-
Follett 230V 50Hz - page 1
Installation, Operation and Ser vice Manual EU155N Series - 230V 50Hz Ice and W ater Dispenser s Cool Ideas For Ice Managemen t 801 Church Lane • PO Box D, Easton, PA 18044 (610) 252-7301 • FAX (610) 250-0696 • www.follettice.com ® Following installation, please f orwar d this manual to the appropriate operations per son. Automatic load unit ...
-
Follett 230V 50Hz - page 2
...
-
Follett 230V 50Hz - page 3
Ta b le of contents W elcome to Follett . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Bef ore y ou begin. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Electrical requ ...
-
Follett 230V 50Hz - page 4
W elcome to Follett Follett ice and water dispensers enjoy a well-deserved reputation for excellent performance, long-term reliability and outstanding after-the-sale support. To ensure that this dispenser delivers that same degree of service, we ask that you take a moment to review this manual before beginning the installation of the dispenser. Sho ...
-
Follett 230V 50Hz - page 5
Plumbing Dispenser 3/4" PVC slip joint for hopper drain 3/4" PVC pipe nipple for beverage drain pan 3/8 ID red line tubing for water in Note: Drains should be hard piped and insulated. Maintain at least 6mm per 304mm run slope on drain line run Icemaker Refer to Icemaker Installation Manual packed with icemaker for installation instructio ...
-
Follett 230V 50Hz - page 6
5 Junction box Junction box Field wiring diagram is intended to aid electrician or technician in understanding how equipment works. IMPORTANT L1 L2 GND Electric supply 230V 50Hz L1 L2 GND Electric supply 230V 50Hz EU155N Dispenser Connections to complete ER400A/W ice machine Junction box L1 L2 GND Electric supply 230V 50Hz optional second ER400A/W ...
-
Follett 230V 50Hz - page 7
Installation Installing EU155N dispenser in counter 1. Check that dispenser location meets all requirements in this manual and cut counter as shown. 2. Block up area below counter cut-out to support dispenser when lowered into place. 3. For automatic load dispensers, disconnect ice transport tube from bracket in storage area of dispenser. (Since th ...
-
Follett 230V 50Hz - page 8
Installing remote icemaker (automatic load units only) 1. Position icemaker in desired location. 2. Push one end of ice transport tube(s) through hole(s) provided in side of dispenser. 3. Route tube into ice tube bracket inside dispenser and engage bracket tabs in holes located in end of ice transport tube(s). (See drawings below.) 4. Proceed with ...
-
Follett 230V 50Hz - page 9
To star t up and operate dispenser 1. Follow detailed cleaning instructions in service manual before operating dispenser. 2. For manual load units, remove front drain pan or rear lid and fill storage area with compatible ice. 3. Turn power switch located on control box to “ON” position. 4. For automatic fill units, follow detailed instructions ...
-
Follett 230V 50Hz - page 10
9 Cleaning bin before use 1. Wipe storage area with Solution A. 2. Rinse thoroughly with clear, potable water. 3. Wipe with Solution B to sanitize. Pe riodic cleaning of dispenser Recommended daily c leaning of drain pan 1. Remove all debris from drain pan. 2. Pour 1 gallon (4L) hot water into drain pan to keep drain lines clear. Recommended weekly ...
-
Follett 230V 50Hz - page 11
Dispense chute co ver removal 1. Remove top cover. 2. Push chute cover up vertically to slip off holding tab. 3. After clearing tab, pull chute cover forward to remove. Dispense mechanism assembl y remov al 1. Remove top cover. 2. Remove chute cover (see above). 3. Remove auger motor assembly (see above). 4. Remove quick release pins from the ice c ...
-
Follett 230V 50Hz - page 12
Service Disassembl y instructions for service requirements only – NO T required for an y cleaning pr ocedure Dispense wheel motor remov al (Fig. 3) 1. Remove drain pan, bin access cover and dispense wheel. 2. Remove stainless steel baffle plate under dispense wheel. 3. Remove two screws holding wheel motor bracket on bin. 4. Lift plate and motor ...
-
Follett 230V 50Hz - page 13
Blk Blk COUNTERCLOCKWISE ROTATION COUNTERCLOCKWISE ROTATION Red Yel Red Red SWITCH NO. 1 SWITCH NO. 2 IM_#2 IM_#1 AutoFill Timer 24 Volts R1 Blu T-STAT BIN 2 2 Red 3 3 9 6 18 MIN OFF 5 SEC ON 2 NO C DISPENSE RELAY DISPENSE SWITCH Brn DISPENSE SOLENOID Yel Brn 3 1 AUTOFILL RELAY B A R2 Yel Yel DISPENSE RELAY B R1 A Yel EU155N Right hand dispenser Ri ...
-
Follett 230V 50Hz - page 14
13 Symptom Ice does not dispense. • Auger motor does not run • Wheel motor does not run Ice does not dispense. • Auger motor runs • Wheel motor runs • Gate does not open Ice does not dispense. • Auger motor does not run • Wheel motor runs Ice does not dispense. • Auger motor runs • Wheel motor does not run No ice in dispenser. Pos ...
-
Follett 230V 50Hz - page 15
Reference # Description Part # 1 Label, “Follett” 502438 2 Top cover (includes label and magnet) 502905 3 Drain pan (includes magnet) 502903 4 Grille, drain pan 502450 5 Cover, electrical components 502902 6 Lid, rear access (includes magnet) 502904 Not shown Cover, ice storage (under drain pan) 502453 7 Label, ice, dispense cover, push button ...
-
Follett 230V 50Hz - page 16
Dispense assembly side view (RH unit shown) Reference # Description Part # 1 Gate, dispense 502455 2 Linkage pin, gate/solenoid 502456 3 Pin, quick release, 141mm, dispense gate 502102 4 Solenoid (includes linkage pin) 00120295 5 Dispense mechanism assembly, right hand unit 502458 Not shown Dispense mechanism assembly, left hand unit 502496 6 Sprin ...
-
Follett 230V 50Hz - page 17
16 2 Reference # Description Part # 1 Auger, LH unit (black, stamped with “1”) 502491 Not shown Auger, RH unit (gray, stamped with “2”) 502492 2 Plate, auger bearing 501696 Not shown Tube, auger, right hand unit 502487 Not shown Tube, auger, left hand unit 502488 3 Wheel, dispense (includes stud and rotating agitator) 501681 4 Baffle (under ...
-
Follett 230V 50Hz - page 18
17 Reference # Description Part # Auger motor/drive assembly, vertical (includes all items below) 502893 1 Motor, vertical auger (includes gearbox and capacitor) 502889 2 Chain, auger drive #35, 40p 502477 3 Sprocket 35#, 22T 5/8 bore 502478 4 Sprocket 35#, 12T 5/8 bore 502479 5 Drive shaft 502480 6 Bearing, auger, upper and lower 501314 7 Cover an ...
-
Follett 230V 50Hz - page 19
Reference # Description Part # 1 Transformer, 24V 502885 2 Relay, dispense 501826 3 Relay, auto fill 501826 4 Timer, auto fill (automatic fill units) 502471 5S trip, terminal 502472 6 Tube, water dispense, stainless steel 502356 7 Bracket, water solenoid 502611 8 Fitting, outlet, 1/8 MPT x 3/8, compression 502562 9 Valve, solenoid, water 208103 10 ...
-
Follett 230V 50Hz - page 20
Cool Ideas For Ice Managemen t 00120303R00 10/03 801 Church Lane • PO Box D, Easton, PA 18044 (610) 252-7301 • FAX (610) 250-0696 • www.follettice.com ® ...
Follett 230V 50Hzについてご質問がありますか?
次のフォームを使用してください
見つけた説明書を読んでもFollett 230V 50Hzの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFollett 230V 50Hzで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。