 PARTS LIST MODELS 1600M Fan Thermodisc Kit #69455 ITEM DESCRIPTION PART# 1 3-Speed Switch 80361 2 Plastic Knob C9267M 3 Low Speed Thermodisc 80388 2 1 5 MODEL 1600M - Blower Motor Kit #69160 (1400CFM) - Blower Housing Kit #69281 ITEM DESCRIPTION PART# 4 3-Speed Motor 1/3 hp 80416 5 Blower Housing (1600) C46799 6 Capacitor C45699 3 4 6 ...

  • United States Stove 1600M - page 17

    17 ITEM DESCRIPTION PART# 1 Draft Blower 80422 2 Power Supply Cord C40899 3 FAD Bracket 69192 4 10-24 Kep Nut (3ea.) 83244 5 1/4-20 x 1" Bolt (2ea) 83379 6 1/4-20 Lock Nut 83261 FORCED AIR DRAFT PARTS LIST (Kit #: 69189) PRE-ASSEMBLED AT FACTORY (OPTIONAL KIT) ...

  • United States Stove 1600M - page 18

    18 INSTALLATION OF OPTIONAL EQUIPMENT INSTALLING DOMESTIC HOT WATER COIL 1. Remove access panel at rear of enclosure. 2. With a utility knife cut out the section of fiberglass insulation directly behind the access panel. 3. Remove cover plate from rear of firebox. 4. Place one nut on each end of the coil and thread each as far as they will go. 5. P ...

  • United States Stove 1600M - page 19

    19 INSTALLING OPTIONAL BACK DRAFT DAMPER The back draft damper may be installed in either a vertical or horizontal section of the hot air duct. It should be positioned as close to the plenum opening of the furnace as practical. Press female end of the back draft damper over Clayton Furnace collar or male end of the duct pipe. When properly placed t ...

  • United States Stove 1600M - page 20

    20 HO W TO ORDER REP AIR P AR TS THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SERVICE FROM THE HEATER, AND ENABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP IN A SAFE PLACE FOR FUTURE REFERENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE BACK OF THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS G ...

Fabbricante United States Stove Categoria Furnace

I documenti che otteniamo dal fabbricante del dispositivoUnited States Stove 1600M possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici United States Stove
- manuali per l’uso 1600M
- schede prodotto United States Stove
- opuscoli
- o etichette energetiche United States Stove 1600M
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso United States Stove 1600M.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione United States Stove 1600M, manuali di manutenzione, brevi manuali o manuali utente United States Stove 1600M. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto United States Stove 1600M.

Manuali per l’uso simili

Manuale completo del dispositivo United States Stove 1600M, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare United States Stove 1600M dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti United States Stove 1600M.

Il manuale per l’uso completo United States Stove, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale United States Stove 1600M - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice United States Stove 1600M, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per United States Stove 1600M che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo United States Stove 1600M - che ci dovrebbe aiutare nei primi passi durante l'uso United States Stove 1600M
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del United States Stove 1600M
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio United States Stove 1600M in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su United States Stove 1600M?

Utilizza il modulo sottostante

Se non hai risolto il problema con United States Stove 1600M con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con United States Stove 1600M è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Captcha
Nuova immagine

Commenti (0)