Graco 254973の取扱説明書

20ページ 1.42 mb
ダウンロード

ページに移動 of 20

Summary
  • Graco 254973 - page 1

    For W ater- Based Materials Only Model: 254973 50 psi (0.3 5 MP a, 3 .5 bar) Ma ximum Fluid Working Pre ssure 100 psi (0.7 MP a, 7.0 bar) Maxim um Air Pressure Related Manuals Important Safety Instructions Read all warnings and instruction s in this manual. Sav e these instruction s. 311777 311767 Model 254973 Sho wn ti8370a 311771E Repair Interior ...

  • Graco 254973 - page 2

    Warnings 2 311771E Wa r n i n g s The f ollowing are gene ral warnings related to the setup , use , grounding, maintenance an d repair of this equipment. Additional, mo re specific warnings may be f ound through out the body of this manual wher e applicable. Symbols appearing in the body of the man ual ref er to these general war nings . When these ...

  • Graco 254973 - page 3

    Warnings 311771E 3 Electric Shock Hazar d T o reduce the risk of electric shock: • Be sure spra y er is adequately grounded thr ough electrical outlet, page 6. • Use only 3-wire, e xtension cords. • Mak e sure ground prongs are int act on spra yer and e xtension cords . • Do not oper ate with cov er remo ved. • T urn off spray er . Follo ...

  • Graco 254973 - page 4

    Warnings 4 311771E CA UTION W ater or mater ial rema ining in unit w hen tempe ratures are below free zing can da mage motor and/o r dela y pump star tup . T o insure water and material are completely dr ained out of unit: 1. Remov e material line from spra y er . 2. Tip spray er u p as shown. Bef ore adding material or star ting unit in cold weath ...

  • Graco 254973 - page 5

    Component Identification 311771E 5 Component Identification M A K E B P J D C H G ti8369a F L N Model 2549 73 Shown 3.5 cfm@40 min . Q R Item Component Item Compone nt A Pump Hose Outle t J Bur p Guard B RotoFlex™ II Pump (inside) K ON/OFF Switch C T exture Spra y Gun (Manual 3117 77) L P ower Cord (120V , 15 ft) D N ozzle (2 included) M Material ...

  • Graco 254973 - page 6

    Component Ide ntification 6 311771E Pressure Relief Pr ocedure T o reduce risk of injur y , follo w this procedure whene ver you see this symbol through out this manual, Also , perfo r m this procedure whene v er you: • Stop spraying • Chec k or repair any par t of this system • Install or c lean spray nozzle 1. T urn P ower Swit ch OFF . 2. ...

  • Graco 254973 - page 7

    Shroud Removal 311771E 7 Shr oud Remo val Disassembl y 1. Relie ve Pressure , page 6. 2. Unplug spra y er from outlet. 3. Remove two screws (15) and two screws (64) fr om back of shroud (7) . 4. Pull shroud (7) ba ck and up ov er knob (41) . Reassembl y 1. Slide shro ud (7) ont o base (2). 2. Tighten two bo ttom screws (15) an d two top screws (64 ...

  • Graco 254973 - page 8

    RotoFlex ™ II Pump 8 311771E RotoFlex ™ II Pump Disassembl y 1. Relie ve Pressure , page 6. 2. Unplug spra y er from outlet. 3. Remove Shroud , page 7. 4. Loosen tw o spacers (56) and knob (41). 5. Loosen hopper fit ting by hand to re mov e hopper (1). 6. Use 3/8 in. soc ket to remo ve scre w (36) from hose brac ket (2 7). 7. Slide hose fittin ...

  • Graco 254973 - page 9

    RotoFlex ™ II Pump 311771E 9 Reassembl y 1. Bend hose (23 ) so colored dots on hose f ittings f ace each other and slid e hose fittings through hose brac ket ( 27). 2. Squeez e hose ends together to k eep hose (23) and brac ket ( 27) together and f eed pump hose fitting s through holes on front of base . 3. Use 3/8 in. soc ket to tighten scre w ( ...

  • Graco 254973 - page 10

    Motor 10 311771E Motor Disassembl y 1. Relie ve Pressure , page 6. 2. Unplug spra y er from outlet. 3. Remove Shr oud , page 7. 4. loosen knob (41) until spring relax es. 5. Remove Pump , page 8. 6. Disconnect all electrical Wiring , page 1 6. 7. Use 1/4 in. soc ket to remov e grou nding screw (22) . 8. Disconnect e xtension cab le (29) from pulle ...

  • Graco 254973 - page 11

    Motor 311771E 11 Reassembl y 1. Tighte n Belt , page 13. 2. Use petroleum jelly to g rease area of shaft tha t makes contact with e xtension cable ( 29). 3. Slide pin on motor tr ay (32) into slots on base and push moto r and tray bac k int o position. 4. Replace two cle vis pins (20) in base (2). 5. Reconnec t all electr ical wir ing including gro ...

  • Graco 254973 - page 12

    Motor Fuse Removal 12 311771E Motor Fuse Remo v al When replac ing fuse, use only Bussm an GMF-3 ( 3A) to pre vent premature trips or equipment damage . The motor has a re placeable fuse at tached to the motor brack et. The fuse as sembly (A) is f astened to th e motor brac ket along with a clamp . T o remov e the motor fuse , press down on the rou ...

  • Graco 254973 - page 13

    Belt 311771E 13 Belt Disassembl y 1. Relie ve Pressure, page 6. 2. Unplug spra y er from outlet. 3. Remove Shr oud , page 7. 4. Remove Motor , page 10. 5. Place motor tra y (32) into vice an d tighten until snug. 6. Use 9/16 in. wrench to loosen two mounting scre ws (4) on motor tray (32) to allow motor to slide around . 7. Remov e old belt and dis ...

  • Graco 254973 - page 14

    Troubleshooti ng 14 311771E T r oub leshooting Prob lem Cause Solution Spra yer won’t r un P ower s witch not on T u r n switch on. No power at w all outlet Check outl et by seeing if light in the plug is illuminated. If not, tr y another outlet. Wrong size ge nerator Use a 3500 wa tt or larger generator . Ref er to Generato r Requirements, page ...

  • Graco 254973 - page 15

    Troubleshooting 311771E 15 Speed of application too slo w New pum p hose not broken in properly Run pump dry for no longer than 2 minutes. Material too thic k Thin material. Nozzle too small Change nozzles to a larger size . See Operat ion Manual, Recommend ed Nozzle Selection Char t, page 10. Plugged or dirty gun Relie ve Pressure , page 6. Clean ...

  • Graco 254973 - page 16

    Wiring Diagram 16 311771E Wiring Diagram ti9199a 25 10 39 ON/OFF Switch Black Wi re Black Wire P ower Cord 31 8 Chassis Ground White Wire White Wire Green Wire Green Wire Motor Red Wire ...

  • Graco 254973 - page 17

    Parts 311771E 17 Pa r t s Models 254973 42 ti9654a 12 1 3 6 14 5 2 7 15 8 10 31 24 33 23 19 29 20 43 20 4 2 36 21 16 32 ti9655b 27 17 11 44 22 46 • 47 13 • 18 25 41 37 • • • 55 39 42 56 63 37 9 9 64 64 65 28 38 30 26 ...

  • Graco 254973 - page 18

    Parts 18 311771E Pa r t s Models 254973 ▲ Labels are not included wit h compone nts. They must be ordered separately . † Additional w ar ning labels are av ailabl e at no cost. Ref. P art Description Qty . 1 15K225 HOPPER, 5 gallon 1 2 15J181 BASE 1 3 15K227 FRAME, tubular , painted, s ilver 1 4 117791 SCREW , cap , tr i lobe 2 5 120783 SCREW , ...

  • Graco 254973 - page 19

    Technical Data 311771E 19 Te c h n i c a l D a t a Main Unit P ower Requir ements . . . . . . . . . . . . . . . . . . . . 120 V ac, 60 Hz, 15A, 1 phase Maximum Fluid Working Pre ssure . . . . . . . . . . . . . . . . . . 50 psi, (3.5 bar) Maximum Air Working P ressure . . . . . . . . . . . . . . . . . . . . 100 psi (7.0 bar) Compressor Specification ...

  • Graco 254973 - page 20

    Graco Standard Warranty 20 311771E Graco Standar d W arranty Graco warrants all equipment ref erence d in this document which is manufactured b y Graco and bear ing its name to be free from de fe c t s i n material and workmanship on the date of sale the original purchaser for us e. With the e xception o f any special, e xtended, or li mited warran ...

メーカー Graco カテゴリー Paint Sprayer

Graco 254973のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 254973の取扱説明書
- Gracoの製品カード
- パンフレット
- またはGraco 254973の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Graco 254973の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Graco 254973の取り付け説明書、サービスマニュアル、簡易説明書、またはGraco 254973のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Graco 254973の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Graco 254973デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがGraco 254973を使用するのを助ける技術的文書のことです。説明書は通常、全てのGraco 254973ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Gracoの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Graco 254973の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははGraco 254973の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Graco 254973に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Graco 254973デバイスの基本機能を使うにあたってのヒント。 Graco 254973のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Graco 254973に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるGraco 254973のメーカー/サービスへの連絡先に関する情報。

Graco 254973についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもGraco 254973の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがGraco 254973で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)