BKI COH-EDの取扱説明書

20ページ 0.28 mb
ダウンロード

ページに移動 of 20

Summary
  • BKI COH-ED - page 1

    INST ALLA TION AND OPERA TING INSTRUCTIONS FULL SIZE (CO1-E) & 1/2 SIZE (COH-E) ELECTRIC CONVECTION O VENS Models: CO1-E and COH-E INTENDED FOR OTHER THAN HOUSEHOLD USE RET AIN THIS MANUAL FOR FUTURE REFERENCE OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES This equipment has been engineered to provide you with year round dependable servic ...

  • BKI COH-ED - page 2

    INDEX INST ALLA TION INSTRUCTIONS SECTION ITEM P AGE 1 Receiving 2 2 Location & Minimum Clearances 2 3A Set-Up & Mounting for COH-E1 3 3B Set-up & Mounting for CO1-E 3 4 E l e c t r i c a l C o n n e c t i o n s 4 5 Initial Start Up 5 6 S y s t e m C h e c k & R o t a r y C o n t r o l s 5 7 Steam Injection (Optional) 6 OPERA TING I ...

  • BKI COH-ED - page 3

    MINIMUM CLEARANCES C O H - E 1 C O 1 - E 1 I n c h e s m m I n c h e s m m R i g h t 1 2 5 1 2 5 L e f t 1 2 5 2 5 0 R e a r 1 2 5 1 2 5 Suitable for installation on combustible floors when installed on factory supplied legs or casters. 3A. SET -UP / MOUNTING FOR COH-E1 Counter-top installation must conform to one of the following methods: 1. COH-E ...

  • BKI COH-ED - page 4

    4 2. CO1-E2: INST ALLA TION / MOUNTING 6” LEGS a. After unpacking the unit, remove legs and any other material from inside the oven. b. Tilt the bottom oven onto its left side and attach the two mounting plates to the right underside using ½” bolts and washers and tighten firmly . Screw the 6” legs into the center holes. c. Use proper liftin ...

  • BKI COH-ED - page 5

    2. FIELD CONNECTIONS a. Remove access panel from the right side of the oven. b. Feed power cable (supplied by the customer) through the access hole in the rear of the oven and pull the cable to the front of the oven under the access panel where it may be attached to the cable support bracket. c. Following the appropriate wiring diagram conforming t ...

  • BKI COH-ED - page 6

    7. STEAM INJECTION OPTION The solenoid valve for steam injection is mounted behind the service panel on the right hand side of the unit on COH-E and on the back of the unit on CO1-E. It is pre-wired at the factory . The electronic timer is pre-set at the factory . A ¼” copper tubing with a compression fitting for water connection is provided on ...

  • BKI COH-ED - page 7

    3. COOK & HOLD ROT ARY CONTROL a. Close the oven door(s). b. T urn selector switch to “High” or “Low” position. The green indicator light near the selector switch will be illuminated. c. T urn the thermostat knob to the desired cooking temperature. d. Upon reaching the set temperature, the amber indicator light near the thermostat will ...

  • BKI COH-ED - page 8

    8 OVEN INTERIOR: Clean The Racks And Rack Support Guides: Open the doors and remove all wire racks and rack support guides. T ake them to the sink and thoroughly clean in warm water with mild detergent or soap. Use a nylon scouring pad or stiff nylon brush. DO NOT USE STEEL WOOL. Clean The Stainless Steel Interior: Baked on splatter , oil, grease o ...

  • BKI COH-ED - page 9

    4. SERVICING 1. The power supply to the unit must be disconnected prior to service. 2. Most of the service to this unit can be performed from the front and/or the control panel side. 3. For proper service, access to the control panel side of the unit is required. 4. It is necessary to have access to the back of the oven when the motor and/or contac ...

  • BKI COH-ED - page 10

    17 B L K 2 B L K A4 W H T C2 WHT A5 W H T A6 WHT 9 BLK 10 BLK H5 W H T H3 WHT H6 WHT 6 WHT 16 W H T 1 B L K COM NO L2 9 B L K 12 B L K S B L K A3BLK C1 BLK 13 WHT A3 BLK A4 WHT 4 3 2 P4 P3 P2 P1 BUZZER TIMER 2 1 4 S SELECTOR SWITCH PILOT LIGHT (POWER) DOOR SWITCH C NC NO BUTT CONNECTOR 2 0 8 V 1 220-240V 1 2 0 8 V 3 220-240 V 3 T4 T3 T2 T1 L1 L2 L3 ...

  • BKI COH-ED - page 11

    4- ALL POLES DISCONNECT MUST BE PROVIDED BY THE INSTA LLER RC 1 F, 250VAC m 1 F, 250V AC m m 1 F, 250V AC 2 SPEED 250V 10 B L U C2 BRN S B L U 2 B L U 2 B L U 1 B R N C1 BLU 17 B L U H5 B R N A5 B R N A6 BRN A3 BLU A4 BRN A4 B R N BUZZER TIMER 2 1 4 S 14 B L K 18 W H T Used ONLY on CO1-E CIRCUIT BREAKER 16 BRN 6 BRN 13 BRN L2 4 3 2 1 P4 P3 P2 P1 SE ...

  • BKI COH-ED - page 12

    CO1-E F ull Size Electric Convection Oven Figure A Exterior / Interior / Elements / Controls / Door BR KS AE BR KS AE E R PI D E R PI D w S r i o t c o h D w S r i o t c o h D 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 29 30 31 32 33 34 35 36 37 40 44 43 41 38 39 42 45 46 47 48 50 49 51 52 53 54 55 56 57 57 58 58 59 60 ...

  • BKI COH-ED - page 13

    Exterior / Interior / Elements / Controls / Door Item Part # Description Item Part # Description 1 E3450X Door Seal, To p & Bottom (2) 47 Q1407A Screw , Hx Hd, #10x1/2 2 E3451K Door Seal, Sides (2) 48 K1375E Element Bracket, Flat (4) 3 E3466U Door Closure Strip 49 Q3017A Star W asher #10 4 S1317U Door Handle 50 Q1402A Nut, 10-32 5 Q1477A Screw ...

  • BKI COH-ED - page 14

    Figure B Door Chain / Legs & Open Rack Stand Part # Description Item Part # Description Steam Option (Not Shown) Door Chain Assy Legs & Open Rack Stand 1 2 3 4 6 7 8 10 11 12 13 14 15 16 17 18 19 20 9 5 21 22 23 24 1 S3228A Flange Bearing (4) 13 S1252T 24 1/2" S/S Leg (each) Used w/Casters 2 S3231X Door Chain Assy (Complete) 14 S1081X ...

  • BKI COH-ED - page 15

    Figure A Exterior / Interior / Elements / Controls / Door 1 3 4 5 6 Co l o Co l o Dow n Dow n Up Se t l ec Se t le c M n u e M nu e S r ta t S r ta t S o p t S o p t Down Down g i He a t n g i He a t n a S te m a S te m 2 2 3 1 4 5 6 7 8 9 10 11 12 13 14 12 13 14 15 16 17 18 19 21 20 22 23 24 25 26 27 33 33 28 29 30 33 60 64 31 31 32 34 69 35 35 36 ...

  • BKI COH-ED - page 16

    Exterior / Interior / Elements / Controls / Door I t e m P a r t # D e s c r i p t i o n I t e m Part # Description Optional Steam Injection (Not Shown) 1 E1 178K Outer Shell 44 U1 169A Motor Rotation Arrow , Label 2 E1 179K Outer Side (Right) 45 S1 195X Blower Wheel 3 E1 180X Access Cover Assy . 46 Q2318A Bolt, Wheel Puller 3/8-16x1 1/2 Hx (1) 4 E ...

  • BKI COH-ED - page 17

    34 Figure B Door Latch / Electrical Components Item Part # Description Item Part # Description r Rea 1 2 3 5 4 8 6 7 9 10 12 13 14 15 16 17 19 21 20 22 23 24 25 26 29 30 31 27 32 33 24 28 18 1 U1210A Installation W arning, Label 18 K1087E Spring Bracket 2 U1 120A Element T erminal, Plate 19 Q3017A Star W asher #10 3 M1555A RTD T emperature Probe 20 ...

  • BKI COH-ED - page 18

    NOTES: 18 ...

  • BKI COH-ED - page 19

    19 WHA T IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original pur chaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated and maintained in accordance with National an ...

  • BKI COH-ED - page 20

    P h o n e : ( 8 6 4 ) 9 6 3 - 3 4 7 1 Fax: (864) 963-5316 T oll Free: (800) 927-6887 Website: www .bkideas.com E-mail: customerservice@bkideas.com BKI Worldwide Headquarters PO Box 80400 Simpsonville, SC 29680-0400 USA 20 ...

メーカー BKI カテゴリー Convection Oven

BKI COH-EDのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- COH-EDの取扱説明書
- BKIの製品カード
- パンフレット
- またはBKI COH-EDの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、BKI COH-EDの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、BKI COH-EDの取り付け説明書、サービスマニュアル、簡易説明書、またはBKI COH-EDのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、BKI COH-EDの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

BKI COH-EDデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがBKI COH-EDを使用するのを助ける技術的文書のことです。説明書は通常、全てのBKI COH-EDユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

BKIの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. BKI COH-EDの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははBKI COH-EDの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。BKI COH-EDに関してこのドキュメントで見つけることができる全てのヒントの目次
3. BKI COH-EDデバイスの基本機能を使うにあたってのヒント。 BKI COH-EDのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。BKI COH-EDに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるBKI COH-EDのメーカー/サービスへの連絡先に関する情報。

BKI COH-EDについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもBKI COH-EDの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがBKI COH-EDで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)