Cornelius JT20の取扱説明書

28ページ 0.49 mb
ダウンロード

ページに移動 of 28

Summary
  • Cornelius JT20 - page 1

    J ET S PRAY (C OLD ) T RAINING M ANUAL ✔ C ARBON D IO XIDE ✔ W ATER ✔ S YRUP /C ON CENTRATE ✔ M ECHANICAL ✔ R EFRIGERATION ✔ C ONTR OLS & E LECTRICAL ...

  • Cornelius JT20 - page 2

    Jet Spra y (Cold) Tr aining Manu al Jet S pray (Cold) T raining Manual The products, technical information, and instructions contained in this manual are subject to change without notice. These instructions are not intended to cover all details or varia- tions of the equipment, nor to provide for every possible contingency in the installation, oper ...

  • Cornelius JT20 - page 3

    Jet Spr ay (Cold ) Training Manual T ABLE OF CONTENTS INTROD UCTION - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 1 Preview Ques tions - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 1 Key Things To Know / Do - - - - - - - - - - - - - - - - - - - - - - - - - - - ...

  • Cornelius JT20 - page 4

    Jet Spra y (Cold) Tr aining Manu al TROU BLESHOOTING - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 12 No Spray - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 12 Pump assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - ...

  • Cornelius JT20 - page 5

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 1 - INTRODUCTION 1. P REVIEW Q UESTIONS Check your current knowledge by taking a fe w minutes to answer the following questions: 1. The 5 and 3-gallon bowl assemblies are interchangeable on certain models? _____ T rue _____ False 2. Parts that contain Microban need not be cleaned on ...

  • Cornelius JT20 - page 6

    Jet Spr ay (Cold ) Training Manual - 2 - © 2000, IMI Cornelius Inc. 2. K EY T HINGS T O K NOW / D O ✔ W ork Safely! Always unplug/disconnect the power to the dispenser before servicing, and get help lifting the unit if it must be removed from the counter ! ✔ Make certain that you have adequate airf low around the unit for proper operation ! ? ...

  • Cornelius JT20 - page 7

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 3 - 3. O VERVIEW 3.1 Product Description Product T ypes The visual cold drink dispenser can dispense a premixed dr ink from the follow beverage selections: • Powder based (sport drinks and Icsotonic) • Syrup based product (non-carbonated) • Pulpy products (fresh juice fr om con ...

  • Cornelius JT20 - page 8

    Jet Spr ay (Cold ) Training Manual - 4 - © 2000, IMI Cornelius Inc. 3.2 Dimensions & Cap acities JS7 Dispens ers: Flavors: - - - - - - - - - - - - - - - - - - - - - - - - - - - - - One Capacity: - - - - - - - - - - - - - - - - - - - - - - - - 5 gal. (19 L) V oltages: - - - - - - - - - - - - - - - - 1 15 volt/60 Hz, 240 volt/ 50 Hz Dimensions: ...

  • Cornelius JT20 - page 9

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 5 - 3.3 Accessorie s Leg extension kit p/n S4056 No Cup Contact p/n S6469 Locking Kit p/n A3035 (JT -20), p/n A3036 (JT -30) Spray Drive Motor p/n A1753 INTRODUCTION ...

  • Cornelius JT20 - page 10

    Jet Spr ay (Cold ) Training Manual - 6 - © 2000, IMI Cornelius Inc. SYSTEM DET AILS 1. W ATER 1.1 W ater Quality W ater quality has an af fect on juice dispensing system s. • odor • taste • clarit y/foaming W ater filtration is rec ommended to assu re the bes t beverage taste . 2. M ECHANICAL 2.1 Pump Assembly / S pray Dri ve Assembly All un ...

  • Cornelius JT20 - page 11

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 7 - • Check whipper switch for adjustment. If moved too far for ward, an air lock may occur , there by breaking the magnetic lock between whipper motor and whipper chamber assembly . T o adjust whipper switch, loosen screw to the right of the switch. Slide switch in slot to desired ...

  • Cornelius JT20 - page 12

    Jet Spr ay (Cold ) Training Manual - 8 - © 2000, IMI Cornelius Inc. 2.4 S pray V erses Circula te Certain products are not suited for spraying, including products that have pul p and those that foam. Jet Spray units can be r etro-fitted with circulator assemblies for pulpy or foamy products. • Circulator for foamy products #A1620, including ice ...

  • Cornelius JT20 - page 13

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 9 - 3. R EFRIGERATION 3.1 Coo ling Thermosta t There is one thermostat on all of the cold product units. This thermostat is located against the eva porator coil of the unit. On the JT20 and JT30 units the thermosta t is mounted against the right hand evaporator coil when faci ng the ...

  • Cornelius JT20 - page 14

    Jet Spr ay (Cold ) Training Manual - 10 - © 2000, IMI Cornelius Inc. 3.8 Evaporators There are two types of eva porators on the Jet Spray cold products, coil and dome. It is important on both to remember to keep product above the top of the coils to insure proper cooling of the product and correct ope ration of the cooling system. Sometimes there ...

  • Cornelius JT20 - page 15

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 11 - 4. C ONTROLS AND E LECTRICAL 4.1 Switches Separate spray and ref rigeration switches are located on the front of each dis- penser , excluding the JS7, JW6, and JW5. There are separate switches for each side of multi-bowl models. These switches can be tested by che cking the cont ...

  • Cornelius JT20 - page 16

    Jet Spr ay (Cold ) Training Manual - 12 - © 2000, IMI Cornelius Inc. TROUBLESHOOTING 1. N O S PRAY 1.1 Pump assembly Be sure the spray switch is ON Check impella magnet. Impella should spin freely . If it does not, remove and clean both impella and support pin. NOTE: Check that the Impel la assembly is in upright position, fins facing upward. Suga ...

  • Cornelius JT20 - page 17

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 13 - 2. N OISE IN P UMP A SSEM BLY 2.1 Impella S paci ng Correct installation and maintenance of the impella is very important to efficient operation and the appearance of the product in the bowl. 2.2 Breaking Magnetic Lock The operation of the spray drive motor and impella is simple ...

  • Cornelius JT20 - page 18

    Jet Spr ay (Cold ) Training Manual - 14 - © 2000, IMI Cornelius Inc. 4. B OWL L EAK NOTE: Do not confuse condensation drippings on the outside of the bowl as leaks. High humidity causes more condensation. 1. Be sure the gaskets are proper ly placed in the grooves on the bowl and that there are no tears or cuts in the ga skets. 2. Check for foreign ...

  • Cornelius JT20 - page 19

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 15 - 4. Replace side panels and restart unit. 5.3 Condenser Fan Motor The condenser fan motor is sealed at the factory and nee ds no lubrication. The motor can be checked in two ways; che ck for continuity , and check to see that power is present at the terminal block or terminal str ...

  • Cornelius JT20 - page 20

    Jet Spr ay (Cold ) Training Manual - 16 - © 2000, IMI Cornelius Inc. 2. Compressor will not start — hums but trips overload protector A. Improperly wir ed B. Low voltage to unit C. Relay not closing D. Compressor motor winding open or shorted E. Inter nal mecha nical trouble in compressor F . Liquid refrigerant in compressor A. Check wiring agai ...

  • Cornelius JT20 - page 21

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 17 - 5. Unit runs OK but sh ort- cycl es on A. Overload protec tor B. Thermostat A. See “ Compressor s tarts but then short-cycles on overload protector ” above B. W iden differential 6. Unit operates long or continuously A. Refrigerant low B. Control contacts st uck closed C. Re ...

  • Cornelius JT20 - page 22

    Jet Spr ay (Cold ) Training Manual - 18 - © 2000, IMI Cornelius Inc. 9. Unit noisy A. Loose parts or mount- ing B. T ubing ra ttle C. Bent fan blade vibrat- ing D. W orn fan motor bear- ings A. T ighten B. Reform tubing C. Replace blade D. Replace motor PROBLEM (fault) CAUSE (diagnosis) ACTION (remedy) TROUBLE SHOOTING ...

  • Cornelius JT20 - page 23

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 19 - A TT ACHMENTS The following attachments should be included with this lesson: JetSpray Car e And Cleaning Instructions TROUBLE SHOOTI NG ...

  • Cornelius JT20 - page 24

    Jet Spr ay (Cold ) Training Manual - 20 - © 2000, IMI Cornelius Inc. Micr oban Antibacterial Pr otection AT T A C H M E N T S ...

  • Cornelius JT20 - page 25

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 21 - REVIEW DA TE: _______________________________________________ NAME: _______________________________________________ LOCA TION: __________________________________________ The following questions summarize important points in thi s training lesson. 1. It is acceptable to run the s ...

  • Cornelius JT20 - page 26

    Jet Spr ay (Cold ) Training Manual - 22 - © 2000, IMI Cornelius Inc. 8. What direction does the refrigerant flow during initial startup? ____________________________________________________________________ ____________________________________________________________________ 9. What direction does the refriger ant flow during the cooling cycle? ___ ...

  • Cornelius JT20 - page 27

    Jet Spra y (Cold) Tr aining Manu al © 2000, IMI Cornelius Inc. - 23 - NOTES: _______________________________________________________________________ _______________________________________________________________________ _______________________________________________________________________ ________________________________________________________ ...

  • Cornelius JT20 - page 28

    Part No. TP00936 March 9, 2000 IMI Corneliu s, Inc. www .co rnliu s.co m ...

メーカー Cornelius カテゴリー Juicer

Cornelius JT20のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- JT20の取扱説明書
- Corneliusの製品カード
- パンフレット
- またはCornelius JT20の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Cornelius JT20の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Cornelius JT20の取り付け説明書、サービスマニュアル、簡易説明書、またはCornelius JT20のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Cornelius JT20の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Cornelius JT20デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがCornelius JT20を使用するのを助ける技術的文書のことです。説明書は通常、全てのCornelius JT20ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Corneliusの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Cornelius JT20の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははCornelius JT20の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Cornelius JT20に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Cornelius JT20デバイスの基本機能を使うにあたってのヒント。 Cornelius JT20のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Cornelius JT20に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるCornelius JT20のメーカー/サービスへの連絡先に関する情報。

Cornelius JT20についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもCornelius JT20の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがCornelius JT20で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)