Manuale per l’uso Lincoln 1117-000-A

32 pagine 0.9 mb
Scarica

Vai alla pagina of 32

Summary
  • Lincoln 1117-000-A - page 1

    1100AdvDigSvc REV: 3/20/08 SERVICE MANUAL (DOMESTIC) IMPINGER ADVANTAGE DIGITAL SERIES MODEL 1116-000-A, 1117-000-A, 1130-000-A, 1131-000-A, 1132-000-A, 1133-000-A WITH PUSH BUTTON CONTROLS Lincoln Foodservice Products, LLC 1111 North Hadley Road Fort Wayne, Indiana 46804 United States of America Phone : (800) 374-3004 U.S. Fax: (888) 790-8193 • ...

  • Lincoln 1117-000-A - page 2

    Impinger II – Advantage Digital Service Manual - Domestic 2 SEQUENCE OF OPERATION IMPINGER II ADVANTAGE SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) MODEL 1116-000-A NAT. GAS 120VAC 60 HZ. 1 PHASE MODEL 1117-000-A LP GAS 120VAC 60 HZ. 1 PHASE POWER SUPPLY Electrical power is supplied to the oven by a three-co nductor cordset. ...

  • Lincoln 1117-000-A - page 3

    Impinger II – Advantage Digital Service Manual - Domestic 3 SEQUENCE OF OPERATION IMPINGER II ADVANTAGE SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) 1130-000-A 208VAC 60 HZ. 1 PHASE 1131-000-A 240VAC 60 HZ. 1 PHASE 1132-000-A 208VAC 60 HZ. 3 PHASE 1133-000-A 240VAC 60 HZ. 3 PHASE POWER SUPPLY Electrical power to be supplied t ...

  • Lincoln 1117-000-A - page 4

    Impinger II – Advantage Digital Service Manual - Domestic 4 SCHEMATIC DIAGRAM MODEL 1116-000-A, 1117-000-A SERIAL NUMBER 2038616 AND ABOVE ...

  • Lincoln 1117-000-A - page 5

    Impinger II – Advantage Digital Service Manual - Domestic 5 SCHEMATIC DIAGRAM MODEL 1130-000-A, 1131-000-A SERIAL NUMBER 2038616 AND ABOVE ...

  • Lincoln 1117-000-A - page 6

    Impinger II – Advantage Digital Service Manual - Domestic 6 SCHEMATIC DIAGRAM MODEL 1132-000-A, 1133-000-A SERIAL NUMBER 2038616 AND ABOVE ...

  • Lincoln 1117-000-A - page 7

    Impinger II – Advantage Digital Service Manual - Domestic 7 TROUBLESHOOTING GUIDE GAS OVENS SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) MODEL 1116-000-A NAT. GAS 120VAC 60 HZ. MODEL 1117-000-A LP GAS 120VAC 60 HZ. SYMPTOM POSSIBLE CAUSE EVALUATION Oven fan will not run Incoming power sup ply Check circuit breakers, reset if ...

  • Lincoln 1117-000-A - page 8

    Impinger II – Advantage Digital Service Manual - Domestic 8 Main fan If not operating, refer to “Oven fan will not run”. Centrifugal switch of main fan motor Check for 120VAC at wire #5 (inp ut to centrifugal switch, located at 6-pin connecto r in ra ceway near the main fan motor) to neutral. If no voltage is present, trace wiring back to the ...

  • Lincoln 1117-000-A - page 9

    Impinger II – Advantage Digital Service Manual - Domestic 9 valves, the valve should open. Check for gas pressure at the manifold tap located just before the burner. If there is no pressure, check the incoming gas supply to be sure all manu al valves are open and flexible gas hose i s properly connected. If gas is present, and the gas control val ...

  • Lincoln 1117-000-A - page 10

    Impinger II – Advantage Digital Service Manual - Domestic 10 voltage output at the oven control, check the read- out on the control. If the control reads “P ROBE FAIL”, this indicates that the thermocouple has failed or become disconnected from the oven control. Thermocouple Check to be sure that the thermocouple is securely connected to the ...

  • Lincoln 1117-000-A - page 11

    Impinger II – Advantage Digital Service Manual - Domestic 11 wiring back to the oven power relay. If voltage is present, check for 24 VAC at the transformer secondary. If there is primary voltage but no secondary voltage, replace control tran sformer. Conveyor motor Check for 120 VAC supply to the convey or motor at wire #14 to neutral. If no vol ...

  • Lincoln 1117-000-A - page 12

    Impinger II – Advantage Digital Service Manual - Domestic 12 TROUBLESHOOTING GUIDE ELECTRIC OVENS 1130-000-A 208VAC 60 HZ. 1 PHASE 1131-000-A 240VAC 60 HZ. 1 PHASE 1132-000-A 208VAC 60 HZ. 3 PHASE 1133-000-A 240VAC 60 HZ. 3 PHASE SYMPTOM POSSIBLE CAUSE EVALUATION Oven fan will not run Incoming power supply Check circuit breakers. Reset if requi r ...

  • Lincoln 1117-000-A - page 13

    Impinger II – Advantage Digital Service Manual - Domestic 13 oven cavity thermostat and rete st. If thermostat will not hold for maximum oven temperature, and oven is not exceeding temperature setting, check for prope r location of capillary bulb in its spring holder. If the capillary checks okay, replace the hi -limit thermostat. Control transfo ...

  • Lincoln 1117-000-A - page 14

    Impinger II – Advantage Digital Service Manual - Domestic 14 activate, replace the mercury contactor. Also check each contactor for hi gh voltage in put and output. Heating element(s) Check the Amp draw on each p ower le g for proper load. Check the sp ecification pla te for rating information. If the amp draw is high or low, check the individual ...

  • Lincoln 1117-000-A - page 15

    Impinger II – Advantage Digital Service Manual - Domestic 15 discharge before testing. Switch, conveyor reversing Check co ntinuity between swit ch terminals. Replace switch as needed. Oven control If there is supply voltage to the motor, and the motor, capacitor, and reversing switch check good, replace the oven control. Conveyor motor runs, but ...

  • Lincoln 1117-000-A - page 16

    Impinger II – Advantage Digital Service Manual - Domestic 16 REMOVAL, INSTALLATION AND ADJUSTM ENTS IMPINGER II ADVANTAGE SERIES CAUTION BEFORE REMOVING OR INSTALLING ANY COMPONENT IN THE IMPINGER OVEN BE SURE TO DISCONNECT EL ECTRICAL POWER AND GAS SUPPLY. MAIN FAN – REPLACEMENT A. Shut off power at main breaker. B. Remove motor cover from bac ...

  • Lincoln 1117-000-A - page 17

    Impinger II – Advantage Digital Service Manual - Domestic 17 FUSE HOLDER – REPLACEMENT A. Shut off power at main breaker. B. Remove control box cover and front pa nel. C. Remove wires from fuse h o lder and ma rk for reassembly. D. Remove mounting screws or mounting n ut on fuse hol der and remove fuse holde r. E. Reassemble in reverse order an ...

  • Lincoln 1117-000-A - page 18

    Impinger II – Advantage Digital Service Manual - Domestic 18 TRANSFORMER, BURNER – REPLACEMENT A. Shut off power at main breaker. B. Remove control panel top and front cover. C. Remove all wires from transformer and mark for re assembly. D. Remove two mounting screws from tr ansformer base and re move transformer. E. Reassemble in reverse order ...

  • Lincoln 1117-000-A - page 19

    Impinger II – Advantage Digital Service Manual - Domestic 19 BURNER CONTROL – REPLACEMENT A. Shut off power at main breaker. B. Remove control panel top and front cover. C. Remove wires from control and mark for reassembly. D. Remove mounting screws from control and rem ove burner control. E. Reassemble in reverse order and check system operati ...

  • Lincoln 1117-000-A - page 20

    Impinger II – Advantage Digital Service Manual - Domestic 20 BYPASS ORIFICE – REPLACEMENT A. Shut off power at main breaker. B. Shut off gas supply to the oven and di sconnect the flexible gas line to oven. C. Remove control panel top and front cover. D. Disconnect bypass tube from gas valve. E. Remove bypass orifice from gas valve. F. Reassemb ...

  • Lincoln 1117-000-A - page 21

    Impinger II – Advantage Digital Service Manual - Domestic 21 AIR PRESSURE SWITCH – REPLACEMENT A. Shut off power at main breaker. B. Remove control panel top and front cover. C. Disconnect wiring from air pre ssure switch and mark for reassembly. D. Disconnect air tube from air pre ssure switch. E. Remove two mounting screws and remove air pres ...

  • Lincoln 1117-000-A - page 22

    Impinger II – Advantage Digital Service Manual - Domestic 22 IMPINGER II ADVANTAGE GENERAL VIEW LETTER PART NUMBER DESCRIPTION A 369390 Caster 4” w/ mounting pl ate B 369502 Bottom finger cover C Columnating plate, see Installation & Operations manual D 370010 Bottom finger housing E 369504 Top finger housin g F Columnating plate, see Insta ...

  • Lincoln 1117-000-A - page 23

    Impinger II – Advantage Digital Service Manual - Domestic 23 ...

  • Lincoln 1117-000-A - page 24

    Impinger II – Advantage Digital Service Manual - Domestic 24 CONTROL BOX MODEL 1116-000-A, 1117-000-A SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) LETTER PART NUMBER DESCRIPTION A 369124 Cooling fan B 369537 Power cord C 370362 Thermocouple type “K” D 370378 Conveyor Motor (S/N 2052 462 & Below) 370675 Conveyor Motor ...

  • Lincoln 1117-000-A - page 25

    Impinger II – Advantage Digital Service Manual - Domestic 25 ...

  • Lincoln 1117-000-A - page 26

    Impinger II – Advantage Digital Service Manual - Domestic 26 CONTROL BOX MODEL 1130-000-A, 1131-000-A, 1132-000-A, 1132-000-A SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) LETTER PART NUMBER DESCRIPTION A 370108 Control box top B 370355 Control, oven C 369432 On/off switch D 370354 Facia, Label E 370107 Side panel F 370067 369 ...

  • Lincoln 1117-000-A - page 27

    Impinger II – Advantage Digital Service Manual - Domestic 27 ...

  • Lincoln 1117-000-A - page 28

    Impinger II – Advantage Digital Service Manual - Domestic 28 OVEN BACK ASSEMBLY LETTER PART NUMBER DESCRIPTION A 369182 Fan B 369899 Fan shroud C 369655 Stand off D Heating element 369183 208 Volt 369184 240 Volt E Rear wall 369976 Gas ovens 369549 Electric ovens F 369581 Motor mount G Motor 369539 Gas ovens (120VAC) 369181 Electri c ovens (208/2 ...

  • Lincoln 1117-000-A - page 29

    Impinger II – Advantage Digital Service Manual - Domestic 29 ...

  • Lincoln 1117-000-A - page 30

    Impinger II – Advantage Digital Service Manual - Domestic 30 CONVEYOR / DOOR LETTER PART NUMBER DESCRIPTION A 369611 Cou pler (S/N 2052462 & Below) B 369664 Cou pling center (S/N 2052 462 & Below) C 369269 Ball plunge r (S/N 2052462 & Below) D 370116 Set screw (S/N 2052462 & Below) Not Shown 370671 Drive Coupli ng (S/N 2052463 &am ...

  • Lincoln 1117-000-A - page 31

    Impinger II – Advantage Digital Service Manual - Domestic 31 ...

  • Lincoln 1117-000-A - page 32

    Impinger II – Advantage Digital Service Manual - Domestic 32 ...

Fabbricante Lincoln Categoria Oven

I documenti che otteniamo dal fabbricante del dispositivoLincoln 1117-000-A possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici Lincoln
- manuali per l’uso 1117-000-A
- schede prodotto Lincoln
- opuscoli
- o etichette energetiche Lincoln 1117-000-A
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso Lincoln 1117-000-A.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione Lincoln 1117-000-A, manuali di manutenzione, brevi manuali o manuali utente Lincoln 1117-000-A. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto Lincoln 1117-000-A.

Manuali per l’uso simili

Manuale completo del dispositivo Lincoln 1117-000-A, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare Lincoln 1117-000-A dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti Lincoln 1117-000-A.

Il manuale per l’uso completo Lincoln, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale Lincoln 1117-000-A - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice Lincoln 1117-000-A, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per Lincoln 1117-000-A che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo Lincoln 1117-000-A - che ci dovrebbe aiutare nei primi passi durante l'uso Lincoln 1117-000-A
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del Lincoln 1117-000-A
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio Lincoln 1117-000-A in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su Lincoln 1117-000-A?

Utilizza il modulo sottostante

Se non hai risolto il problema con Lincoln 1117-000-A con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Lincoln 1117-000-A è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Commenti (0)