Lennox Hearth VINの取扱説明書

28ページ 3.15 mb
ダウンロード

ページに移動 of 28

Summary
  • Lennox Hearth VIN - page 1

    Report No. 50-S-1 1b-5 INST ALLA TION AND OPERA TION MANUAL W ARNINGS • Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will retain heat for a while after shutting off the appliance. Severe burns may result. • Carefully supervise children in the same room as appliance. Do not store or use gasoline or ...

  • Lennox Hearth VIN - page 2

    2  FOR YOUR SAFETY do not install or operate your Vin- tage™ gas stove without first read ing and underst anding this manual. Any installation or operation of the appli- ance deviating from that which is stated in this manual WILL void the warranty and may be hazardous.  INST ALLA TION AND REPAIR SHOULD ONL Y BE DONE BY A QUALIFIED SERV ...

  • Lennox Hearth VIN - page 3

    3 C ON GR A TU L A TI ON S O N TH E PU R CH AS E OF YO UR N EW G AS A PP LI A NC E MA NU F A CT UR ED B Y L EN N OX H EA R TH P RO DU CT S. When you purchased your new gas stove, you joined the ranks of thousands of individuals whose answer to their home heating needs reflect s their concern for efficiency and our environm ent. We extend our cont ...

  • Lennox Hearth VIN - page 4

    4 ORIFICE SIZE/AL TITUDE ADJUSTMENT SMOKE DETECTORS CODES AND APPROV ALS THE VINT AGE™ STOVE Installation of these fireplaces are approved for installation in New Y ork City in the US state of New Y ork (MEA#: 138-07-E). NEW YORK CITY , NEW YORK (MEA) COMMONWEAL TH OF MASSACHUSETTS REQUIREMENTS (Massachusetts Approval #G3-0806-6) These fireplac ...

  • Lennox Hearth VIN - page 5

    5 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. PRE-INST ALLA TION Pa nel Ki ts ( Re qu ire d) Ca t. No. Mo del De scr ipt ion 75 19 9 VI NT -C PS -B Ca st Ir on P an el Se t/ B la ck , Re ve r si bl e H7 40 6 V IN T AG E- PK -B G Ga ll o V ene zi ano S to n e Pa ne ls Features Installation Options Residential Vented vertical and horizontal ...

  • Lennox Hearth VIN - page 6

    6 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Dimensions The gas line screws into the gas valve at the back of the stove 5” in from the right side of the stove and 4-3/16” up from the base of the unit. Preparing Y our Vintage™ Stove For Installation Read all instructions before beginning your installation. If instructions have not b ...

  • Lennox Hearth VIN - page 7

    7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Alcove Option 1 Alcove Option 3 Alcove Option 2 Carpet Leg 1-1/2” (38mm) Maximum Corner Installation Clearances to Combustibles Min imum clea ranc es to combus tibl e materi als sho wn here are in inch es (mi llim eter s). See Page 6 f or p ipe clea ranc es. Floor Protection A non-combustibl ...

  • Lennox Hearth VIN - page 8

    8 Firebox Accessories / Parts Cat. No. Description H5861 Log Set H5863 Bag of Embers (volcanic stone) H5864 Bag of Rockwool (glowing embers) H5865 Bag of Steel Wool Log Installation Instructions If logs are not installed according to the log installation instruc- tions, flame impingement and improper combustion could occur and result in soot and/o ...

  • Lennox Hearth VIN - page 9

    9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Side-Insert Installation Follow these steps to install the cast iron inserts or your own custom stone inserts in the Vintage™ gas stove: 1. Remove the cast iron top and set it aside. 2. Remove the cast iron upper piece A - see Figure 14. Complete this step by unscrewing the (2) 5/32 hex-head ...

  • Lennox Hearth VIN - page 10

    10 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Vent Installation V enting : The Vintage™ gas stove has been tested and listed as a direct vent heater system by OMNI-T est Laboratories, Beaverton, Oregon and is recommended for use with Security™ Secure Vent pipe*. Important: • Read all instructions carefully before starting the insta ...

  • Lennox Hearth VIN - page 11

    11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Vent Parts List Direct vent pipe Security™ Secure Vent™ * may be used with the Vintage™ gas stove. Please see the lists below to verify the components available from each dire ct vent pipe manufac turer . Snorke l terminati ons are availabl e for applications which may require vertical ...

  • Lennox Hearth VIN - page 12

    12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Snorkel T erminations For installations requiring a vertical rise on the exterior of the building, 14-inch and 36-inch tall snorkel terminations are available. When us - ing a snorkel, the stove can be vented directly out the back. There is a vent starter collar fastened to the stove (to vent ...

  • Lennox Hearth VIN - page 13

    13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A Flue Opening in the top of the firebox A Restrictor Restrictor Installed Over Flue Opening Figure 23 Figure 25 Figure 24 Flue Restrictors The flue restrictor settings shown in Figures 26 and 27 are for typical installations and may need to be adjusted from standard to take into acco unt o ...

  • Lennox Hearth VIN - page 14

    14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 8’ Max. Restrictor Position # 4 Restrictor Position # 3 Restrictor Position # 3 Restrictor Position # 2 No Restrictor 18” Section of Pipe Horizontal T erminations The shaded areas in the diagram below show all allowable combinations of vent configurations with horizontal terminations. Ho ...

  • Lennox Hearth VIN - page 15

    15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Exterior Horizontal Vent T ermination Clearance Requirements V V V V V F C B B A B H M I X V D V A A A V L B J X E V A G *18” 18” B C C C * S e e It e m D i n t h e T ex t Be lo w . C e n t e r L i ne o f T er mi na ti on E x t e r i or W a l l H o r i z o nt a l T er mi na t io n V en ti ...

  • Lennox Hearth VIN - page 16

    16 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Gas Line Installation This stove must be connected to the gas line in accordance with local codes and/or the National Fuel Gas Code, ANSI Z223.1 (In Canada, the current CAN/CSA B149.1 installation code). The gas line screws into the gas valve at the back of the stove 5” in from the right si ...

  • Lennox Hearth VIN - page 17

    17 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Operating Instructions Pre-Lighting Checklist Be sure to check these items before the initial lighting of the stove: c  The stove gas label corresponds to the gas supply available - that is “natural gas” for natural gas or “LP gas” for LP gas. c  Gas pressure has been chec ...

  • Lennox Hearth VIN - page 18

    18 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNINGS • Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. For assistance or additional infor mation , consult a qua lified inst aller , service agency or your gas supplier . • Operation of this appliance when not connected to a ...

  • Lennox Hearth VIN - page 19

    19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Optional Blower Wiring Diagram F AN SNAP SWITCH - N/O MAIN POWER CORD WIRE (BLACK) GROUND WIRE (GREEN) MAIN POWER CORD WIRE (WHITE) MAIN POWER CORD WIRE (BLACK) F AN SPEED CONTROL SNAP SWITCH CONNECTION WIRE (BLACK) BLOWER SPEED CONTROL CONNECTION WIRE (BLACK) SPEED CONTROL WIRE (RED) SPEED C ...

  • Lennox Hearth VIN - page 20

    20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Millivolt Control Schematic Thermopile ON/OFF Rocker Switch, Thermostat, or Remote Thermostat Piezo Igniter Thermocouple Pilot Gas Line Sparker Pilot Hood Pilot Assembly Gas Inlet Pressure T aps T erminal 3 T erminal 1 T erminal 2 Th erm ost at W ir e Wi re Siz e Ma xim um Len g th 12 Ga ge 1 ...

  • Lennox Hearth VIN - page 21

    21 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Maintenance Checklist: The following should only be performed by a qualified ser vice technician. CAUTION: Label all wires prior to disconnection when ser vic- ing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. 1. Annual inspectio ...

  • Lennox Hearth VIN - page 22

    22 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Glass/Door Maintenance Cleaning: When cooled, the glass may be cleaned with a clean, soft cloth and a household glass cleaner . For cleaning white condensation from the interior glass use a gas stove glass cleaner available from your stove dealer . Use of caustic or abrasive cleaners may dama ...

  • Lennox Hearth VIN - page 23

    23 TROUBLESHOOTING NOTE: When troubleshooting the gas control system, be sure the external gas shut off valve, located at the gas supply inlet is in the “ON” position. IMPORT ANT : Call your gas supplier or plumber for additional help with any gas control problem. Valve system troubleshooting should only be accomplished by a qualified service ...

  • Lennox Hearth VIN - page 24

    24 REPLACEMENT P ARTS Vi nta ge ™ M od el VI N Part Number Description H6031 Cassette Assembly , NG (if LP , also requires 75190 Conversion Kit) H5936 Burner Assembly H5947 Pilot Assembly NG H2830 Pilot Assembly LP H5942 Gas Control Valve, NG (if LP , also requires H5945 LP Regulator) H5943 Regulator , NG H5945 Regulator , LP H5955 Orifice, Main ...

  • Lennox Hearth VIN - page 25

    25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Pa nel Ki ts ( Re qu ire d) Ca t. No. Mo de l De scr ipt ion 75 19 9 VI NT -C PS -B C as t Ir on Pa ne l S et /B la ck , R ev er si bl e u H7 40 6 V I NT AG E-P K- BG Gal lo V en ez ia no St on e P an el s Ga s C onv ers i on K its Ca t. No. Mo del De scr ipt ion 75 19 1 VI NT -T ET N- CK -L ...

  • Lennox Hearth VIN - page 26

    26 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. VIN VENTED GAS FIREPLACE HEA TER - NOT FOR USE WITH SOLID FUEL MA Y BE INST ALLED IN RESIDENTIAL BEDROOMS AND MANUFACTURED (MOBILE) HOMES. TESTED TO ANSI Z21.88-2005/CSA 2.33-2005 “VENTED GAS FIREPLACE HEA TERS”, UL307b, CSA P .4.1-02, AND CGA 2.17-M91. THIS APPLIANCE MUST BE INST ALLED I ...

  • Lennox Hearth VIN - page 27

    27 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. LIGHTING LABEL CAUT ION: YOU R CO UNTR Y GAS APP LIAN CE MU ST AL W A YS BE OPER A TED WITH GLAS S DOO R IN PLAC E. STO P! R ead t he s afet y inf orma tion abov e bef ore proce edin g. 1. Open t he lo wer door . Mak e su re ga s su pply shut -off cock s are ope n an d ON/ OFF Rock er S witc ...

  • Lennox Hearth VIN - page 28

    28 Printed in U.S.A. © 2007 Lennox Hearth Products P/N 775,227M REV . D 11/2008 Lennox Hearth Products reser ves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. WARRANTY Y our gas ...

メーカー Lennox Hearth カテゴリー Stove

Lennox Hearth VINのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- VINの取扱説明書
- Lennox Hearthの製品カード
- パンフレット
- またはLennox Hearth VINの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Lennox Hearth VINの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Lennox Hearth VINの取り付け説明書、サービスマニュアル、簡易説明書、またはLennox Hearth VINのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Lennox Hearth VINの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Lennox Hearth VINデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがLennox Hearth VINを使用するのを助ける技術的文書のことです。説明書は通常、全てのLennox Hearth VINユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Lennox Hearthの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Lennox Hearth VINの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははLennox Hearth VINの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Lennox Hearth VINに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Lennox Hearth VINデバイスの基本機能を使うにあたってのヒント。 Lennox Hearth VINのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Lennox Hearth VINに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるLennox Hearth VINのメーカー/サービスへの連絡先に関する情報。

Lennox Hearth VINについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもLennox Hearth VINの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがLennox Hearth VINで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)