Cub Cadet 72-inchの取扱説明書

32ページ 2.15 mb
ダウンロード

ページに移動 of 32

Summary
  • Cub Cadet 72-inch - page 1

    Hydr ostatic Zer o-T urn Commer cial Riding Mo wer Professional Turf Equipment OPERATOR’S AND SERVICE MANUAL 48” Fabricated Deck 54” Fabricated Deck 60” Fabricated Deck 72” Fabricated Deck ...

  • Cub Cadet 72-inch - page 2

    2 T ABLE OF CONTENTS F oreword . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 General Saf ety Operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 A.Danger . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Cub Cadet 72-inch - page 3

    3 FOR W ARD The T ank Hydrostatic Zero-T ur n Commercial Riding Mower pro vides superb maneuv erability , mid-mount cutting capability f or profession al landscapers, commercial la wn ser vice compa - nies, prof essional turf managers and golf course superintendents. The machine incorporates many safety f eatures that should be studied b y all oper ...

  • Cub Cadet 72-inch - page 4

    4 GENERAL SAFETY OPERA TIONS A. D ANGER 1. Do not operate mach ine in confined areas where e xhaust gases can accumulate. 2. Do not oper ate machine without mo wer chute deflector in place and operationa l. 3. Do not carry passengers. B. W ARNING 1. Do not oper ate machines under the influence of alco hol or dru gs. 2. Do not operate mach i nes wit ...

  • Cub Cadet 72-inch - page 5

    5 11. When looking for oil leak s , n e ver run your hand o ver h ydraulic hoses , lines or fittings . Ne ver tighten or ad just hydra ulic hoses, lines or fitti ngs while the sy stem is under pressure. If high-pressure oil penetr ates the skin, the oil must be remo ved with in a fe w hours by a doc - tor fa mil iar with this f or m of injur y or s ...

  • Cub Cadet 72-inch - page 6

    6 blade bolts are tight before restarting the engine. 13. Ne ver leav e the mow er unattended without: turning off the blade clutch s witch; placing the left and r ight steer ing le vers in the neutral opened-out position; mo ving the throttle to slow; se tting the par king br ake; shutting off the engine and taking the k ey from th e ignition sw i ...

  • Cub Cadet 72-inch - page 7

    7 SAFETY DECALS AND LABELS K E E P HA ND S a n d F E E T AW AY DA NG E R TO R E DU CE THE RI S K O F I N J U RY , DO NO T OP E R A T E M O W E R UN L E S S DI S CHARG E CHUT E CO V ER O R GRAS S C ATCH ER I S I N I TS PRO PER PL A CE. WARNING SHIELD MISSING DO NOT OPERATE Do not put hands or feet under or into mower when engine is running. ROTATING ...

  • Cub Cadet 72-inch - page 8

    8 SPECIFICA TIONS GENERAL INFO . Contr ols: Engine ignition and star t switch; th rottle; chok e; left and r ight steering lev ers; electric blade clutch s witch; parking brake; mow er deck lift P arking Brake: Mechanical linkage brak e handle to inter nal dr um brak es Seat: Adjustab le seat and ar mrests . 5" Adjustment (f ore-aft) Frame: 2& ...

  • Cub Cadet 72-inch - page 9

    9 OPERA TING INSTR UCTIONS A.General 1. When Mowing: a. K eep adults , children, and pets aw ay fr om the area to be m o wed. b . Wh en operating this mower , in the forward direction, do not allo w the steer ing le vers to retur n to Neutral on th eir own. Alwa ys maintain a firm grip on the le vers , operate them smoothly and a voi d any sudden m ...

  • Cub Cadet 72-inch - page 10

    10 b . Av oid tur ning do wnhill if possible, if not use e xtra care and go slo wly . c. A void turning when going downhi ll, traction is at a minimum going do wnhill. d. Do not oper ate with discharge side of the mow er towa rd streets, b uildings, p lay - grounds , parking lots, othe r machines, ani - mals, an d other people. e. Av oid operation ...

  • Cub Cadet 72-inch - page 11

    11 4. Electric Blade Clutch Switc h: (See Figure 1.) Located on the right side of the mo wer beside the ignition s witch. This is an “on/off ” push pull s witch that controls the electric bl ade clutch which supplies power to the cut - ting bl ades through the PT O. Th e switch m ust be tur ned off to star t the engi ne and should be tur ned of ...

  • Cub Cadet 72-inch - page 12

    12 C.Initial Adjustments 1. Check the flu id levels and tires: Note: These checks should be made daily , befo re star ting the engine. a. Fuel: Using a good grade of unleaded, regular gasoline (f or a gasoline engine), fill the fuel tank (beside t he engine on the left or ri ght side of the mower). When the fuel reaches one inch from the top of the ...

  • Cub Cadet 72-inch - page 13

    13 f . Raise t he mowing deck to the transpor t position usin g the transpor t lev er . g. Use the transp or t lev er to lower the mow - ing dec k to the cutting position and repeat step “b . ” abov e to mak e sure that the desired cutting height has been attained . If the dimensions ar e not correct, repeat steps “c. ” through “f . ” a ...

  • Cub Cadet 72-inch - page 14

    14 3. Mov e both lap bars out of the neu tral/ star t position to th e neutral position (tow ard center of machine). Slo wly , mov e both lap bars to ward the front of the machine until the machin e begins to mov e f orward — release the lap ba rs and the machine should sto p. The more that the lap bar s are mov ed towa rd the front of the ma chi ...

  • Cub Cadet 72-inch - page 15

    15 Note: Do not hold the key in the “Start” position for more than 10 seconds o r y ou may damage the star ter . If th e engine do es not start in this time, wait abou t 30 seconds and try again. i. Gasoline Engine: Once the engine s tar ts, push the ch ok e on halfwa y and as the engine warms, push the chok e off all the way . 4. Operating the ...

  • Cub Cadet 72-inch - page 16

    16 MAINTENANCE AND SER VICE W ARNING: Disconnect the spark pl ug wires or r emo ve the key fr om the ignition to prevent the engine from accidentally starting before performing any maintenance on th is mower . A. Mower Dec k 1. Removing the Mo wer Deck: a. Apply the par king brake . Remove ignition ke y and both spark plug caps. b . Lower th e cutt ...

  • Cub Cadet 72-inch - page 17

    17 a. Set the parking brak e. b . Clean any debris fr om the blades. K eep bl ades shar p and free of b uild up at all times. c. Sharpen bl ades ev enly at the original 30° angle to maintain balanced cut ting blades . Do not sharpen the underside of the bl ades. Use a electric blade sharpener , a conv entional electric grinder or a hand file to sh ...

  • Cub Cadet 72-inch - page 18

    18 1. Adding Hydraulic Oil (use Rimu la SAE15W40) a. Place the Mower on a le v el surface and engage the pa rking brake. b. Stop the engine and remo ve the key fro m the ignition switch. c. Clean the area around the Hydr aulic Oil fill neck. d. Remove the h ydraulic fill cap and check the le vel. The correct lev el is a 1/4” below the oil tank fi ...

  • Cub Cadet 72-inch - page 19

    19 c. Store the batter y with a full charge . A dis - charged batter y will fr eeze (ref er to the table belo w). d. Recharge battery when e v er the specific gra vity value is less than 1.225 3. Battery Remov al Wa r n i n g : When removing the cables from the batter y follo w these steps to avoid a short between the wrench and the frame. a. Remov ...

  • Cub Cadet 72-inch - page 20

    20 adjustment specs. There are three in spec - tion slots in the brake co ver . T o adjust, suc - cessiv ely tig hten each of the three gap adjustment nu ts an equal amount. Inser t a f eeler gage (see p age 22 f or specs) into each slot as th e air gap adjustment nut are tightened. The correct adjustment occurs when slight contact with the f eeler ...

  • Cub Cadet 72-inch - page 21

    21 a. Balance inflation pressure bet ween the rear tires t o help maintain straight trav el (see tire side w all for prop er inflation pres - sure). b . K eep the valv e caps tightened to pre vent air pressure loss. 2. Leaking T ires: When a flat tire occurs , repair or replace immed iately . The nor mal pro cedure is to remov e t he wheel and repl ...

  • Cub Cadet 72-inch - page 22

    22 T o adjust either brak e individually , disconnect the brake rod from the brake ar m by removing the cotter pin from the cle vis pin and pulling the cle v is pin from the brak e clevis . Loosen the he x nut and turn the brak e clevis in a cloc kwise direction one full turn looking do wn the brak e rod. This will tighten th e brake about .040 inc ...

  • Cub Cadet 72-inch - page 23

    23 opened out to the neutr al position. If the Mow er begins to creep, adjust the Steering Le vers. If the mow er creeps, first deter mine whether it creeps to the right or left side and which direc - tion the mow er mov es — to the front or the rear . T o make the ad justment, place the steer - ing le vers in the opened-out neutra l po sition an ...

  • Cub Cadet 72-inch - page 24

    24 MAINTENANCE SCHEDULE A. Daily Chec ks 1. Before star ting engine: a. Check th e fuel lev el.** b . Check the engine oil le vel.** c. Check the h ydraulic oil lev el. d. Check the h ydraulic hoses f or leaks, abra - sion, kink s , tw ists, or a flattened condit ion. e. Check the tir es and tire pressure. Drive Tires: 8-10 psi. F ront Caster Wheel ...

  • Cub Cadet 72-inch - page 25

    25 . OIL CHAR T Apply a f ew drops of en gine oil or use a spra y lubricant. Apply the oil to both sides of pivot points . Wipe off any e xcess. Star t engine and operate mo wer briefly to insure that oil spreads ev enly . Number of Oil P oints Description DA I L Y 4 4 2 2 2 2 1 2 WEEKL Y 1 2 2 2 1 1 1 4 2 2 Deck Suspension Pivots Height Adjustment ...

  • Cub Cadet 72-inch - page 26

    26 P erformance Adjustments A. High Speed T racking Adjustment If mow er tracks to one side wi th both lap bars in fully f orward position: 1. Chec k air pressure in all four tires: a. Pressure should be within specif ied ranges and balanc ed side-to-side. b . Rear tires 8-10 psi. reco mmended (20 psi MAX.) c. F ront tires 20-25 psi. recommen ded ( ...

  • Cub Cadet 72-inch - page 27

    27 g. V er ify proper th rottle adjustment b y check - ing RPM readings as outlined abo ve . C. Deck Corner Ball Wheel Roller Settings 1. Matching the set heights of the ball rollers on the f our cor ners of the mo wer deck to the desired cut height will pre vent edg e scalping and minimize an y side-to-side variance in cut height. 2. There are thr ...

  • Cub Cadet 72-inch - page 28

    28 F . Deck le veling Procedure 1. P ar k the mower on a flat pav ed surface , engage the park ing brak e, shut off the engine, remove the ke y from the i gnition s witch, discon nect the spark plu g wires and using the transpor t lev er , low er the mowing deck into the 4" height of cut position. (The 4" hei ght of cut position is recom ...

  • Cub Cadet 72-inch - page 29

    29 WIRING DIA GRAM GD: 02000591 ...

  • Cub Cadet 72-inch - page 30

    30 MAINTENANCE RECORD DA TE WORK PERFORMED DA TE WORK PERFORMED ...

  • Cub Cadet 72-inch - page 31

    31 ...

  • Cub Cadet 72-inch - page 32

    MANUF A CTURER’S LIMITED W A RRANTY - TURF EQUIPMENT This warr anty is specific t o the produc t manual to wh ich it is attac hed. For a complete list of pr oducts and warranties con t act y our authorized Cub Cadet Commer cial dealer . Proper maintenance of the pur chased Cub Cadet Commer cial equipment is the owner’ s responsibility . Fo ll o ...

メーカー Cub Cadet カテゴリー Lawn Mower

Cub Cadet 72-inchのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 72-inchの取扱説明書
- Cub Cadetの製品カード
- パンフレット
- またはCub Cadet 72-inchの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Cub Cadet 72-inchの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Cub Cadet 72-inchの取り付け説明書、サービスマニュアル、簡易説明書、またはCub Cadet 72-inchのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Cub Cadet 72-inchの製品を使用するにあたって最も人気のある説明書を閲覧できます。

Cub Cadet 72-inchデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがCub Cadet 72-inchを使用するのを助ける技術的文書のことです。説明書は通常、全てのCub Cadet 72-inchユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Cub Cadetの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Cub Cadet 72-inchの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははCub Cadet 72-inchの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Cub Cadet 72-inchに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Cub Cadet 72-inchデバイスの基本機能を使うにあたってのヒント。 Cub Cadet 72-inchのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Cub Cadet 72-inchに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるCub Cadet 72-inchのメーカー/サービスへの連絡先に関する情報。

Cub Cadet 72-inchについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもCub Cadet 72-inchの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがCub Cadet 72-inchで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)