Kohler K241の取扱説明書

16ページ 3.23 mb
ダウンロード

ページに移動 of 16

Summary
  • Kohler K241 - page 1

    OWNER’S MANUAL MODELS ’ K241/ K301 (10 hP) (12 hp) K321,& K341 (14 hp) operating & maintenance instructions (16 hP) Congratulations - You have selected a fine four-cycle, single cylinder, air-cooled engine. Kohler designs long life strength and on-the-job durability into each engine. . . making a Kohler engine dependable.. .dependabilit ...

  • Kohler K241 - page 2

    Safety Precautions I To insure safe operations please read the following statements and understand their meaning. Also refer to your equipment owner’s manual for other important safety information. This manual contains safety precautions which are explained below. Please read carefully. AA WARNING Warning is used to indicate the presence of a haz ...

  • Kohler K241 - page 3

    Safety Precautions (Cont.) A WARNING 3 @ l $5 St 0 : F Accidental Starts can cause Carbon Monoxide can cause severe injury or death. severe nausea, fainting or death. Disconnect and ground spark plug lead before servicing. kcidental Starts! , Before servicing the engine or equipment, always disconnect the spark plug lead to prevent the engine from ...

  • Kohler K241 - page 4

    Air Filter Ignition Coil Blowe !r ,HOUSI Air lnta Screen *NOTE: Dipstick or oil fill plug is optional and may vary depending on engine specification. I Cooling Shrouds Spark Plug Carbur / ‘etor / Oil Drain Oil Pan Figure 1. Typical Command Horizontal Shaft Engine. Oil Recommendations Using the proper type and weight of oil in the crankcase is e ...

  • Kohler K241 - page 5

    Fuel Recommendations A WARNING: Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated, unoccupied buildings, away from sparks or flames. Do not fill the fuel tank while the engine is hot or running, since spilled fuel could ignite if it comes in contact ...

  • Kohler K241 - page 6

    Cold Weather Starting Hints 1. Be sure to use the proper oil for the temperature expected. See Figure 2 on page 4. 2. Declutch all possible external loads. 3. Set speed control at part throttle position. 4. A warm battery has much more starting capacity than a cold battery. 5. Use fresh winter grade fuel. NOTE: Winter grade gasoline has a higher vo ...

  • Kohler K241 - page 7

    Angle of Operation This engine will operate continuously at angles up to 30°. Check oil level to assure crankcase oil level is at the ‘IF” mark. Refer to the operating instructions of the equipment this engine powers. Because of equipment design or application, there may be more stringent restrictions regarding the angle of operation. NOTE: Do ...

  • Kohler K241 - page 8

    Check Oil Level The importance of checking and maintaining the proper oil level in the crankcase cannot be overemphasized. Check oil BEFORE EACH USE as follows: 1. Make sure the engine is stopped, level, and is For a new engine, change oil after the first 5 hours cool so the oil has had time to drain into the of operation. Thereafter, change oil af ...

  • Kohler K241 - page 9

    Wing Nut Air Filter Precleaner Figure 6. Air Cleaner Housing Components. Check the air cleaner daily or before starting the engine. Check for buildup of dirt and debris around the air cleaner system. Keep this area clean. Also check for loose or damaged components. Replace all bent or damaged air cleaner components. NOTE: Operating the engine w ...

  • Kohler K241 - page 10

    3. Check gap using a wire feeler gauge. Spark plug gaps are as follows: Battery/Breakerless . . . . . . . . . . . . . . .035” Magneto . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 025” Gaseous Fuel Engines . . . . . . . . . ,018” (Magneto/Battery Only) Adjust the gap as necessary by carefully bending the ground electrode. Se ...

  • Kohler K241 - page 11

    l Make sure fuel is reaching the carburetor. This includes checking the fuel lines and fuel pump for restrictions or faulty components, replace as necessary. l Make sure the air cleaner element is clean and all air cleaner element components are fastened securely. If, after checking the items listed above, the engine is hard to start, runs roughly, ...

  • Kohler K241 - page 12

    Walbro Carburetor Adjustment In general, turning the adjusting needles in (clockwise) decreases the supply of fuel to the carburetor. This gives a leaner fuel-to-air mixture. Turning the adjusting needles out (counterclockwise) increases the supply of fuel to the carburetor. Idle Speed Screw Figure 9. NOTE: The tip of the low idle fuel and main fue ...

  • Kohler K241 - page 13

    6. Low Idle Fuel Needle Setting: Turn the adjusting needle in (clockwise). The engine speed may increase, then it will decrease as the needle is turned in (lean). Note the position of the needle. Back the needle out approximately l/8 to l/4 turn. See Figure 11 for best low idle fuel performance. Back out Appx. 118 to l/4 Lean turn. Lean Figure 11. ...

  • Kohler K241 - page 14

    Storage If the engine will be out of service for two months or more, use the following storage procedure: 1 . 2 . Clean the exterior surfaces of the engine. Change the oil and filter while the engine is still warm from operation. See “Change Oil” on page 8. 3 . Change oil in reduction gear unit, if so equipped. Refill with the same oil as used ...

  • Kohler K241 - page 15

    Specifications Model: ................................................................................... K241 ................. K301 ................ K321 ................... K341 Bore: ................................................. inches (millimeters) ... 3.25 (82.6) ...... .3.38 (85.7) ....... 3.50 (88.9). ........ .3.75 (95.3) Stroke- ..... ...

  • Kohler K241 - page 16

    ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 FOR SALES AND SERVICE INFORMATION IN U.S. AND CANADA, CALL I-800-544-2444 FORM NO.: TP-1346-C ISSUED: 1 O/87 REVISED: 8197 MAILED: LITHO IN U.S.A. ...

メーカー Kohler カテゴリー Automobile Parts

Kohler K241のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- K241の取扱説明書
- Kohlerの製品カード
- パンフレット
- またはKohler K241の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Kohler K241の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Kohler K241の取り付け説明書、サービスマニュアル、簡易説明書、またはKohler K241のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Kohler K241の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Kohler K241デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがKohler K241を使用するのを助ける技術的文書のことです。説明書は通常、全てのKohler K241ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Kohlerの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Kohler K241の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははKohler K241の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Kohler K241に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Kohler K241デバイスの基本機能を使うにあたってのヒント。 Kohler K241のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Kohler K241に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるKohler K241のメーカー/サービスへの連絡先に関する情報。

Kohler K241についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもKohler K241の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがKohler K241で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)