Delta Electronics Series E48SHの取扱説明書

15ページ 0.74 mb
ダウンロード

ページに移動 of 15

Summary
  • Delta Electronics Series E48SH - page 1

    FEATURES  High efficiency: 92.0% @3.3V/30A  Size: 58.4mm x 22.8mm x9.5mm (2.30”x0.90”x0.37”)  Industry standard pin out  Fixed frequency operation  Input UVLO, Output OTP , OCP , OVP  Monotonic startup into normal and pre-biased loads  Secondary control, very fast transient response  2250V Isolation and basic insulatio ...

  • Delta Electronics Series E48SH - page 2

    TECHNICAL SPECIFICA TIONS (T A =25°C, airflow rate=300 LFM, V in =48Vdc, nominal V out unless otherw ise noted.) PA R A M E T E R NOTES and CONDITIONS E48SH3R330 (St andard) Min. T y p. Max. Un its ABSOLUTE MAXIMUM RA TINGS Input V oltage Continuous 75 Vdc T ransient (100ms) 100ms 100 Vdc Operating T emperature Refer to Figure 21 for mea suring po ...

  • Delta Electronics Series E48SH - page 3

    E48SH3R330_0216200 7 3 ELECTRICAL CHARACTERISTICS CUR VES Figure 1: Efficiency vs. load current for minimum, nominal, and maximum in put voltage at 25°C Figure 2: Power dissipation vs. load current for min imum, nominal, and max i mum input voltage at 25°C. Figure 3: T ypical full l oad input characteristics at room temperature 0 0.5 1 1.5 2 2.5 ...

  • Delta Electronics Series E48SH - page 4

    ELECTRICAL CHARACTERISTICS CUR VES E48SH3R330_0216200 7 4 For Negative Remote On/Off Logic Figure 4: T urn-on transient at zero load current (5 ms/div). Vin=48V .T op T race: V out, 2V/div; Bottom T race: ON/OF F input, 2V/div Figure 5: T urn-on transient a t full ra ted load current (constant current load) (5 ms/div). Vin=48V .T op T race: Vout, 2 ...

  • Delta Electronics Series E48SH - page 5

    ELECTRICAL CHARACTERISTICS CUR VES E48SH3R330_0216200 7 5 Figure 8: Output voltage response to step-change in load current (75%-50% of Io, max; di/dt = 0.1A/µs). Load cap: 10µF , tantalum capacitor and 1µF ceramic capa citor. T race: Vout (50mV/div , 100us/div ) , Scope measureme nt should be made using a BNC cable (length shorte r than 20 inche ...

  • Delta Electronics Series E48SH - page 6

    ELECTRICAL CHARACTERISTICS CUR VES Figure 12: Input reflected ripple current, i s , through a 12µH source inductor at nominal input voltage an d rated load current (20 mA/div , 2us/div). Figure 13: Output voltage noise and ripple me asurement test setup Figure 14: Output voltage ripple at nominal input voltage and rated load current (Io=30A)(50 mV ...

  • Delta Electronics Series E48SH - page 7

    DESIGN CONSIDERA TIONS Input Source Impedance The impedance of the input source co nnecting to the DC/DC powe r modules will interact with the modul es and affect the st ability . A low ac-impedance input source is recommended. If the source induct ance is more than a few µ H, we advise adding a 10 µ F to 100 µ F electrolytic capa citor (ESR < ...

  • Delta Electronics Series E48SH - page 8

    FEA TURES DESCRIPTIONS Over-Current Protection The E48SH modules include an internal output over-current protection circuit, which will endure current limiting for an unlimited duration du ring output overload. When the output current exce eds the OCP set point, the current limit function will work by initially reduce duty cycle of the module, the ...

  • Delta Electronics Series E48SH - page 9

    FEA TURES DESCRIPTIONS (CON.) Output V oltage Adjustment (TRIM) To increase or decrea se the output voltage set point, the modules may be connected wit h an external resistor betwee n the TRIM pin and either the SENSE(+) or SENSE(-). The TRIM pin should be left open if this feature is not used. Figure 18: Circuit configuration for trim-down (decrea ...

  • Delta Electronics Series E48SH - page 10

    E48SH3R330_0216200 7 10 THERMAL CONSIDERA TIONS Thermal management is an importa nt part of the system design. To ensure prop er, reliable operation, sufficient cooling of the power mod ule is needed over the entire temperature range of the modul e. Convection coolin g is usually the dominant mode of heat transfer. Hence, the choice of equipment to ...

  • Delta Electronics Series E48SH - page 11

    P I C K A N D P L A C E L O C A T I O N S U R F A C E - M O U N T T A P E & R E E L RECOMMENDED P AD LA YOUT (SMD) E48SH3R330_0216200 7 11 ...

  • Delta Electronics Series E48SH - page 12

    LEADED (Sn/Pb) PROCESS RECOMMEND TEMP . PROFILE T ime ( sec. ) Pre-h eat tem p. 140~180 ° C 60~120 sec. Peak tem p. 210~230 ° C 5sec . Ramp-up te mp. 0.5~3.0 ° C /sec . T emperature ( ° C ) 50 100 150 200 250 300 60 0 120 180 240 2nd Ramp-up temp. 1.0~3.0 ° C /sec. Over 200 ° C 40~50sec. Coolin g down ra te <3 ° C /se c. Note: The tempera ...

  • Delta Electronics Series E48SH - page 13

    MECHANICAL DRA WING SURF ACE-MOUNT MODULE T H R O U G H - H O L E M O D U L E Pin No. Name Function 1 2 3 4 5 6 7 8 +Vin ON/OFF -Vin -V out -SENSE TRIM +SENSE +V out Positive input voltage Remote ON/OFF Negative input voltage Negative output voltage Negative remote sense Output voltage trim Positive remote sense Positive output voltage E48SH3R330_0 ...

  • Delta Electronics Series E48SH - page 14

    MECHANICAL DRA WING (WITH HEA TSPREADER) THROUGH-HOLE MODULE E48SH3R330_0216200 7 14 ...

  • Delta Electronics Series E48SH - page 15

    E48SH3R330_0216200 7 15 P ART NUMBERING SYSTEM E 48 S H 3R3 30 N R F A T ype of Product Input V oltage Number of Output s Product Series Outp ut Vo l t a g e Output Current ON/OFF Logic Pin Length Option Code E- Eighth Brick 48-36V~75V S- Single H-50A series 3R3 - 3.3V 30 - 30A N- Negative P- Positive R- 0.170” N- 0.145” K- 0.1 10” M- SMD F- ...

メーカー Delta Electronics カテゴリー Power Supply

Delta Electronics Series E48SHのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- Series E48SHの取扱説明書
- Delta Electronicsの製品カード
- パンフレット
- またはDelta Electronics Series E48SHの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Delta Electronics Series E48SHの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Delta Electronics Series E48SHの取り付け説明書、サービスマニュアル、簡易説明書、またはDelta Electronics Series E48SHのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Delta Electronics Series E48SHの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Delta Electronics Series E48SHデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがDelta Electronics Series E48SHを使用するのを助ける技術的文書のことです。説明書は通常、全てのDelta Electronics Series E48SHユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Delta Electronicsの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Delta Electronics Series E48SHの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははDelta Electronics Series E48SHの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Delta Electronics Series E48SHに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Delta Electronics Series E48SHデバイスの基本機能を使うにあたってのヒント。 Delta Electronics Series E48SHのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Delta Electronics Series E48SHに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるDelta Electronics Series E48SHのメーカー/サービスへの連絡先に関する情報。

Delta Electronics Series E48SHについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもDelta Electronics Series E48SHの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがDelta Electronics Series E48SHで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)