Toshiba DEV002Zの取扱説明書

20ページ 0.36 mb
ダウンロード

ページに移動 of 20

Summary
  • Toshiba DEV002Z - page 1

    E6581295 ⑥ TOSVERT VF-AS1/PS1 Option Instruction Manual DEV002Z-1 * The data given in this manual are subject to change without notice. © Toshiba Schneider Inverter Corporation 2005 All rights reserved. NOTICE 1. Make sure that this instruction manual is delivered to the end user of the DeviceNet option for the VF-AS1/PS1. 2. Read this manual be ...

  • Toshiba DEV002Z - page 2

    E6581295 ⑥ - 1 - Safety precautions On the inverter and in its instruction m anual, important information is contained for preventing injuries to users and damages to assets and for proper use of the device. Read the instruction manual attached to VF- AS1/PS1 along with this instruction manual for completely understanding the safety prec autions ...

  • Toshiba DEV002Z - page 3

    E6581295 ⑥ - 2 - ■ General Operation Danger Disassembly prohibited ▼ Never disassemble, modify or repair. Doing so could result in electric shock, fire and injury. For repairs, call your sales agency. Prohibited ▼ Do not attach this option to any inverter other than the VF-AS1/PS1. Doing so could result in electric shock or fire. ▼ When t ...

  • Toshiba DEV002Z - page 4

    E6581295 ⑥ - 3 - ■ Wiring Danger Mandatory ▼ Shut off power when installing and wiring this option. Wait at least 15 minutes and check to make sure that the charge lamp (VF-AS1/PS1) is no longer lit. ▼ Tighten the screws on the terminal block to t he specified torque (Refer to Section 4.1). If the screws are not tightened to the specified t ...

  • Toshiba DEV002Z - page 5

    E6581295 ⑥ - 4 - Introduction Thank you for purchasing a “VF-AS1/PS1 DeviceNet Option (DEV002Z),” for TOSVERT VF-AS1/PS1 inverter. Installing this option in the VF-AS1/PS1 and using it together, data communication can be made with a host computer or other device via DeviceNet. Please read the entire manual carefully before attempti ng to cont ...

  • Toshiba DEV002Z - page 6

    E6581295 ⑥ - 5 - Contents 1. OVERVIEW .................................................................................................................... ..........................6 2. EXTERIOR FEATURES ........................................................................................................... ................ 7 2.1. DeviceNe t c ...

  • Toshiba DEV002Z - page 7

    E6581295 ⑥ - 6 - 1. Overview The DEV002Z interface allows the VF-AS1/PS1 inverter to be connected into a DeviceNet network. DeviceNet supports a maximum of 64 nodes, allowing for the Master unit and the configuration tool a maximu m of 62 devices can be connected to the network. Master (PLC, etc.) VF-AS1/PS1 VF-AS1/PS1 VF-AS1/PS1 DeviceNet DEV002 ...

  • Toshiba DEV002Z - page 8

    E6581295 ⑥ - 7 - 2. Exterior features The external view of this option and the name of each part are shown below: Danger Prohibited ▼ Do not change the switch setting when the power is on. It could lead to electric shocks, or the option might breaks down or get damaged. 2.1. DeviceNet connector Used to connect DeviceNet network cables. The term ...

  • Toshiba DEV002Z - page 9

    E6581295 ⑥ - 8 - 2.2. DeviceNet indicator The DEV002Z option has a two-color (red and green) LED as a means of indicating the MNS (module/network status), which works basically in accordance with DeviceNet specifications. LED Status Item displayed Off Not Powered/Not On–line Device is not on-line. - The DEV002Z has not completed the Dup_MAC_ID ...

  • Toshiba DEV002Z - page 10

    E6581295 ⑥ - 9 - 3. Installing the DEV002Z Install the DeviceNet option to VF-AS1/PS1 as f ol lows : * When this option is used together with the IO card option, attach this option to the fr ont panel side. (1) Turn off input power of VF-AS1/PS1 and wait for at least 15 minutes and then check that the CHARGE lamp on VF-AS1/PS1 is no longer lit. ( ...

  • Toshiba DEV002Z - page 11

    E6581295 ⑥ - 10 - 4. Connecting to the network 4.1. Installation method (1) Attach DeviceNet cable to DeviceNe t connector. (Refer to Section 2.1). (Be careful not to short-circuit adjacent terminals on DeviceNet connector). <Recommended cable> Thin branch cables: Device Net-specific thin cable. <Tightening torque> 0.5 - 0.6 N·m Reco ...

  • Toshiba DEV002Z - page 12

    E6581295 ⑥ - 11 - 4.2. Network Grounding Please note the following points regarding the grounding of a DeviceNet network. - Do not connect the G/E terminal to a power ground or any other potential noise-producing ground connection (such as a driv e’s “E” terminal). Connect to a close, clean ground to provide RF termination of the DeviceNet ...

  • Toshiba DEV002Z - page 13

    E6581295 ⑥ - 12 - 4.3. Setting a MAC ID number and a network baud rate Configure MAC ID and network baud rate by the dip switch on the DeviceNet option . • MAC ID configuration The MAC ID must be unique and not matc h any other device on the network. 3 4 5 678 3 4 5 6 7 8 SW ID MAC ID SW ID MAC ID 0 OFF OFF OFF OFF OFF OFF 32 ON OFF OFF OFF OFF ...

  • Toshiba DEV002Z - page 14

    E6581295 ⑥ - 13 - 5. Communications-related parameters On the network, the VF-AS1/PS1 (including the DEV002Z) serves as a slave device. Using the parameters listed below, set the slave device on the net work and its mode of operation. These settings can also be made by the use of configuration tools and the EDS file. The EDS file can be downloade ...

  • Toshiba DEV002Z - page 15

    E6581295 ⑥ - 14 - 5.1. f851 : Communication Loss Action Setting (Network breaks) This parameter sets up the VF-AS1/PS1 res ponse to a loss of communications with the DeviceNet network. 0: Stop and Communication release The inverter decelerates the motor to a stop and gives an  alarm (the leftmost LED  flashes). Commands entered through the ...

  • Toshiba DEV002Z - page 16

    E6581295 ⑥ - 15 - 5.3. f830 : Assembly Object Setting The Input/Output Instance of DEV002Z is set up by this parameter. The DEV002Z supports both the standard Device Net AC Drive profile Instances 20/70, 21/71 and user defined Inst ances 100/150, 101/151, 102/152. * For an explanation of f830 = 0 (Instance 20/70), 1 (Ins tance 21/71), 3 (Instance ...

  • Toshiba DEV002Z - page 17

    E6581295 ⑥ - 16 - Data composition of output instance 100 Byte bit Specifications 0 1 Supplement 0 0 Preset speed #1* 1 0 1 Preset speed #2* 1 0 2 Preset speed #3* 1 0 3 Preset speed #4* 1 Preset speed OFF: 0000, Preset speed #1-#15: 0001 to 1111 A combination of 4 different bits is used to select a preset speed from among preset speed operati on ...

  • Toshiba DEV002Z - page 18

    E6581295 ⑥ - 17 - Data composition of output instance 150 Byte bit Specifications 0 1 Supplement 0 0 Fault FL No output Output - 0 1 Fault No trip Tripped The rtry status and the trip retention status are also regarded as tripped statuses. 0 2 Alarm No alarm Alarm issued - 0 3 (Reserved) - - - 0 4 Motor #1/#2 (THR2 selection) Motor #1 (THR1) Moto ...

  • Toshiba DEV002Z - page 19

    E6581295 ⑥ - 18 - 6. DeviceNet Local/Remote Operation The example below shows how to configure t he VF-AS1/PS1 for local / remote operation. <Terminal function> F terminal ............ O perating command R terminal ............ Device Net/Local (Terminal in this example) switch ing RR/S4 terminal.... Operation frequency command <Wiring&g ...

  • Toshiba DEV002Z - page 20

    E6581295 ⑥ - 19 - 7. Specifications Item Specifications Model number DEV002Z DeviceNet Device type: AC drive Connector: Plug type Indicator: MNS (Module / Network status) MAC ID setup: DIP switch Baud-rate setup: DIP switch Baud-rate: 125kbps, 250kbps, 500kbps Use environments Indoors, an altitude of 3,000m or less, where the product will not be ...

メーカー Toshiba カテゴリー Network Card

Toshiba DEV002Zのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- DEV002Zの取扱説明書
- Toshibaの製品カード
- パンフレット
- またはToshiba DEV002Zの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Toshiba DEV002Zの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Toshiba DEV002Zの取り付け説明書、サービスマニュアル、簡易説明書、またはToshiba DEV002Zのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Toshiba DEV002Zの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Toshiba DEV002Zデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがToshiba DEV002Zを使用するのを助ける技術的文書のことです。説明書は通常、全てのToshiba DEV002Zユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Toshibaの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Toshiba DEV002Zの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははToshiba DEV002Zの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Toshiba DEV002Zに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Toshiba DEV002Zデバイスの基本機能を使うにあたってのヒント。 Toshiba DEV002Zのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Toshiba DEV002Zに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるToshiba DEV002Zのメーカー/サービスへの連絡先に関する情報。

Toshiba DEV002Zについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもToshiba DEV002Zの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがToshiba DEV002Zで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)