日本語 dropdown-ico

United States Stove 6037の取扱説明書

24ページ 0.39 mb
ダウンロード

ページに移動 of 24

Summary
  • United States Stove 6037 - page 1

    USSC 1 851595 CORN & PELLET MUL TIFUEL ST OVE 6037 OWNER’S MANUAL Installation - Operation - Maintenance Instructions - Repair Parts READ THIS ENTIRE MANUAL , THOROUGHL Y , BEFORE A T TEMPTING TO INST ALL AND/OR BURN YOUR NEW AMERICAN HARVEST CORN AND PELLET MUL TI-FUEL ST OVE. F AILURE T O FOLLOW THESE INSTRUCTIONS MA Y RESUL T IN PROPERTY D ...

  • United States Stove 6037 - page 2

    2 USSC SPECIFICATIONS United States Stove Company ( manufacturer of the American Harvest Multifuel Pellet Stove ) reserves the right to alter products, specifications and price without notice. Safety T ested & Listed to ASTM- E 1509, ULC -C 1482, (UM) 84-HUD, by OMNI T est Laboratories, Inc. , B ea verton, Oregon USA NOTE: YOUR UNIT MUST BE INS ...

  • United States Stove 6037 - page 3

    USSC 3 Ashes will have to be Remov ed from the stove periodically . See cleaning procedure. Y ou can minimize cleaning required and maximize efficiency by maintaining the correct draft settings. See “Setting the Draft” further in the manual. The draft setting on your stove may have to be changed from time to time to accommodate your specific bu ...

  • United States Stove 6037 - page 4

    4 USSC FLOOR PROTECTION The American Harvest Multifuel Stove may be installed on a combustible floor , with proper floor protection, or on a masonry hearth. The hearth or noncombustible floor protector must extend a minimum of (6) inches (152mm)in front and (6) inches (152mm) from each side of the ash remo val door . INSTALLATION REQUIREMENTS SHELL ...

  • United States Stove 6037 - page 5

    USSC 5 CLEARANCES TO COMBUSTIBLES The stove must be installed with the following minimum clearances to side and back wall combustible materials. NOTE: These are minimum clearances to combustible walls established by the testing lab. The amount of room needed on the left side of the unit to access the electrical panel is (6) six inches (152mm). PARA ...

  • United States Stove 6037 - page 6

    6 USSC NOTE: These are guidelines only. Proper venting is accomplished by design and common sense. In most installations 3” inch diameter venting is adequate. If it does not vent properly you will have to change it to 4”. DO NOT CONNECT TO ANY AIR DISTRIBUTION DUCT OR SYSTEM GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN • • • • • • ...

  • United States Stove 6037 - page 7

    USSC 7 For installations with horizontal through-the-wall exhaust, it is strongly recommended that the stove combustion air be connected to the outside. If the home is newer or has been tightly insulated it is required to install outside combustion air . Connection to outside the house is REQUIRED for mobile home installations. W e strongly urge us ...

  • United States Stove 6037 - page 8

    8 USSC Note: Where passage through a wall, or partition of combustible construction is desired, the installation shall conform to CAN/CSA -B365 The American Harvest Corn/Pellet Stove Model 6037 may be installed as follows: 1) A freestanding unit MOBILE HOME INSTALLATION REQUIREMENTS IN ADDITION TO THE STANDARD INSTALLATION INSTRUCTION, THE FOLLOWIN ...

  • United States Stove 6037 - page 9

    USSC 9 Locate proper position f or the type “PL ” wall thimble (F). Use a saber saw or keyhole saw to cut a 7 1/4-inch diameter hole through the wall (E) for a 3-inch pipe. For a 4-inch pipe, cut an 8 1/4-inch hole. Install the wall thimble (F)in the hole. The size of hole opening will vary with brand of wall thimble. P osition stove approximat ...

  • United States Stove 6037 - page 10

    10 USSC T ermination Cap Fresh Air Intake (Optional 67F AK) With 90 Degree Elbow or Hood (Pest Guard, 3/8” Mesh Maximum) Clean Out Cover Te e Wall Thimble 6” Min. Non Combustible Hearth Plate Support Bracket 9” Min. THROUGH THE WALL, VER TICAL PIPE INST ALLA TION WITH TERMINA TION CAP The Hearth Pad is not required under the unit if the floor ...

  • United States Stove 6037 - page 11

    USSC 11 Y our American Harvest Corn/Pellet Stove comes to you with the glass door installed in place, ready f or use. The glass is surrounded on the edges with a gasket and seated in a glass channel. It is held in place with four (4) clips. REMOVAL OF BROKEN OR DAMAGED CERAMIC GLASS Open the door and lift off of hinges. If the door is tight, tap ge ...

  • United States Stove 6037 - page 12

    12 USSC STOVE CONTROLS Adjustable Door Handle lifts up and turns left to open. Ash Dump Shutoff Pull out to empty ashes out of the firebox area. Make sure to push all the way in when done. Front View Left/Front View Circuit Board Control Panel Manual Draft Adjustment Slide in or out to adjust the amount of draft flowing through the firebox. Service ...

  • United States Stove 6037 - page 13

    USSC 13 LIGHTING INSTRUCTIONS CAUTION: DO N OT USE CHEMICALS OR FLUIDS TO ST ART THE FIRE HOT WHILE IN OPERA TION. KEEP CHILDREN, CLO THING AND FURNITURE AW AY . CONT ACT MA Y CAUSE SKIN BURNS. • • • • • • • • • • • • Before lighting your American Harvest for the first time, make sure that all items are out of the hopper , a ...

  • United States Stove 6037 - page 14

    14 USSC SETTING THE DRAFT A proper draft setting is crucial to the successful burning of solid fuels. Draft refers to the amount of air flowing through the burn chamber of your stov e. T oo much or too lit tle draft will cause your stove to burn improperly and may r esult in the fire burning out or excessive deposits (clinkers). Please follow these ...

  • United States Stove 6037 - page 15

    USSC 15 The 6037 has (2) front cleanout slides that must be in the closed position when burning the unit. • • • • • Set the stove on high fire. Open the draft to 100% and allow the stove to burn for 15 minutes. Resume desired heat and draft setting. Shut down the stove as directed in the operating instructions. Allow the stove to cool to ...

  • United States Stove 6037 - page 16

    16 USSC FUEL ADDITIVE Chicken Scratch for my Corn Burner? Y es - Cr azy as it may sound, ground Oyster Shells, (calcium carbonate) same as fed to chickens, is the ideal additiv e to promote clean burning, especially when the Corn Fuel is extra high in starch. And it’s available at your local Feed and Seed. The “aver age” mixture is 1/2 pound ...

  • United States Stove 6037 - page 17

    USSC 17 COMPONENT OPERA TION ST ART OPERA TION END CIRCUIT BOARD FUNCTIONS ST ART -UP SEQUENCE OF EVENTS Once the control panel is turned to one of the five heat settings, a timer begins that will start, stop and continue operation of the American Harvest as a preset temperature is achieved. Exhaust Blower Agitator Auger Room Fan Automatic Shutdown ...

  • United States Stove 6037 - page 18

    18 USSC Exhaust Blower Agitator Auger Room Fan Automatic Shutdown COMPONENT SHUTDOWN OPERA TION END CIRCUIT BOARD FUNCTIONS continued... SHUTDOWN SEQUENCE OF EVENTS Once the AMERICAN HARVEST has reached the normal operating temperature and switched to the “OFF” position, the unit will continue to operate on a much lower setting for 10 minutes. ...

  • United States Stove 6037 - page 19

    USSC 19 TROUBLE SHOOTING Unplug stove before performing any maintenance PROBLEM CAUSE: T oo rich air/fuel mixture ? Fire burns with a lazy , orange flame and/or fuel builds up in the firepot. Glass may become dirty . ? Fire goes out or stove shuts down. Fuel may stop feeding. ? Fire goes out or stove shuts down. Fuel may stop feeding. Increase air ...

  • United States Stove 6037 - page 20

    20 USSC WIRING DIAGRAM ...

  • United States Stove 6037 - page 21

    USSC 21 REPAIR PARTS DIAGRAM-6037 45 ...

  • United States Stove 6037 - page 22

    22 USSC K EY PAR T # DESCRIPTION QTY. 1 69437B Ash Pan Guide Assy . , P ainted 1 2 25309B Pedestal, Painted 1 3 25158B P edestal T rim, P ainted 1 4 25317B Pedestal Back, Painted 1 5 69364B Ash Pan, Painted 1 6 69443 Hopper Assembly 1 7 891118 Safety Guard 1 8 25315B Cabinet T op, P ainted 1 9 25316B Hopper Lid, Painted 1 10 89899 Br ass Knob 2 11 ...

  • United States Stove 6037 - page 23

    USSC 23 Notes ...

  • United States Stove 6037 - page 24

    24 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPEND- ABLE SERVICE FROM YOUR AMERICAN HARVEST, AND EN- ABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFER- ENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE ...

メーカー United States Stove カテゴリー Cooktop

United States Stove 6037のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 6037の取扱説明書
- United States Stoveの製品カード
- パンフレット
- またはUnited States Stove 6037の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、United States Stove 6037の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、United States Stove 6037の取り付け説明書、サービスマニュアル、簡易説明書、またはUnited States Stove 6037のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、United States Stove 6037の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

United States Stove 6037デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがUnited States Stove 6037を使用するのを助ける技術的文書のことです。説明書は通常、全てのUnited States Stove 6037ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

United States Stoveの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. United States Stove 6037の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははUnited States Stove 6037の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。United States Stove 6037に関してこのドキュメントで見つけることができる全てのヒントの目次
3. United States Stove 6037デバイスの基本機能を使うにあたってのヒント。 United States Stove 6037のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。United States Stove 6037に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるUnited States Stove 6037のメーカー/サービスへの連絡先に関する情報。

United States Stove 6037についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもUnited States Stove 6037の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがUnited States Stove 6037で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)