Wagner SprayTech FLEXiO 570の取扱説明書

21ページ 関係なし
ダウンロード

ページに移動 of 21

Summary
  • Wagner SprayTech FLEXiO 570 - page 1

    English Fr ançais Español 0113 • Form No. 0529835B Owner’s Manual Read this manual for complete instructions Français (page 17) / Español (página 33) Contents 2 Important Safety Information 4 Controls and Functions 6 Material Preparation 7 Assembly 8 Air and Material Controls 9 Spray Pattern Adjustment 10 Proper Spraying Technique 12 Clean ...

  • Wagner SprayTech FLEXiO 570 - page 2

    English 2 © Wagner Spray Tech - All Rights Reserved Important Safety Information Read all safety information before operating the equipment. Save these instructions. Indicates a hazardous situation which, if not avoided, could result in death or serious injury. To reduce the risks of re or explosion, electrical shock and the injury to persons, ...

  • Wagner SprayTech FLEXiO 570 - page 3

    English © Wagner Spray Tech - All Rights Reserved 3 Important Safety Information WARNING - To reduce the risk of injury: 1. Always wear appropriate gloves, eye protection, clothing and a respirator or mask when painting. Hazardous vapors – Paints, solvents, insecticides, and other materials can be harmful if inhaled or come in contact with body. ...

  • Wagner SprayTech FLEXiO 570 - page 4

    English 4 © Wagner Spray Tech - All Rights Reserved Controls and Functions - Model 570 iSpray® Nozzle X-Boost™ T urbine 2-stage Tr igger Spray width lever (for large projects) Ad justment ring 1.5 qt cup X- Boost™ po wer dial (2-speed) Ma terial ow contro l Filter housin g (both sides) Filter Filter X-Boost™ Power Dial: The X-Boost power ...

  • Wagner SprayTech FLEXiO 570 - page 5

    English © Wagner Spray Tech. - All Rights Reserved 5 Controls and Functions - Model 590 Detail Finish Nozzle™ X-Boost™ T urbine Filter housin g (both sides) Filter Filter iSpray® Nozzle 2- stage Tr igger *Spray width lever *A djustment ring 1.5 qt cup X- Boost™ po wer dial (variable speed) (for larger jobs) F unnel (2) Ma terial ow contr ...

  • Wagner SprayTech FLEXiO 570 - page 6

    English 6 © Wagner Spray Tech. - All Rights Reserved Material Preparation Note: Material to be sprayed may need to be strained to remove any impurities in the paint which may enter and clog the system. Impurities in the paint will give poor performance and a poor finish. Note: Only thin the material if absolutely necessary to improve spray perform ...

  • Wagner SprayTech FLEXiO 570 - page 7

    English © Wagner Spray Tech - All Rights Reserved 7 Assembly Before you begin: NEVER point the spray gun at any part of the body. To Assemble: IMPORTANT: Make sure the power cord is unplugged. 1. Insert the suction tube into the intake opening. 2. Align the suction tube - a. If you are going to be spraying in a downward direction, the angled end o ...

  • Wagner SprayTech FLEXiO 570 - page 8

    English 8 © Wagner Spray Tech - All Rights Reserved Air and Material Controls Spray performance will depend upon a number of factors: material thickness, spray pattern selected, and material ow. Testing dierent variations of the control settings will help you achieve the desired results. See descriptions and suggested Air and Material Settin ...

  • Wagner SprayTech FLEXiO 570 - page 9

    English © Wagner Spray Tech - All Rights Reserved 9 Spray Pattern Adjustment Adjust Spray Shape - both nozzles The spray pattern shape is adjusted by turning the adjustment ring (iSpray) or air cap ears (Detail Finish) to either the vertical, horizontal, or diagonal positions. The positions of the air cap and the corresponding spray pattern shapes ...

  • Wagner SprayTech FLEXiO 570 - page 10

    English 10 © Wagner Spray Tech - All Rights Reserved Proper Spraying Technique STOP The room you are spraying must be properly masked in order to prevent overspray from covering woodwork, oors or furnishings. Make sure you have properly masked the room per the instructions on the enclosed “Taping Guide”. If spraying with an air-assisted spr ...

  • Wagner SprayTech FLEXiO 570 - page 11

    English © Wagner Spray Tech - All Rights Reserved 11 Proper Spraying Technique Pattern Examples Use the images and guidelines below in order to assist you in achieving the desired spray pattern for your project. These are meant to be general starting points - you may have to slightly modify certain controls on the system in order to get the exact ...

  • Wagner SprayTech FLEXiO 570 - page 12

    English 12 © Wagner Spray Tech - All Rights Reserved Cleanup Flushing the unit Before you begin: When cleaning, use the appropriate cleaning solution (warm, soapy water for latex materials; mineral spirits for oil-based materials) IMPORTANT: Never clean air cap or air holes in the nozzle with sharp metal objects. Do not use solvents or lubricants ...

  • Wagner SprayTech FLEXiO 570 - page 13

    English © Wagner Spray Tech - All Rights Reserved 13 Cleanup (continued) Cleaning the Nozzle To Clean the Nozzle: 1. Make sure power cord is unplugged. Push the tab below the trigger, twist and separate the nozzle from the turbine. Wipe the exterior of the cup and nozzle until clean. 2. iSpray nozzle only - a. Remove the adjustment ring (a) carefu ...

  • Wagner SprayTech FLEXiO 570 - page 14

    English 14 © Wagner Spray Tech - All Rights Reserved Reassembly To Reassemble: 1. Install the nozzle seal* with the groove (a) (slot) facing toward the nozzle (away from the front end assembly). Insert the nozzle. Make sure to align the groove (b) and notch (c) and align the nozzle opening with the needle. 2. Put the air screen (d) in the air cap ...

  • Wagner SprayTech FLEXiO 570 - page 15

    English © Wagner Spray Tech. - All Rights Reserved 15 Maintenance Cleaning the Filters: IMPORTANT: Before every use, you should inspect the air lters in the turbine to see if it is excessively dirty. If it is dirty, follow these steps to replace it. IMPORTANT: Never operate your unit without the air lters. Dirt could be sucked in and interfe ...

  • Wagner SprayTech FLEXiO 570 - page 16

    English 16 © Wagner Spray Tech. - All Rights Reserved Troubleshooting PROBLEM CAUSE SOLUTION Problem A: Little or no material ow 1. Nozzle clogged. 2. Suction tube clogged. 3. Material ow setting too low. 4. Suction tube loose. 5. Air vent on suction tube blocked. 6. No pressure build up in container. 7. Air valve tube disconnected. 8. Air ? ...

  • Wagner SprayTech FLEXiO 570 - page 17

    English © Wagner Spray Tech. - All Rights Reserved 49 Parts List • Liste de pièces • Lista de piezas English Fr ançais Español 1 2 X-Boost™ Turbine • Turbine de X-Boost™ • Turbina de X-Boost™ # Part No. Nº de piéce Pieza No. English Description Français Description Español Descripción Qty. Qte. Cant. 1 --------- X-Boost Turbi ...

  • Wagner SprayTech FLEXiO 570 - page 18

    Español Français English 50 © Wagner Spray Tech - All Rights Reserved Parts List • Liste de pièces • Lista de piezas 1 8 2 3 4 6 7 5 # Part No. Nº de piéce Pieza No. English Description Français Description Español Descripción Qty. Qte. Cant. 1 0529014 Spray gun assembly (includes items 1-8) Ensemble de pistolet (inclut des pièces 1 ? ...

  • Wagner SprayTech FLEXiO 570 - page 19

    English Fr ançais Español © Wagner Spray Tech - All Rights Reserved 51 Parts List • Liste de pièces • Lista de piezas 1 2 3 4 5 10 11 9 7 8 # Part No. Nº de piéce Pieza No. English Description Français Description Español Descripción Qty. Qte. Cant. 1 0529013 Detail Finish Nozzle assembly (includes items 1-8) Ensemble de buse de Detail ...

  • Wagner SprayTech FLEXiO 570 - page 20

    Español Français English 52 © Wagner Spray Tech - All Rights Reserved Accessories • Accessoires • Accesorios Part No. Nº de piéce Pieza No. English Description Français Description Español Descripción 0529014 iSpray nozzle assembly Ensemble de buse de iSpray Ensamblaje del boquilla de iSpray 0529013 Detail Finish Nozzle™ assembly Ense ...

  • Wagner SprayTech FLEXiO 570 - page 21

    English 56 © Wagner Spray Tech. - All Rights Reserved Limited Warranty HVLP paint spray equipment This product, manufactured by Wagner Spray Tech Corporation (Wagner), is warranted against defects in material and work-manship for one year following date of purchase if operated in accordance with Wagner’s printed recommendations and instructions. ...

メーカー Wagner SprayTech カテゴリー Paint Sprayer

Wagner SprayTech FLEXiO 570のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- FLEXiO 570の取扱説明書
- Wagner SprayTechの製品カード
- パンフレット
- またはWagner SprayTech FLEXiO 570の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Wagner SprayTech FLEXiO 570の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Wagner SprayTech FLEXiO 570の取り付け説明書、サービスマニュアル、簡易説明書、またはWagner SprayTech FLEXiO 570のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Wagner SprayTech FLEXiO 570の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Wagner SprayTech FLEXiO 570デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWagner SprayTech FLEXiO 570を使用するのを助ける技術的文書のことです。説明書は通常、全てのWagner SprayTech FLEXiO 570ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Wagner SprayTechの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Wagner SprayTech FLEXiO 570の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWagner SprayTech FLEXiO 570の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Wagner SprayTech FLEXiO 570に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Wagner SprayTech FLEXiO 570デバイスの基本機能を使うにあたってのヒント。 Wagner SprayTech FLEXiO 570のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Wagner SprayTech FLEXiO 570に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWagner SprayTech FLEXiO 570のメーカー/サービスへの連絡先に関する情報。

Wagner SprayTech FLEXiO 570についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWagner SprayTech FLEXiO 570の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWagner SprayTech FLEXiO 570で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)