日本語 dropdown-ico

Hearth and Home Technologies E42の取扱説明書

32ページ 1.27 mb
ダウンロード

ページに移動 of 32

Summary
  • Hearth and Home Technologies E42 - page 1

    08/04 17335 Rev L 1 WARNING! Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual. For assist ance or additional information, consult a qualified installer , service agency or the gas supplier . INST ALLA TION & OPERA TING INSTRUCTIONS E36 E39 E42 WOODBURNING FIREPLACE N ...

  • Hearth and Home Technologies E42 - page 2

    2 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS CAUTION: Do not expose the fireplace to the elements (i.e. rain, etc.) and keep the fireplace dry at all times. Wet insulation will produce an odor when the fireplace is used. T able of Content s Design and Installation Considerations ......................................................... ...

  • Hearth and Home Technologies E42 - page 3

    08/04 17335 Rev L 3 E36/39/42 INST ALLA TION INSTRUCTIONS DESIGN AND INST ALLA TION CONSIDERA TIONS When selecting a location for your woodburning fireplace, it is important to evaluate a number of considerations. Modern construction techniques can create conditions that may not allow your chimney to draft properly . This may result in smoke spilla ...

  • Hearth and Home Technologies E42 - page 4

    4 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS W ARNING! This fireplace and its component s are designed to be installed and operated as a system. Any alteration to or substitution for items in this system, unless allowed by these installation instructions, will void the Underwrit- ers Laboratories listing and may void the product warran ...

  • Hearth and Home Technologies E42 - page 5

    08/04 17335 Rev L 5 E36/39/42 INST ALLA TION INSTRUCTIONS C. SYSTEM COMPONENTS 1. Fireplace Component s GR4 GR5 GR6 INTEGRAL GRA TE (Supplied) GLASS DOORS HEARTH EXTENSION A B DP1036 DP1036B DP1036S DP1042 DP1042B DP1042S Perception Glass Doors DM1036 DM1036B DM1036S DM1039 DM1039B DM1039S DM1042 DM1042B DM1042S Bifold Glass Doors DMA1036B DMA1042B ...

  • Hearth and Home Technologies E42 - page 6

    6 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS OUTSIDE AIR KIT AK14 Fireplace Dimensions Cat # A B C D E/EC36 36 in. 914 m m 41 i n . 1041 mm 25-1/4 in . 641 mm 12- 5/ 8 in . 321 m m E/EC39 39 in 991 m m 44 i n . 111 8 m m 28-1/4 in . 718 m m 14- 1/ 8 in . 359 m m E/EC42 42 in. 1067 m m 47 i n . 11 9 4 m m 31-1/4 in . 794 m m 15- 5/ 8 in ...

  • Hearth and Home Technologies E42 - page 7

    08/04 17335 Rev L 7 E36/39/42 INST ALLA TION INSTRUCTIONS 2. Chimney Component s The following pictures show only those chimney components which may be safely used with this fireplace. Catal og # Descri pt i on: CAK4 A Ch im n ey Air Kit ID 4 Ins u l a t e d D u c t / O u t s i d e A i r U D4 U n in su l at e d Du ct / Ou t s id e Air SL3 06 Ch im ...

  • Hearth and Home Technologies E42 - page 8

    8 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS SL3 - Chimney Stabilizer SL330 - Offset/Return RF370 - Roof Flashing Flat to 6/12 Pitch RF371 - Roof Flashing 6/12 to 12/12 Pitch CB876 Chimney Bracket AS8 Straight Attic Insulation Shield Chimney Sections Firestop Sp acer JB877 Joint Band Ca t a log # A B SL 306 6 in. 4-3/4 i n. SL312 12 i ...

  • Hearth and Home Technologies E42 - page 9

    08/04 17335 Rev L 9 E36/39/42 INST ALLA TION INSTRUCTIONS LDS33 (3 ft x 3 ft) LDS46 (4 ft x 6 ft) Decorative Shroud TR344 Round T ermination Cap TR342 Round T elescoping T ermination Cap CT35 Chase T op CAK4A Chimney Air Kit TS345/TS345P Square T ermination Cap ST375 Square T ermination Cap ...

  • Hearth and Home Technologies E42 - page 10

    10 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 3 Installation Along a Wall or an Exterior Chase Figure 4 Corner Inst allation W ARNING! Do not draw out side air from garage spaces. Exhaust product s of gasoline engines are hazardous. Do not install out side air ducts such that the air may be drawn from attic sp aces, basement s o ...

  • Hearth and Home Technologies E42 - page 11

    08/04 17335 Rev L 11 E36/39/42 INST ALLA TION INSTRUCTIONS W ARNING! Do not apply combustible finishing materials over any part of the black face of this fireplace or a structure fire may result. The black metal fireplace front may only be covered with noncombustible materials such as ce- ramic tile, brick, or stone. Do not cover or block any cooli ...

  • Hearth and Home Technologies E42 - page 12

    12 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 6 - Sidewalls and Surrounds E. CHIMNEY REQUIREMENTS When planning your fireplace location, the chimney construction and necessary clearances must be considered. The fireplace system and chimney components have been tested to provide flexibility in construction. The following figures ...

  • Hearth and Home Technologies E42 - page 13

    08/04 17335 Rev L 13 E36/39/42 INST ALLA TION INSTRUCTIONS W ARNING! Do not combine offsets to create an offset greater than 30 degrees from verti- cal. This may create a fire hazard since the natural draft may be restricted. a. T o bypass any overhead obstructions, the chimney may be offset using a 15-deg or a 30-deg offset/return. Perform the fol ...

  • Hearth and Home Technologies E42 - page 14

    14 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 8 - Chimney Height T able 2 3. Number of Sections Required T o determine the chimney components needed to complete your particular installation, follow the step s below: a. Determine the total vertical height of the fireplace installation. This dimension is measured from the base of ...

  • Hearth and Home Technologies E42 - page 15

    08/04 17335 Rev L 15 E36/39/42 INST ALLA TION INSTRUCTIONS F . INST ALLA TION OF FIREPLACE W ARNING! Before st arting, do the following: 1. W ear gloves and safety glasses for protection. 2. Keep hand tools in good condition. Sharpen cutting edges and make sure tool handles are secure. 3. Always maint ain the minimum air sp ace required to the encl ...

  • Hearth and Home Technologies E42 - page 16

    16 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 1 1 Installing the Firestop S p acer CAUTION: Firestop spacers must be used whenever the chimney penetrates a ceiling/floor area. Figure 10 Assembling Chimney Sections W ARNING! Carefully follow the instructions for assembly of the pipe and other p arts needed to inst all this firepl ...

  • Hearth and Home Technologies E42 - page 17

    08/04 17335 Rev L 17 E36/39/42 INST ALLA TION INSTRUCTIONS W ARNING! Maintain a minimum of 2 in. air clearance to all parts of the chimney system at all times! Failure to maintain this 2 in. air clearance will cause a structure fire. CAUTION: Inner flue and outer liner sections cannot be disassembled once locked together . Plan ahead to ensure the ...

  • Hearth and Home Technologies E42 - page 18

    18 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 14 - Ceiling/Attic Construction Figure 15 - Air Kit Handle Location 9. Mark the Exit Point of the Roof Locate the point where the chimney will exit the roof by plumbing down to the center of the chimney . Drive a nail up through the roof to mark the center . See Figure 14. 10 . Cut o ...

  • Hearth and Home Technologies E42 - page 19

    08/04 17335 Rev L 19 E36/39/42 INST ALLA TION INSTRUCTIONS Note: Use only a noncombustible material to finish the face of the fireplace below the level of the front standof fs. A noncombustible material such as USG MICORE CV230 Mineral Fiber Board, or USG DUROCK Cement Board is recommended for this purpose. Figure 16 - Air Clearance Around Gas Line ...

  • Hearth and Home Technologies E42 - page 20

    20 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 17 - Factory Built Hearth Extension Figure 18 - Field Constructed Hearth Extension W ARNING! Hearth extensions are to be installed only as illustrated to prevent high temperatures from occurring on concealed combustible materials. Hearth sealing strip s prevent burning or hot particl ...

  • Hearth and Home Technologies E42 - page 21

    08/04 17335 Rev L 21 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 19 - Position the Hearth Extension 18. Position the Hearth Extension Position and secure the hearth extension over the protective metal strips that have been placed p artially under the fireplace front. These strip s should be protruding approximately 2 in. from under the fireplace f ...

  • Hearth and Home Technologies E42 - page 22

    22 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS G . CONSTRUCTING A CHASE Figure 20 - Chase Constructions Figure 21 - Chase Assembly 1. Materials a. The chase is constructed using framing materials much the same as the walls in your home. A variety of materials may be used including brick, stone, veneer brick, or standard siding materials ...

  • Hearth and Home Technologies E42 - page 23

    08/04 17335 Rev L 23 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 22 - Installing a TR344 Round T ermination Cap Figure 23 - Inst alling a TR342 Round T elescoping T ermination Cap 2. Chase T op Construct a chase of desired materials maint aining a minimum 2 in. air space around the chimney . 3. T ermination Cap a. Install the chimney sections up t ...

  • Hearth and Home Technologies E42 - page 24

    24 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS W ARNING! Never inst all a single wall slip section or smoke-pipe in a chase structure. The higher temperature of this single wall pipe may radiate sufficient heat to combustible chase materials to cause a fire. W ARNING! Det ailed instructions for inst allation of the chase top, storm coll ...

  • Hearth and Home Technologies E42 - page 25

    08/04 17335 Rev L 25 E36/39/42 INST ALLA TION INSTRUCTIONS Note: Save and pass this instruction manual to subsequent home owners. The information provided is intended to notify and warn them about making unsafe future modifications such as the addition of shelves or the use of unauthorized part s and repairs. W ARNING! DO NOT operate this fireplace ...

  • Hearth and Home Technologies E42 - page 26

    26 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 26 Proper Operating Positions of Bi-Fold Doors W ARNING! Burning wet, unseasoned wood can cause ex- cessive creosote accumulation. When ignited it can cause a chimney fire that may result in a serious house fire. CAUTION: When left closed while burning your fireplace, firescreens and ...

  • Hearth and Home Technologies E42 - page 27

    08/04 17335 Rev L 27 E36/39/42 INST ALLA TION INSTRUCTIONS CAUTION: Never use gasoline, gasoline-type lantern fuel, kerosene, charcoal lighter fluid, or similar liq- uids to start or “freshen up” a fire in this fire- place. Keep all such liquids well away from the fireplace. Note: When first lighting your fireplace, it may be necessary to pre-w ...

  • Hearth and Home Technologies E42 - page 28

    28 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS Figure 27 - Flue Draf t Flue draft is measured as negative pressure in the chimney . The amount of negative pressure determines how strong the draft is. The draft is important because it draws the combustion air into the fireplace and pulls the smoke out of the chimney . There are three bas ...

  • Hearth and Home Technologies E42 - page 29

    08/04 17335 Rev L 29 E36/39/42 INST ALLA TION INSTRUCTIONS I. MAINTENANCE INSTRUCTIONS W ARNING! A chimney fire can permanently damage your chim- ney system. This damage can only be repaired by replacing the damaged component part s. Chimney fires are not covered by the Limited W arranty and Buyer Protection Plan. Figure 28 - Chimney & T ermina ...

  • Hearth and Home Technologies E42 - page 30

    30 17335 Rev L 07/04 E36/39/42 INST ALLA TION INSTRUCTIONS HOMEOWNER’S NOTES ...

  • Hearth and Home Technologies E42 - page 31

    08/04 17335 Rev L 31 E36/39/42 INST ALLA TION INSTRUCTIONS Index A Air Clearance 17, 19 Air Kit 6, 18 Ashes, Disposal of 29 Attic Insulation Shield 17 B Building Codes 4, 18, 21 C Chase 22 Chase T op 9, 23 Chimney Assembling Sections Through the Roof 18 Checking the Assembly 17 Cleaning 29 Creosote 29 Exit Point Through the Roof 18 Height Requireme ...

  • Hearth and Home Technologies E42 - page 32

    32 17335 Rev L 07/04 HEA TILA T OR WOODBURNING FIREPLACE LIMITED WARRANTY As part of its 20-YEAR BUYER PROTECTION PROGRAM AS P ART OF ITS 20 YEAR BUYER PROTECTION PROGRAM (“PROGRAM”), HEARTH & HOME TECHNOLOGIES INC. (“HHT”) is pleased to offer a Limited W arranty and a Replacement Parts Advantage covering specific components of your Hea ...

メーカー Hearth and Home Technologies カテゴリー Indoor Fireplace

Hearth and Home Technologies E42のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- E42の取扱説明書
- Hearth and Home Technologiesの製品カード
- パンフレット
- またはHearth and Home Technologies E42の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Hearth and Home Technologies E42の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Hearth and Home Technologies E42の取り付け説明書、サービスマニュアル、簡易説明書、またはHearth and Home Technologies E42のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Hearth and Home Technologies E42の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Hearth and Home Technologies E42デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHearth and Home Technologies E42を使用するのを助ける技術的文書のことです。説明書は通常、全てのHearth and Home Technologies E42ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Hearth and Home Technologiesの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Hearth and Home Technologies E42の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHearth and Home Technologies E42の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Hearth and Home Technologies E42に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Hearth and Home Technologies E42デバイスの基本機能を使うにあたってのヒント。 Hearth and Home Technologies E42のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Hearth and Home Technologies E42に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHearth and Home Technologies E42のメーカー/サービスへの連絡先に関する情報。

Hearth and Home Technologies E42についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもHearth and Home Technologies E42の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHearth and Home Technologies E42で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)