-
Bush Hog RTS - page 1
ASSEMBLY l l OPERATION l l MAINTENANCE 707 $4.00 81451 B U S H H O G ® M o d e l R T S R o t a ry T i l l e r O O p p e e r r a a t t o o r r ’ ’ s s M M a a n n u u a a l l ...
-
Bush Hog RTS - page 2
CONGRATULATIONS! You have invested in the best implement of its type on the market today. The care you give your Bush Hog implement will greatly determine your satisfaction with its performance and its service life. We urge a careful study of this manual to provide you with a thorough understanding of your new implement before operating, as well as ...
-
Bush Hog RTS - page 3
RETAIL CUSTOMER’S RESPONSIBILITY UNDER THE BUSH HOG WARRANTY It is the Retail Customer and/or Operator’s responsibility to read the Operator’s Manual, to ope rate, lubricate, maintain and store the product in accordance with all instructions and safety procedures. Failure of the operator to read the Operator’s Manual is a misuse of this equ ...
-
Bush Hog RTS - page 4
LIMITED WARRANTY OOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO Bush Hog warrants to the original purchaser of any new Bush Hog equipment, purchased from an authorized Bush Hog dealer, that the equipment be free from defects in material and workmanship for a period of one (1) year for non-commercial, state, and municipalities’ use and ninety (90) days for comme ...
-
Bush Hog RTS - page 5
DEALER PREPARATION CHECK LIST ROTARY TILLERS BEFORE DELIVERING MACHINE — The following check list should be completed. Use the Operator’s Manual as a guide. r 1. Assembly completed. r 2. Gearboxes filled with oil. r 3. All fittings lubricated. r 4. All shields in place and in good condition. r 5. All fasteners torqued to specifications given in ...
-
Bush Hog RTS - page 6
IMPORTANT SAFETY PRECAUTIONS In addition to the design and configuration of equipment, hazard control and accident prevention are depen- dent upon the awareness, concern, prudence and proper training of personnel in the operation, transport, maintenance and storage of equipment. Lack of attention to safety can result in accident, personal injury, r ...
-
Bush Hog RTS - page 7
6 Figure 1-1 Major Components Mast Hitch Pin Blades Parking Stand Chain Drive Cover Rear Deflector Adjustable Skid Driveline Chain Retainer Cross-Shaft Shield Gearbox (Behind Mast) SECTION I INTRODUCTION AND DESCRIPTION 1-2 INTRODUCTION We are pleased to have you as a Bush Hog cu s- tomer. Your Rotary Tiller has been carefully designed to give maxi ...
-
Bush Hog RTS - page 8
SECTION II PREPARATION FOR USE 2-1 ATTACHING TO TRACTOR A. Attach tiller to tractor 3-point hitch per tractor operator’s manual. Do not attach driveline at this time. NOTE Due to the many variations in tractor/implement hitch points and corresponding differences in distances between tractor PTO shafts and implement input shafts, drivelines may ne ...
-
Bush Hog RTS - page 9
8 26-7/8” Figure 2-7 Alternate Hitch Lug Mounting Figure 2-6 Hitch Lug Dimension Clamp Bolts Frame H i t c h P i n B r a c k e t s G ea r bo x I np u t Sh a ft 26-7/8” H. Using cut off section of shield as a guide, cut shaft the same amount. (Figure 2-4) Figure 2-4 I. Repeat steps “G” and “H” to other driveline section. J. Deburr ends o ...
-
Bush Hog RTS - page 10
9 Figure 3-1 Skid Adjustment 1” 2” 3” 4” SECTION III OPERATING INSTRUCTIONS 3-1 GENERAL SAFETY Only qualified people familiar with this operator’s manual should operate this machine. Operator should wear hard hat, safety glasses, and safety shoes. The operator should read, understand and practice all safety messages shown on the caution, ...
-
Bush Hog RTS - page 11
E. Place tractor in gear and proceed forward. Increase speed to 3/4 throttle. Lower tiller into soil. Increase speed to 540 PTO rpm. Average soil with reasonable moisture will allow travel speeds up to 2 mph. Hard soil will require low travel speed, less than 1 mph to ensure smooth operation and maxi- mum possible depth. Shallow weed cultivation wi ...
-
Bush Hog RTS - page 12
11 (6)100 Hours Fill Line Figure 4-1A Lubrication N O T E : I n s o m e i n s t a n c e s , s l i d i n g t h e y o k e shield back will be necessary to conveniently lubricate the cross bearings. Bondioli & Pavesi Driveline Binacchi Driveline EG Driveline (1) Before Each Use (3) Before Each Use (2) Before Each Use To remove yoke shield, depress ...
-
Bush Hog RTS - page 13
12 Figure 4-2 Blade Wear Figure 4-3 Shear Bolt Figure 4-4 Spring Length Spring Length Bondioli & Pavesi or Binacchi 1.12” (28.6 mm) EG/Comer 1.25” (31.8 mm) Figure 4-5 Slip Clutch Identification Bondioli & Pavesi EG or Binacchi (Holes Through Center) (Solid Casting) 4-6 SLIP CLUTCH ADJUSTMENT The slip clut ch is facto ry pre set to the ...
-
Bush Hog RTS - page 14
Table 4-1 Troubleshooting PROBLEM PROBABLE CAUSE REMEDY Uneven Till Tiller not level right to left Adjust skids for same depth Adjust tractor lower lift arms Noisy Loose components Che ck a ll b olts fo r ti ghtn ess. Ref er t o To rque Spe cs Low oil in gear box C h e c k f o r p r o p e r o i l l e v e l . R e f e r t o L u b r i c a t i o n S ec ...
-
Bush Hog RTS - page 15
14 A. Insert parking stand onto mounting bracket and retain with pin. Fasten parking stand bracket to tiller end plate using two 3/8 x 1” bolts, lockwashers and nuts. B. Attach PTO driveline to gearbox input shaft. Make certain driveline yoke is securely locked into position and driveline shields are in place and in good condition. C. Fasten left ...
-
Bush Hog RTS - page 16
SAFETY DECALS To promote safe operation, Bush Hog supplies safety decals on all products manufactured. Because damage can occur to safety decals either through shipment, use or reconditioning, Bush Hog will, upon request, provide safety decals for any of our products in the field at no charge. Contact your authorized Bush Hog dealer for more inform ...
-
Bush Hog RTS - page 17
B O L T D I A M E T E R W R E N C H ( I N . ) “ B ” A N D S A E S A E S A E S I Z E ( I N . ) “ A ” T H R E A D S I Z E G R A D E 2 G R A D E 5 G R A D E 8 7/16 1/4 - 2O UNC 6 (7) 8 (11) 12 (16) 7/16 1/4 - 28 UNF 6 (8) 10 (13) 14 (18) 1/2 5/16 - 18 UNC 11 (15) 17 (23) 25 (33) 1/2 5/16 - 24 UNF 13 (17) 19 (26) 27 (37) 9/16 3/8 - 16 UNC 20 (2 ...
-
Bush Hog RTS - page 18
IMPORTANT FEDERAL LAWS AND REGULATIONS* CONCERNING EMPLOYERS, EMPLOYEES AND OPERATIONS. *(This section is intended to explain in broad terms the concept and effect of the following federal laws and regulations. It is not intended as a legal interpretation of the laws and should not be considered as such). U.S. Public Law 91-596 (The Williams-Steige ...
-
Bush Hog RTS - page 19
P.O. Box 1039 l l Selma, AL 36702-1039 Telephone (334) 874-2700 l l www.bushhog.com ...
Bush Hog RTSについてご質問がありますか？
次のフォームを使用してください
見つけた説明書を読んでもBush Hog RTSの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがBush Hog RTSで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。