Garland EM-C180の取扱説明書

28ページ 3.52 mb
ダウンロード

ページに移動 of 28

Summary
  • Garland EM-C180 - page 1

    FORM # EM-C180 (02/05) SER VICE MANUAL SUPPLEMENT for Model EM-C180 Micr owave Oven C A U T I O N W A R NI N G T O S ER VI C E TE C H N I C I A NS PRECA UTIONS T O BE OBSER VED BEFORE AND DURING S ER VICING T O A V OID POSSIBL E EXPOSUR E T O EXCESSIVE MICR O W A VE ENERGY (a) Do not operate or allow the oven to be operated with the door open. (b) ...

  • Garland EM-C180 - page 2

    CA UTION For microwave energy emission On every service call. A check for micro- wave energy emission must be made according to the f ollo wing manner . Measurement of energy emission Measurement must be made with the microwave oven operating at its maximum output and containing a load of 275 ± 15 milliliters of tap water initially at 20 °± 5 ° ...

  • Garland EM-C180 - page 3

    - 3 - - T ABLE OF CONTENTS - Adjustment Procedures ............................................. 1 Specifications ............................................................ 2 P ower output Measurement ...................................... 2 Precautions and Repair Ser vice Tips ....................... 2 Circuit Diagram ........................... ...

  • Garland EM-C180 - page 4

    - 2 - 2.SPECIFICA TIONS Microwave output ................ 1,800W to 180W F requency ........................... 2,450MHz P ow er supply ....................... 208V , 60Hz Rated current ...................... 13 Amp . Saf ety Device ...................... Ther mal protector(Magnetron) 150°C(270°F)Open (Thermostat) 80°C(144°F)Close Ther mistor ( ...

  • Garland EM-C180 - page 5

    ...

  • Garland EM-C180 - page 6

    - 6 - 6. TEST PROCEDURES AND TR OUBLESHOOTING CA UTION -DISCONNECT THE PO WER SUPPL Y CORD FROM THE W ALL OUTLET WHENEVER REMOVING THE CABINET FROM THE UNIT . PROCEED WITH TESTS ONL Y AFTER DISCHARGING THE HIGH V OL T A GE CAP ACIT ORS AND REMO VING THE LEAD WIRES ON THE PRIMAR Y WINDING OF THE HIGH V OL T A GE TRANSFORM- ERS FOR LO WER AND UPPER M ...

  • Garland EM-C180 - page 7

    - 7 - Measure the resistance: Across two terminals with an ohm-meter on highest scale. COMPONENT HIGH-V OL T A GE CAP A CIT OR Including internal bleeder resistor HIGH-V OL T A GE DIODE Measure the resistance: Across two terminals with an ohm-meter on highest scale. CHECKOUT PR OCEDURE RESUL T Normal reading: Momentarily indicates several ohms, and ...

  • Garland EM-C180 - page 8

    - 8 - Measure the resistance between terminals of FPC connector after removing it from S101.(Figure 10) NO TE - When reconnecting the FPC connector , make sure the holes on the connector are properly inser ted in hook of the plastic fastener in S101. MA TRIX CIRCUIT FOR T OUCH KEY BO ARD FPC CONNECT OR COMPONENT T OUCH KEY BO ARD CHECK OUT PR OCEDU ...

  • Garland EM-C180 - page 9

    - 9 - Check voltage at S104 and S105 after remov- ing each connector (f emale) from pow er circuit board. Pin No .3 (Ground) and 4,5, 1,2 at S105. Pin No .1 and 2 at S104. CA UTION: F or your saf ety , proceed with the test only after removing the wire leads from the pri- mar y winding of high voltage transf or mer. T est procedures: a) Make sure t ...

  • Garland EM-C180 - page 10

    - 10 - P ower with normal voltage is applied. Place a cup of water inside microwave oven Shor ted Replace B. TR OUBLESHOO TING CONDITION TR OUBLE CHECK RESUL T REMED Y * “TIME”, ”1”, ”0” , ”0” and “ST ART” keys are touched Fuse(10A) blows off immediately Step down T ransformer No displa y cooking time H.V Capacitor Connection of ...

  • Garland EM-C180 - page 11

    - 9 - Thermistor (on duct) sensies a temperature of 120 ° C or higher . Displa y E-21 E-31 Thermistor (on Magnetron) or thermistor (on Duct) is shor ted. T rouble Other Symptom Solution Check and remove the cause of the cav- ity fire or abnormal overheating. This error function will be cancelled when the power cord is unplugged. Check f or short-c ...

  • Garland EM-C180 - page 12

    - 12 - 0 1000 2000 3000 4000 5000 6000 7000 8000 0 1 02 03 0 4 05 06 0 Temper atur e   Resistance K¶ “HINT” PROCEDURE FOR DETERMING WHETHER THE UPPER MAGNETR ON CIRCUIT OR LO WER MA GNETR ON CIRCUIT IS DEFECTIVE. SYMPT OM:One magnetron does not work giving less than nor mal heat. Caution: Make sure that cabinet (outer wr ap) and rear ...

  • Garland EM-C180 - page 13

    - 13 - 7. DISASSEMBL Y INSTR UCTIONS - THE O VEN MUST BE DISCONNECTED FROM THE ELECTRICAL OUTLET WHEN MAKING REPLACE- MENTS, REP AIRS, ADJUSTMENT OR CONTINUITY CHECKS. BEFORE PROCEEDING WITH ANY RE- P AIR, WORK , W AIT A T LEAST 1 MINUTE, UNTIL THE CAP A CIT OR IN THE HIGH V OL T A GE AREA HAS FULL Y DISCHARGED. A. REMO VING INTERLOCK SWITCH (See F ...

  • Garland EM-C180 - page 14

    - 14 - F . CHANGING PO WER SUPPL Y CORD (See e xploded view on page 15) (1) Unf asten 1 screw f or ground and pull out the 2 wires of the power cord from the terminal plate. (2) Remov e 1 scre w f or the bottom brac ket of the cord bushing. (3) Install the new power supply cord with the re verse procedure of abo v e (1) to (2). W ARNING: F or chang ...

  • Garland EM-C180 - page 15

    - 15 - K. ADDITIONAL FUNCTIONS The following functions can be completed by the k ey oper ation described below . The Accumulative cooking time and the number of door opening /closings can be observed. The T ype and lev el of the buzz er sound can be selected. The “display of remaining cooking time when cooking is temporarily stopped due to door o ...

  • Garland EM-C180 - page 16

    - 16 - Maintenance: The microwa ve o v ens are designed, manuf actured, and tested f or years of dependab le operation. Howe ver , the ov en ma y require ser vice from time to time if the consumable components listed below are not replaced at the appropriate time. F or protection from unexpected ser vice calls and undue inconvenience, we recommend ...

  • Garland EM-C180 - page 17

    - 17 - 8. EXPLODED VIEW AND P AR TS LIST Main body P arts-1 NO TE: All component ha ve special characteristics f or saf ety and must be replaced using par ts listed in this manual. All ser vice on M/W ovens should be perf or med by a qualified technician using approv ed testing equipment. Customers should not attempt replace component marked with a ...

  • Garland EM-C180 - page 18

    - 18 - NO TE: All component hav e special characteristics f or safety and m ust be replaced using par ts listed in this manual. All service on M/W ovens should be perf ormed by a qualified technician using appro ved testing equipment. Customers should not attempt replace component marked with a symbol. ...

  • Garland EM-C180 - page 19

    ...

  • Garland EM-C180 - page 20

    - 20 - Main body P arts-2 NO TE: All component have special char acteristics f or saf ety and must be replaced usnig par ts listed in this manual. All ser vice on M/W ov ens should be perf ormed by a qualified technician using approv ed testing equipment. Customers should not attempt replace component marked with a symbol. ...

  • Garland EM-C180 - page 21

    - 21 - NO TE: All component hav e special characteristics for saf ety and must be replaced using par ts listed in this manual. All service on M/W ovens should be perf ormed b y a qualified technician using approv ed testing equipment. Customers should not attempt replace component marked with a symbol. ...

  • Garland EM-C180 - page 22

    ...

  • Garland EM-C180 - page 23

    ...

  • Garland EM-C180 - page 24

    ...

  • Garland EM-C180 - page 25

    ...

  • Garland EM-C180 - page 26

    ...

  • Garland EM-C180 - page 27

    ...

  • Garland EM-C180 - page 28

    - 2 8 - Prin ted in J AP AN Wiri ng of Hig h v ol tage Cir cu it Brow n(C Insid e) Wiri ng of Swit ches Mon ito r swi tch Int erloc k s wit ch Doo r se nsin g s wi tch Ora ng e(C ) Br own Wh ite Y ell o w Purple Purple Blue (NC Insid e) Light Bl ue Or an ge Wh ite Pink (NO Insid e) (N O) (N C) Wh ite  ? ...

メーカー Garland カテゴリー Microwave Oven

Garland EM-C180のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- EM-C180の取扱説明書
- Garlandの製品カード
- パンフレット
- またはGarland EM-C180の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Garland EM-C180の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Garland EM-C180の取り付け説明書、サービスマニュアル、簡易説明書、またはGarland EM-C180のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Garland EM-C180の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Garland EM-C180デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがGarland EM-C180を使用するのを助ける技術的文書のことです。説明書は通常、全てのGarland EM-C180ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Garlandの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Garland EM-C180の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははGarland EM-C180の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Garland EM-C180に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Garland EM-C180デバイスの基本機能を使うにあたってのヒント。 Garland EM-C180のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Garland EM-C180に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるGarland EM-C180のメーカー/サービスへの連絡先に関する情報。

Garland EM-C180についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもGarland EM-C180の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがGarland EM-C180で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)