日本語 dropdown-ico

Antunes, AJ VCT-1000の取扱説明書

24ページ 2.32 mb
ダウンロード

ページに移動 of 24

Summary
  • Antunes, AJ VCT-1000 - page 1

    P/N 1010807 Rev . E 06/06 VER TICAL CONT A CT T O ASTER Models VCT -1000 Owner ’ s Man ual M A N U F A C T U R I N G N U M B E R S : 9210700 9210702 9210704 9210706 9210708 9210710 9210712 9210714 9210716 9210720 9210722 ® US C ...

  • Antunes, AJ VCT-1000 - page 2

    VER TICAL CONT ACT T OASTER 2 P/N 1010807 Rev . E 06/06 General The V ertical Contact T oaster , Model VCT -1000, is designed for contact toasting of buns. The toaster design allows the operator to place buns on both sides of the heated Platen at the same time. Buns are placed into the top of the toaster and uniform, golden brown, warm buns are the ...

  • Antunes, AJ VCT-1000 - page 3

    3 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER Authorized Service Agency Name: Phone No.: Address: Use only genuine Roundup replacement parts in this unit. Use of replacement parts other than those sup- plied by the manufacturer will void the warranty . Y our Authorized Service Agency has been factory trained and has a complete supply of p ...

  • Antunes, AJ VCT-1000 - page 4

    VER TICAL CONT ACT T OASTER 4 P/N 1010807 Rev . E 06/06 Throughout this manual, you will find the following safety words and symbols that signify important safety issues with regards to operating or maintaining the equipment. W ARNING GENERAL W ARNING. Indicates informa- tion important to the proper operation of the equipment. Failure to observe ma ...

  • Antunes, AJ VCT-1000 - page 5

    5 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER SPECIFICA TIONS Electrical Ratings Electrical Cord & Plug Configurations CAUTION All electrical connections must be in accordance with local electrical codes and any other applicable codes. W ARNING ELECTRICAL SHOCK HAZARD. F AILURE TO FOLLOW THE INSTRUCTIONS IN THIS MANUAL COULD RESUL T I ...

  • Antunes, AJ VCT-1000 - page 6

    VER TICAL CONT ACT T OASTER 6 P/N 1010807 Rev . E 06/06 Dimensions SPECIFICA TIONS (continued) 10-3/4” (237.1 mm) 20-5/16” (516.0 mm) 23-7/32” (590.0 mm) 22-1 1/16” (576.2 mm) 9-3/4” (248.0 mm) ...

  • Antunes, AJ VCT-1000 - page 7

    7 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER Figure 2. Installing Bun Chute Bun Chute Y ellow Support Rod Hook Bun Chute over rear bottom conveyor cover yellow support rod Figure 1. T oaster and Accessories Heat Shield Heat Shield Conveyor Cover Assy . (rear) Y ellow Support Rod (front) Conveyor Cover Assy . (rear) Bun Feeder. Conveyor C ...

  • Antunes, AJ VCT-1000 - page 8

    VER TICAL CONT ACT T OASTER 8 P/N 1010807 Rev . E 06/06 INST ALLA TION (continued) Installing the Optional Belt Wraps and Roller T ensioners NOTE: Beltwraps and Roller T ensioners are REQUIRED on models with manufacturing number 9210716 and 9210722. INST ALLING BEL T WRAPS NOTE: Depending on toaster usage and how well they are cleaned daily , the B ...

  • Antunes, AJ VCT-1000 - page 9

    9 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER CAUTION Bread may burn. Therefore toasters must not be used near or below curtains or other combustible walls and materials. Failure to maintain safe operat- ing distances may cause discoloration or combustion. CAUTION All electrical connections must be in accordance with local electrical code ...

  • Antunes, AJ VCT-1000 - page 10

    VER TICAL CONT ACT T OASTER 10 P/N 1010807 Rev . E 06/06 Operating Instructions 1. Set the Bun Thickness Compression Knobs (Figure 7) to the desired settings. NOTE: After initial run of 4-6 buns, adjust controls according to the desired finished product. 2. T urn the Rocker Switch (power On/Off) to on (Figure 6). 3. T urn the temperature control to ...

  • Antunes, AJ VCT-1000 - page 11

    1 1 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER MAINTENANCE Daily CLEANING THE RELEASE SHEET , THE OPTIONAL BEL T WRAPS, CONVEYOR BEL T CHAINS, AND TOASTER T ools Required: • Heat resistant gloves • Clean towels • Mu l t ip u rp o se D et e rg e nt So l u ti o n • Sa n i ti z er So l u ti o n 1. T urn the Rocker Switch (power On/O ...

  • Antunes, AJ VCT-1000 - page 12

    VER TICAL CONT ACT T OASTER 12 P/N 1010807 Rev . E 06/06 MAINTENANCE (continued) Replacing Optional Belt Wraps and Measuring the Conveyor Belt Chains and Optional Roller T ensioners (Every 3 - 6 months) REPLACING BEL T WRAPS NOTE: Depending on toaster usage and how well they are cleaned daily , the Belt Wraps should last between 3 - 6 months. Addit ...

  • Antunes, AJ VCT-1000 - page 13

    13 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER Figure 1 1. Removing Conveyor Belt Chain Rotation Upper Support Rod Large Link P/N 0800121 Small Link P/N 0800204 Conveyor Belt Chains MEASURING CONVEYOR BEL T CHAINS Facing the toaster , locate the approximate center-point of the Conveyor Chain. Pull the Conveyor chain away from the edge of ...

  • Antunes, AJ VCT-1000 - page 14

    VER TICAL CONT ACT T OASTER 14 P/N 1010807 Rev . E 06/06 MAINTENANCE (continued) Replacing the Optional Roller T ensioners 1. Remove the acorn nuts and old roller T ensioner Assembly (Figure 12). 2. Replace T ensioner Assembly , and reassemble. 3. Make sure the spacers are placed inside the T ensioner arm. The spacers are smaller than the holes to ...

  • Antunes, AJ VCT-1000 - page 15

    15 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER TROUBLESHOOTING W ARNING T o avoid possible personal injury and/or damage to the unit, inspection, test and repair of electrical equipment should be performed by qualified service personnel. The unit should be unplugged when servicing, except when electrical tests are required. Use extreme ca ...

  • Antunes, AJ VCT-1000 - page 16

    VER TICAL CONT ACT T OASTER 16 P/N 1010807 Rev . E 06/06 TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Product is overly-toast- ed or Platen heat is too high or drop time is too slow . T emperature set too high. Set temperature control to a lower setting. Bun Thickness Compression Knobs set improperly . Measure bun thickness ...

  • Antunes, AJ VCT-1000 - page 17

    17 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER WIRING DIAGRAM = B L K 5 4 2 1 M * W H T P O W E R S W I T C H % B L K B L K G N D G R N T E R M I N A L P O W E R B L O C K C O R D W H T B L K W H T I N T E R L O C K S W I T C H % B L K = W H T % W H T % B L K 6 0 H z 5 0 H z H I - L I M I T T H E R M O S T A T I N D I C A T O R L I G H T ...

  • Antunes, AJ VCT-1000 - page 18

    VER TICAL CONT ACT T OASTER 18 P/N 1010807 Rev . E 06/06 REPLACEMENT P ARTS Idler Sprocket Front Drive Sprocket T emperature Control Thermostat Drive Motor Assy . Rocker Switch Fan Blade Hi-Limit Control Rear Drive Sprocket Drive Chain Interlock Switch Parts Identification ...

  • Antunes, AJ VCT-1000 - page 19

    19 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER REPLACEMENT P AR TS (continued) C A U T I O N 3 3 8 35 10 44 64 52 38 76 34 48 33 66 83 39 45 81 86 82 77 33 91 92 (optional - use only with #93 93 93 Hinged Conv ey or Cov er with Optional Roller T ensioner Assembly . 95 94 ...

  • Antunes, AJ VCT-1000 - page 20

    VER TICAL CONT ACT T OASTER 20 P/N 1010807 Rev . E 06/06 REPLACEMENT P AR TS ( continued) 21 70 87 17 19 70 20 61 57 5 0 72 12 12 6 2 1 7 70 54 7 2 18 19 1 7 23 17 70 16 80 75 70 25 74 42 3 6 67 67 70 42 67 67 53 23 67 46 22 58 84 43 11 24 32 39 28 3 6 83 57 ...

  • Antunes, AJ VCT-1000 - page 21

    21 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER REPLACEMENT P AR TS (continued) 9 41 6 7 40 76 85 4 2 51 7 67 5 37 16 70 78 79 88 31 1 6 7 1 41 4 30 34 27 26 67 67 65 89 90 85 76 83 2 9 ...

  • Antunes, AJ VCT-1000 - page 22

    VER TICAL CONT ACT T OASTER 22 P/N 1010807 Rev . E 06/06 1 001 1266 Conveyor Belt (Consists of below) 2 0800204 1/2” Pitch Link, Small 2 0800121 3/4” Pitch Link, Large 38 2 21501 17 Idler Shaft 2 3 001 1609 Conveyor Cover Assy . (Includes #95) 2 4 0010475 T en sio n e r As sy . ( I nc l. # 40, 7 6 , 8 5 ) 4 5 0800332 Rod, Conveyor Cover 4 6 700 ...

  • Antunes, AJ VCT-1000 - page 23

    23 P/N 1010807 Rev . E 06/06 VER TICAL CONT ACT T OASTER OPTIONAL P ARTS – VCT -1000 Mechanical Butter Wheel Kit (model 7000298) Requires Professional Installation.          (19.1mm) (20.6mm) 7/8" (22.2mm)       1 7000298 Butter Wheel Kit (consists of the following): a 001 1552 End Housing Cover A ...

  • Antunes, AJ VCT-1000 - page 24

    LIMITED W ARRANTY Equipment manufactured by Roundup Food Equipment Division of A.J. Antunes & Co. has been con- structed of the finest materials available and manufactured to high quality standards. These units are warranted to be free from mechanical and electrical defects for a period of one year from date of pur- chase or 18 months from ship ...

メーカー Antunes, AJ カテゴリー Oven

Antunes, AJ VCT-1000のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- VCT-1000の取扱説明書
- Antunes, AJの製品カード
- パンフレット
- またはAntunes, AJ VCT-1000の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Antunes, AJ VCT-1000の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Antunes, AJ VCT-1000の取り付け説明書、サービスマニュアル、簡易説明書、またはAntunes, AJ VCT-1000のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Antunes, AJ VCT-1000の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Antunes, AJ VCT-1000デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがAntunes, AJ VCT-1000を使用するのを助ける技術的文書のことです。説明書は通常、全てのAntunes, AJ VCT-1000ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Antunes, AJの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Antunes, AJ VCT-1000の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははAntunes, AJ VCT-1000の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Antunes, AJ VCT-1000に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Antunes, AJ VCT-1000デバイスの基本機能を使うにあたってのヒント。 Antunes, AJ VCT-1000のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Antunes, AJ VCT-1000に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるAntunes, AJ VCT-1000のメーカー/サービスへの連絡先に関する情報。

Antunes, AJ VCT-1000についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもAntunes, AJ VCT-1000の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがAntunes, AJ VCT-1000で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)