Heatmaster 150 JUMBOの取扱説明書

30ページ 1.6 mb
ダウンロード

ページに移動 of 30

Summary
  • Heatmaster 150 JUMBO - page 1

    66400501 Installation, Operating and Servicing Instructions HM 60 N / 70 N / 100 N / 150 JUMBO HM 60 N / 70 N / 100 N With A CV BG 2000-S premix gas burner HM 60 N / 70 N / 100 N With A CV BM 101 oil burner HM 150 JUMBO With A CV BM 151 oil burner HeatMaster e xcellence in hot water ...

  • Heatmaster 150 JUMBO - page 2

    1 INTENDED USERS OF THESE INSTR UCTIONS These instructions are intended for - specifying engineers - installing engineers - end-users - servicing engineers SYMBOLS The follo wing symbols are used in these instr uctions: Essential instruction for operating the system correctly . Essential instruction for personal saf ety or en vironmental protection ...

  • Heatmaster 150 JUMBO - page 3

    2 DESCRIPTION OPERA TING PRINCIPLE The HeatMaster is a high performance, direct fired hot water stor age heater , which has indirect heat transfer due to its T ank-in-T ank construction. At the hear t of the HeatMaster is a stainless steel cylinder through which the flue tubes pass. This is surrounded b y a mild steel shell containing the primar y ...

  • Heatmaster 150 JUMBO - page 4

    3 DESCRIPTION Thermal reset high limit thermostat Manual reset high limit thermostat Primar y safety valv e Low water pressure switch Control thermostat Domestic cold water inlet Combustion chamber T op cover Insulation F eatures of HeatMaster 70 N / 100 N Safety f eatures of the HeatMaster 60 N Domestic hot wa ter outlet Burner chamber plate Prima ...

  • Heatmaster 150 JUMBO - page 5

    4 DESCRIPTION Thermal reset high limit thermostat Manual reset high limit thermostat Primar y safety valv e Low water pressure switch Control thermostat Thermal reset high limit thermostat Manual reset high limit thermostat Primar y safety valv e Low water pressure switch Control thermostat Safety f eatures of the HeatMaster 70 N and 100 N Safety f ...

  • Heatmaster 150 JUMBO - page 6

    5 TECHNICAL SPECIFICA TION MAXIMUM OPERA TING CONDITIONS Maximum service pressure (tank full of water) - Primar y circuit: 3 bar - Secondary circuit: 10 bar T est pressure (tank full of water) - Primar y circuit: 4.5 bar - Secondary circuit: 13 bar Operating temperature - Maximum temperature: 90 °C W ater quality • Chlorures: < 150 mg/l (304) ...

  • Heatmaster 150 JUMBO - page 7

    6 TECHNICAL SPECIFICA TION DIMENSIONS The units are delivered fully assemb led, tested and packed on a timber base with shockproof edges and protected b y heat-shrunk plastic film. On reception and after unpacking, chec k the equipment for damage. For transport pur poses, ref er to the weight (page 5) and dimensions given below . D G F E J H B A K ...

  • Heatmaster 150 JUMBO - page 8

    7 TECHNICAL SPECIFICA TION D G F E J H B K A C D A C C/2 A K H J E C D F G 562 HeatMaster 150 Jumbo HeatMaster 70 N and H eatMaster 100 N Without burner With ACV BG 2000-S premix gas burner ...

  • Heatmaster 150 JUMBO - page 9

    8 BOILER ROOM Important •K eep vents free at all times . • Do not store inflammable products in the boiler room. • Do not store corrosiv e products near the boiler, such as paints, solvents , chlor ine, salt, soap and other cleaning products. • If you smell gas, do not s witch on the light or light a flame. T ur n of f the mains gas tap at ...

  • Heatmaster 150 JUMBO - page 10

    9 INST ALLA TION Balanced flue boiler connection type: C • C13: concentr ic horizontal connection • C33: concentr ic vetical connection • C53: parallel chimney connection • C63: concentr ic vertical connection without ter minal (only in Germany and Luxembourg). C53 C13 C33 2 m min. 150 min. 120 Maximum length concentric : 6 metres Maximum l ...

  • Heatmaster 150 JUMBO - page 11

    10 INST ALLA TION Example of heating + storage connection Recommended for applications requiring a high peak flow . Example of series connection Prefer able for high temperature applications with up to three units . Example of parallel connection Recommended for applications with a high contin uous flow . D ANGER! As a safety measure against scaldi ...

  • Heatmaster 150 JUMBO - page 12

    11 INST ALLA TION HEA TING CONNECTION The HeatMaster has two connections at the rear that can be used to connect a central heating circuit. Connecting a heating system may reduce the domestic hot water perf or mance. Expansion The HM 60 is fitted with an 8 litre expansion v essel. HM 70/100 models are fitted with two 10 litre e xpansion vessels, an ...

  • Heatmaster 150 JUMBO - page 13

    12 ELECTRICAL CONNECTIONS Po wer supply The boiler operates with a 230 V - 50 Hz single phase supply . A double pole isolator with a 6 amp fuse or a 6 amp MCB must be fitted outside the boiler to allow pow er to be shut off dur ing servicing and before any repairs are carried out on the boiler . Conformity Boiler installation must comply with the p ...

  • Heatmaster 150 JUMBO - page 14

    13 INST ALLA TION 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 L1 N T1 T2 S3 B4 L1 N T1 T2 S3 1 3 5 4 2 1 1 2 1 2 220/240V ~ 50 Hz ph n C 21 C C C 1 A2 A1 A1 A2 11 6 1 9 5 4 4 16 17 2 19 7 6 5 13 103 ° C 95 ° C 10 - 100 ° C 6,3 A 14 18 12 11 15 Electrical connection HeatMaster 150 Jumbo Y/Gr Br W Pk G B Or Br Bk B BR R Or W W W V Or V Bk B ...

  • Heatmaster 150 JUMBO - page 15

    FILLING THE HO T W A TER AND HEA TING CIRCUITS IMPORT ANT Hot water tank must be pressurised bef ore the heating circuit is filled. 1. Close the primar y circuit filling valves (A) 2. Open the stop valv e (B) and the drawoff tap (C). When water flows out of the tap , the hot water tank is full and the draw off tap (C) should be closed. 3. Fill the ...

  • Heatmaster 150 JUMBO - page 16

    15 BURNER FEA TURES A CV BG 2000-S PREMIX GAS BURNERS Description The burner tube is coated with metal fibre (NIT) which, in addition to its remarkable heat exchange capabilities , gives greater durability . The main components are a venturi and one (model 60 and 70) or two (model 100) gas valv es, technology specially dev eloped by Honeywell f or ...

  • Heatmaster 150 JUMBO - page 17

    16 B. Bl ue Bk. Black Br . Brown G. Grey Gr . Green Y. Y ellow Y/Gr . Y ellow / Green Electrical connections B. Bl ue Bk. Black Br . Brown G. Grey Gr . Green Y. Y ellow Y/Gr . Y ellow / Green Electrical connections Burner electr ical connection BG 2000-S/60 and BG 2000-S/70 L1 N 123 456 7 8 9 1 0 1 1 1 2 S3 B4 N T2 T1 L1 Burner electr ical connecti ...

  • Heatmaster 150 JUMBO - page 18

    17 BURNER FEA TURES Ignition electrode Burner tube Gas valv e V enturi Ionisation probe Burner chamber plate insulation Ignition electrode Burner tube Gas valv e V enturi Ionisation probe Burner chamber plate insulation Chamber plate Relay Burner plug connector F an power plug Gas inlet Fa n P otentiometer setting Chamber plate Relay Burner plug co ...

  • Heatmaster 150 JUMBO - page 19

    18 BURNER FEA TURES HeatMaster 60, 70 and 100 Gas burner features - BG 2000 HM 60 N HM 70 N HM 100 N HM 100 N HM 150 Jumbo + BG 2000-S/60 + BG 2000-S/70 + BG 2000-S/100 + gas pressure + gas pressure jet burner jet burner Input kW 69.9 69.9 85.0 96.8 154 Output kW 63.0 63.0 77.4 90.0 139.1 Combustion efficiency - natural gas % 91.2 91.5 92.9 92.9 91 ...

  • Heatmaster 150 JUMBO - page 20

    19 BURNER FEA TURES A CV BM 101 AND BM 151 OIL BURNERS Description The use of new technology enab les our medium output bur ners to meet current performance and emissions quality requirements. These burners are fitted with high quality components including a two-stage oil pump that permits soft star t. Components: - Landis & Gyr relay - A.E.G. ...

  • Heatmaster 150 JUMBO - page 21

    20 SER VICE INTER V ALS A CV recommends that boilers should be ser viced at least once a year . The burner must be serviced and tested by a competent engineer . If a boiler is subject to heavy use, it ma y require ser vicing more than once a year - consult A CV for advice. SER VICING THE BOILER 1. T ur n OFF the on/off switch on the boiler control ...

  • Heatmaster 150 JUMBO - page 22

    21 MAINTENANCE SER VICING THE SAFETY DEVICES - Check that all thermostats and safety de vices are working properly . - T est the safety v alves on the central heating and hot water circuits . SER VICING THE BURNER Oil burner - Check and if necessary clean the main filter on the oil line. - Check the alignment of the nozzle: check, clean or change t ...

  • Heatmaster 150 JUMBO - page 23

    22 USER GUIDE USING THE BOILER Y our system should be serviced at least once a year by a qualified engineer. If the boiler is subject to heavy use, it may require servicing more than once a year - consult your service engineer for advice. Starting the burner: In normal operation, the b urner star ts automatically whenever the boiler temperature fal ...

  • Heatmaster 150 JUMBO - page 24

    B A HeatMaster 150 Jumbo 23 USER GUIDE Heating system pressure Fr om time to time you ma y need to top up the heating system pressure. This pressure is indicated by the combined temperature and pressure gauge on the boiler control panel. The minimum pressure when the boiler is cold should be 1 bar . The precise operating pressure required depends o ...

  • Heatmaster 150 JUMBO - page 25

    24 USER GUIDE RESETTING THE PRESSURE JET OIL OR GAS B URNER • HM 60 N and HM Jumbo 150 ➠ the lock out indicator is situated on the bur ner . • HM 70 N and 100 N ➠ the lock out indicator is situated on the bur ner and on the control panel. The red warning light indicates an operating fault. W ait five minutes before resetting the b urner . T ...

  • Heatmaster 150 JUMBO - page 26

    25 SERVICE RECORD Date installed : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Model : Serial number : Heating system pressure setting : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : INST ALLA TION DET AILS Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and sign ...

  • Heatmaster 150 JUMBO - page 27

    26 SERVICE RECORD Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : Date serviced : % CO 2 ...

  • Heatmaster 150 JUMBO - page 28

    27 SERVICE RECORD Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : Date serviced : % CO 2 ...

  • Heatmaster 150 JUMBO - page 29

    28 SERVICE RECORD Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : Date serviced : % CO 2 (min. load) : % CO 2 (max. load) : Gas LPG Oil Remarks : ❏❏ ❏ Name and signature : Flue gas T° : Efficiency : Gas pressure : Date serviced : % CO 2 ...

  • Heatmaster 150 JUMBO - page 30

    INTERNA TIONAL A CV international n.v KERKPLEIN, 39 B-1601 RUISBR OEK - BELGIUM TEL.: +32 2 334 82 20 F AX: +32 2 378 16 49 E-MAIL: international.info@acv-world.com BELGIUM A CV BELGIUM n v/sa KERKPLEIN, 39 B-1601 RUISBR OEK-BELGIUM TEL.: +32 2 334 82 40 F AX: +32 2 334 82 59 E-MAIL: belgium.info@acv-world.com CHILE ALBIN TRO TTER Y ACV L TDA SAN P ...

メーカー Heatmaster カテゴリー Fan

Heatmaster 150 JUMBOのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 150 JUMBOの取扱説明書
- Heatmasterの製品カード
- パンフレット
- またはHeatmaster 150 JUMBOの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Heatmaster 150 JUMBOの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Heatmaster 150 JUMBOの取り付け説明書、サービスマニュアル、簡易説明書、またはHeatmaster 150 JUMBOのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Heatmaster 150 JUMBOの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Heatmaster 150 JUMBOデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHeatmaster 150 JUMBOを使用するのを助ける技術的文書のことです。説明書は通常、全てのHeatmaster 150 JUMBOユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Heatmasterの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Heatmaster 150 JUMBOの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHeatmaster 150 JUMBOの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Heatmaster 150 JUMBOに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Heatmaster 150 JUMBOデバイスの基本機能を使うにあたってのヒント。 Heatmaster 150 JUMBOのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Heatmaster 150 JUMBOに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHeatmaster 150 JUMBOのメーカー/サービスへの連絡先に関する情報。

Heatmaster 150 JUMBOについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもHeatmaster 150 JUMBOの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHeatmaster 150 JUMBOで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)