-
Alto-Shaam Convection Oven - page 1
W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 USA / CANADA FAX: 262.251.7067 • 800.329.8744 U . S . A . ONLY www.alto-shaam.com M odel: ASC-2E ASC-4E Manual Control Convection Oven Electric • INSTALLATION • OPERATION • MAINTENANCE MN-28666 • ...
-
Alto-Shaam Convection Oven - page 2
Delivery .................................. 1 Unpacking ................................ 1 Safety Procedures and Precautions ............. 2 Installation Site Installation .......................... 3 Clearance Requirements .................. 3 Dimension Drawings ...................... 4 Installation Requirements .................. 5 Leveling ..... ...
-
Alto-Shaam Convection Oven - page 3
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 1 DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section locat ...
-
Alto-Shaam Convection Oven - page 4
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 2 CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause minor or mo ...
-
Alto-Shaam Convection Oven - page 5
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 3 INSTALLATION SITE INSTALLATION The Alto-Shaam convection oven must be installed in a location that will permit the oven to function for its intended purpose and to allow adequate clearance for ventilation, proper cleaning, and maintenance. 1. Hood installation is recommended. ( CH ...
-
Alto-Shaam Convection Oven - page 6
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 4 INSTALLATION 30-5/8" (778mm) 8" (203mm) CA VITY VENT ELECTRICAL INLET 3-5/32" (80,1mm) 9-15/16" (252mm) ELECTRICAL ENTRANCE 123° 129° 29" (737mm) CA VITY WIDTH 38" (965mm) 31-1/16" (789mm) 4" (102mm) ELECTRICAL INLET 54-5/8" (1387mm) ...
-
Alto-Shaam Convection Oven - page 7
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 5 INSTALLATION The oven must be mounted on the factory equipped oven legs or on an optional oven stand. Installation on a solid or concrete base that in any way restricts air flow may void the warranty. All clearances for a proper ventilation air supply must be maintained to minimiz ...
-
Alto-Shaam Convection Oven - page 8
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 6 INSTALLATION The oven must be installed by a qualified electrician. This appliance must be branch circuit protected with proper ampacities, in accordance with the wiring diagram located in this manual or in the electrical compartment of the oven. The oven must be properly grounded ...
-
Alto-Shaam Convection Oven - page 9
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 7 INSTALLATION STACKING & VENTING ASSEMBLY (2-ASC-2E/STK SHOWN ) CAUTION TO PREVENT PERSONAL INJURY, USE CAUTION WHEN MOVING OR LEVELING THIS APPLIANCE. Note: Actual unit may be different than shown. Part numbers and drawings are subject to change without notice. ...
-
Alto-Shaam Convection Oven - page 10
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 8 INSTALLATION STACKING & VENTING ASSEMBLY (2-ASC-4E/STK 208/240V SHOWN ) After legs or casters have been installed on the bottom oven, place the upper oven on top of lower unit. Align. ITEM DESCRIPTION PART NO. QTY 2 RISER, FLUE ELECTRIC 1004984 1 3 SCREW, #10 SMS .5LG SC-26520 ...
-
Alto-Shaam Convection Oven - page 11
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 9 INSTALLATION 8 1 1 7 3 4 2 9 1 2 34-5/16" (876mm) 5 6 2 38" (956mm) OVEN STAND ASSEMBLY ITEM DESCRIPTION PART NO. QTY 1 LEG SUPPORT ASSEMBLY 5003488 2 2 CHANNEL, SUPPORT 1004459 2 3 LEG LG-22185 4 *CASTERS, RIGID CS-25674 2 *CASTERS, SWIVEL W/BRAKE CS-25675 2 4 BRACKET, ...
-
Alto-Shaam Convection Oven - page 12
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 10 USER SAFETY INFORMATION CAUTION METAL PARTS OF THIS EQUIPMENT BECOME EXTREMELY HOT WHEN IN OPERATION. TO AVOID BURNS, ALWAYS USE HAND PROTECTION WHEN OPERATING THIS APPLIANCE. IN THE EVENT OF A POWER FAILURE: • TURN ALL SWITCHES OFF. • WAIT UNTIL POWER ...
-
Alto-Shaam Convection Oven - page 13
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 11 PAN/SHELF POSITIONS FOR ASC-4E: The oven includes 6 chrome plated wire shelves with two removable side racks and 12 shelf positions spaced at 1- 3/ 4" (43mm). 1. The best arrangement for broiling, baking cookies and for other baked goods under 2- 1/ 2& ...
-
Alto-Shaam Convection Oven - page 14
OPERATING INSTRUCTIONS ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 12 MANUAL CONTROL OPERATION 1. Press POWER SWITCH A to the ON position. 2. Press FAN SWITCH B to high or low fan speed. 3. Set COOK TEMPERATURE THERMOSTAT D to the temperature desired. When this temperature is reached, LIGHT OFFOVEN READY indicator light E wi ...
-
Alto-Shaam Convection Oven - page 15
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 13 OPERATING INSTRUCTIONS CHEF OPERATING TIPS The Alto-Shaam convection oven will provide the best results and longest possible service with the utilization of the following suggestions and guidelines. NOTE : Moisture will escape around the doors when baking products with a heavy mo ...
-
Alto-Shaam Convection Oven - page 16
CARE AND CLEANING ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 14 PROTECTING STAINLESS STEEL SURFACES It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely destroy the protective surface layer of stainless steel. Abrasive pads, steel wool ...
-
Alto-Shaam Convection Oven - page 17
CARE AND CLEANING ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 15 CLEAN THE OVEN ON A DAILY BASIS 1. After the oven has cooled, remove all detachable items such as wire shelves, side racks, and drip pan. Clean these items separately. 2. Remove any food scraps from shelves, shelf supports, and blower fan wheel. Convection baffl ...
-
Alto-Shaam Convection Oven - page 18
CARE AND CLEANING ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 16 EXTERIOR: To help maintain the protective film coating on polished stainless steel, clean the exterior of the cabinet with a cleaner recommended for stainless steel surfaces. Spray the cleaning agent on a clean cloth and wipe with the grain of the stainless stee ...
-
Alto-Shaam Convection Oven - page 19
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 17 Part numbers and drawings are subject to change without notice. FULL ASSEMBLY - ASC-2E 2 3 6 7 9 8 11 13 14 16 15 10 1 5 4 12 17 18 *Not Shown ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 PANEL, TOP AND SIDE 1005455 1 11 FEET see pg 10 4 2 MOTOR MO-34208 ...
-
Alto-Shaam Convection Oven - page 20
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 18 Part numbers and drawings are subject to change without notice. CONTROL ASSEMBLY - ASC-2E 5 2 3 1 6 12 11 10 14 8 9 7 4 13 16 15 17 18 19 20 ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 HIGH LIMIT BRACKET 1012678 1 11 SWITCH, MOTOR PROTECT SW-33500 1 2 SA ...
-
Alto-Shaam Convection Oven - page 21
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 19 Part numbers and drawings are subject to change without notice. INTERIOR ASSEMBLY - ASC-2E 1 3 2 5 4 15 16 14 6 55 40 26 21 20 19 18 49 48 51 52 53 54 28 27 12 29 23 46 45 44 43 37 36 35 38 17 34 39 9 25 22 24 12 10 4 42 41 47 33 56 32 31 30 13 11 50 7 8 ...
-
Alto-Shaam Convection Oven - page 22
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 20 Part numbers and drawings are subject to change without notice. ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 BODY SIDE, TOP 1005455 1 29 DOOR LATCH ASC-2 L T -26976 2 2 SCREW, #10 X 1/2 SMS HEX HEAD SLOTTED SC-26520 25 30 WASHER, 1/4", FLAT, 5/8 OD 1 ...
-
Alto-Shaam Convection Oven - page 23
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 21 Part numbers and drawings are subject to change without notice. 18 19 15 14 12 13 1 3 9 10 7 8 5 6 4 11 17 16 2 20 FULL ASSEMBLY - ASC-4E ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 PANEL OUTER, TOP AND LH 1006623 1 12 DOOR ASSEMBLY, RH DR-27849 1 2 PANE ...
-
Alto-Shaam Convection Oven - page 24
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 22 Part numbers and drawings are subject to change without notice. CONTROL ASSEMBLY - ASC-4E 9 8 7 11 10 13 12 14 15 16 17 6 2 4 1 3 5 *Not Shown ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 HEAT ELEMENTS, REAR 208V eL-34128 1 8 FUSE HOLDER FU-34771 1 240V e ...
-
Alto-Shaam Convection Oven - page 25
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 23 Part numbers and drawings are subject to change without notice. INTERIOR ASSEMBLY - ASC-4E 42 2 1 40 2 6 5 7 13 13 35 36 26 8 18 21 22 20 19 18 38 36 39 16 29 30 27 28 12 8 17 41 4 3 9 8 10 11 8 23 24 25 15 14 DETAIL A 31 32 34 33 43 ...
-
Alto-Shaam Convection Oven - page 26
SERVICE ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 24 Part numbers and drawings are subject to change without notice. INTERIOR ASSEMBLY - ASC-4E ITEM DESCRIPTION PART NO. QTY 1 COVER, TOP HINGE 1006679 1 2 SCREW ,10-32 X1/2,NF PHIL TRUSS M/S,18-8 SC-2661 4 3 SCREW , 1/4-20 X 1/2" HEX HEAD SC-22729 4 4 BAFFLE ASSEMBL Y 5 ...
-
Alto-Shaam Convection Oven - page 27
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 25 ...
-
Alto-Shaam Convection Oven - page 28
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 26 ...
-
Alto-Shaam Convection Oven - page 29
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 27 ...
-
Alto-Shaam Convection Oven - page 30
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 28 ...
-
Alto-Shaam Convection Oven - page 31
ASC-2E & ASC-4E Electric Convection Ovens - Manual Control • 29 ...
-
Alto-Shaam Convection Oven - page 32
TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...
Alto-Shaam Convection Ovenについてご質問がありますか？
次のフォームを使用してください
見つけた説明書を読んでもAlto-Shaam Convection Ovenの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがAlto-Shaam Convection Ovenで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。