Wagner SprayTech 9140の取扱説明書

20ページ 2.27 mb
ダウンロード

ページに移動 of 20

Summary
  • Wagner SprayTech 9140 - page 1

    English Printed in the U. S. A. M ODELS 9140, 9140S, 9150, 9170, 9190 AND 9210 H IGH P ERFORMANCE A IRLESS S PRA YER T ABLE OF C ONTENTS : SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 COMPONENTS AND DESCRIPTION . . . . . . . . . . . . . . . . . . 4 SETUP . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Wagner SprayTech 9140 - page 2

    HAZARD: INJECTION INJUR Y A high pressure paint stream produced by this equipment can pierce the skin and underlying tissues, leading to serious injury and possible amputation. SEE A PHYSICIAN IMMEDIA TEL Y . DO NOT TREA T AN INJECTION INJUR Y AS A SIMPLE CUT! Injection can lead to amputation. See a physician immediately . The maximum operating ran ...

  • Wagner SprayTech 9140 - page 3

    HAZARD: GENERAL Can cause severe injury or property damage. PREVENTION: • Read all instructions and safety precautions before operating equipment. • Follow all appropriate local, state, and national codes governing ventilation, fire prevention, and operation. • The United States Government Safety Standards have been adopted under the Occupati ...

  • Wagner SprayTech 9140 - page 4

    Spray gun Spray tip Spray hose Pail bracket Lubricating area (on front face plate) Hose bracket Handle Motor housing Return tube Suction tube Suction set screen ON/OFF switch O = OFF l = ON PRIME/ SPRA Y knob Fluid section O l SPRA Y PRIME SPRA Y PRIME PRIME/SPRA Y knob PRIME position SPRA Y position Customer Service: 800-880-0993 4 © 2003 W agner ...

  • Wagner SprayTech 9140 - page 5

    © 2003 W agner Spray T ech - All rights reserved. 5 Customer Service: 800-880-0993 English T OOLS N EEDED F OR S ETUP • T wo adjustable wrenches • 3/16” allen wrench • Extension cord (refer to Important Electrical Information (page 3) . Do not plug in the unit until setup is complete. A TT ACHING THE H ANDLE ( CART MODELS ) 1. Position the ...

  • Wagner SprayTech 9140 - page 6

    P LUGGING I N THE S PRA YER 1. Check that the ON/OFF switch is in the OFF position. 2. Plug the sprayer into a heavy duty grounded extension cord. Refer to Important Electrical Information, page 3). P RESSURE R ELIEF P ROCEDURE Be sure to follow the pressure relief procedure (page 6) when shutting the unit off FOR ANY PURPOSE. This procedure is use ...

  • Wagner SprayTech 9140 - page 7

    © 2003 W agner Spray T ech - All rights reserved. 7 Customer Service: 800-880-0993 English P URGING & P RIMING P URGING AND P RIMING THE P UMP 1. Place a full container of paint underneath the suction tube. 2. Secure the return tube into a waste container . 3. T urn the pressure control dial to maximum pressure (+). 4. T urn the PRIME/SPRA Y k ...

  • Wagner SprayTech 9140 - page 8

    P RACTICE Be sure that the paint hose is free of kinks and clear of objects with sharp cutting edges. 1. Switch the pump ON (l) and turn the PRIME/SPRA Y knob to SPRA Y . 2. T urn the pressure contol dial to its highest setting (+). The spray hose should stiffen as paint begins to flow through it. 3. When the motor shuts off, unlock the spray gun a ...

  • Wagner SprayTech 9140 - page 9

    © 2003 W agner Spray T ech - All rights reserved. 9 Customer Service: 800-880-0993 English U NCLOGGING THE S PRA Y T IP Do not attempt to unclog or clean the tip with your finger . Do not use a needle or other sharp pointed instrument to clean the tip. The hard tungsten carbide can chip. If the spray pattern becomes distorted or stops completely w ...

  • Wagner SprayTech 9140 - page 10

    I MPORT ANT C LEANING N OTES ! R EAD T HESE N OTES AND W ARNINGS B EFORE Y OU S T ART T O C LEAN Y OUR S PRA YER ! • When using latex paints, clean your sprayer and components using warm, soapy water . When using oil-based paints, use mineral spirits. • Do not use mineral spirits on latex paint, or the mixture will turn into a jelly-like substa ...

  • Wagner SprayTech 9140 - page 11

    © 2003 W agner Spray T ech - All rights reserved. 11 Customer Service: 800-880-0993 English C LEANUP ( CONTINUED ) 1. Make sure the pump is switched OFF (O), the PRIME/SPRA Y knob is turned to PRIME, and unplug the sprayer . 2. Remove spray gun from the paint hose using adjustable wrenches. 3. Remove filter from spray gun (refer to Cleaning the Sp ...

  • Wagner SprayTech 9140 - page 12

    S HORT -T ERM S T ORAGE ( UP T O 16 HOURS ) S HUTDOWN 1. Lock the spray gun off. 2. T urn the PRIME/SPRA Y knob to PRIME. 3. Switch the pump OFF , and unplug the sprayer . 4. Pour 1/2 cup water slowly on the top of the paint to prevent the paint from drying. 5. Wrap the spray gun assembly in a damp cloth and place it in a plastic bag. Seal the bag ...

  • Wagner SprayTech 9140 - page 13

    © 2003 W agner Spray T ech - All rights reserved. 13 Customer Service: 800-880-0993 English D AIL Y M AINTENANCE The only daily maintenance necessary is thorough cleaning. Follow the cleaning procedures in this manual. E XTENDED M AINTENANCE Some pump parts eventually wear out from use and must be replaced. The following list indicates the availab ...

  • Wagner SprayTech 9140 - page 14

    Customer Service: 800-880-0993 14 © 2003 W agner Spray T ech - All rights reserved. English D ISASSEMBL Y OF THE F LUID S ECTION 1. Remove the suction set. 2. Remove the front cover and the four screws that secure it using a T20 T orx head driver . 3. Remove the yoke screw and washer that secures the dowel pin. The dowel pin connects the yoke to t ...

  • Wagner SprayTech 9140 - page 15

    © 2003 W agner Spray T ech - All rights reserved. 15 Customer Service: 800-880-0993 English T ROUBLESHOOTING P ROBLEM A. The sprayer does not start. B. The sprayer starts but does not draw in paint when the PRIME/SPRA Y knob is set to PRIME. C. The sprayer draws up paint but the pressure drops when the gun is triggered. D. The PRIME/SPRA Y valve i ...

  • Wagner SprayTech 9140 - page 16

    English 48 800-880-0993 © 2003 W agner Spray T ech - All rights reserved. Fran ç ais Espa ñ ol GX-06/07 (9140, 9140S, 9150, 9170) Item Part # Description Quantity 1 0512120 Plastic gun assembly ............................1 0512121 Metal gun assembly ..............................1 2 050101 1 Guard Assembly ...................................1 3 ...

  • Wagner SprayTech 9140 - page 17

    English Fran ç ais © 2003 W agner Spray T ech - All rights reserved. 800-880-0993 49 Espa ñ ol Article N ° de pi è ce Description Quantity 1 Se reporter à la liste d ’ ACCESSOIRES 2 050101 1 Prot è ge-embout ....................................1 3 0296261 Diffuseur , 2,2 cm ...................................1 4 0296270 Ressort de soupape ...

  • Wagner SprayTech 9140 - page 18

    English 50 800-880-0993 © 2003 W agner Spray T ech - All rights reserved. Fran ç ais Espa ñ ol P ARTS LIST • L ISTE DE PI È CES • L IST A DE PIEZAS GX-10 (9210) Item Part # Description Quantity 1 Refer to Accessories, page 13 2 050101 1 Holder assembly ...................................1 3 0296261 Diffuser , 7/8" ..................... ...

  • Wagner SprayTech 9140 - page 19

    English Fran ç ais © 2003 W agner Spray T ech - All rights reserved. 800-880-0993 51 Espa ñ ol 8 0512396 Roue (9140, 9150) . . . . . . . . . . . . . .2 0512397 Roue (9170) . . . . . . . . . . . . . . . . . . .2 0278373 Roue (9190, 9210) . . . . . . . . . . . . . .2 9 0275728 Capuchon (9140, 9150, 9170) . . . . . .2 9890104 Capuchon (9190, 9210) ...

  • Wagner SprayTech 9140 - page 20

    English 52 800-880-0993 © 2003 W agner Spray T ech - All rights reserved. Fran ç ais Espa ñ ol GARANTIE LIMIT É E MA T É RIEL DE PUL V É RISA TION DE PEINTURE SANS AIR Ce produit, fabriqu é par W agner Spray T ech Corporation (Wagner), est garanti, au b é n é fice de l ’ acheteur au d é tail d ’ origine, contre tout vice de mati è re ...

メーカー Wagner SprayTech カテゴリー Paint Sprayer

Wagner SprayTech 9140のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 9140の取扱説明書
- Wagner SprayTechの製品カード
- パンフレット
- またはWagner SprayTech 9140の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Wagner SprayTech 9140の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Wagner SprayTech 9140の取り付け説明書、サービスマニュアル、簡易説明書、またはWagner SprayTech 9140のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Wagner SprayTech 9140の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Wagner SprayTech 9140デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWagner SprayTech 9140を使用するのを助ける技術的文書のことです。説明書は通常、全てのWagner SprayTech 9140ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Wagner SprayTechの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Wagner SprayTech 9140の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWagner SprayTech 9140の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Wagner SprayTech 9140に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Wagner SprayTech 9140デバイスの基本機能を使うにあたってのヒント。 Wagner SprayTech 9140のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Wagner SprayTech 9140に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWagner SprayTech 9140のメーカー/サービスへの連絡先に関する情報。

Wagner SprayTech 9140についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWagner SprayTech 9140の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWagner SprayTech 9140で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)