Monessen Hearth VFCS20DNVの取扱説明書

32ページ 2.55 mb
ダウンロード

ページに移動 of 32

Summary
  • Monessen Hearth VFCS20DNV - page 1

    ON OFF READ AND SA VE THESE INSTR UCTIONS This is an unv ented gas-fired heater . It uses air (o xygen) from the room in which it is installed. Pro visions f or adequate combustion and v entilation air must be pro vided. Ref er to page 8. W ARNINGS If the information in this man ual is not follo wed exactl y , a fire or explosion ma y result causi ...

  • Monessen Hearth VFCS20DNV - page 2

    2 58D6002 CONTENTS Important Safety Information .......................... 3 Product Features .............................................. 5 Dimensions ....................................................... 6 Getting Started ................................................. 7 Product Specifications ..................................... 8 Igniti ...

  • Monessen Hearth VFCS20DNV - page 3

    58D6002 3 10. This unit complies with ANSI Z21.1 1.2 Unvented Heaters. 1 1. Do not install heater in a bathroom or bedroom unless approved for bedroom use. 12. Correct installation of the ceramic ber logs, proper location of the heater , and annual cleaning are neces - sarytoavoidpotent ...

  • Monessen Hearth VFCS20DNV - page 4

    4 58D6002 IMPOR T ANT SAFETY INFORMA TION Continued fr om page 3 16. Keep room area clear and free from comb ustible materi - als,gasolineandotherammablevaporsandliquids. 17. Unvented gas heaters are a supplemental zone heater . They are not intended to be a primary heating? ...

  • Monessen Hearth VFCS20DNV - page 5

    58D6002 5 ON OFF ON OFF PR ODUCT FEA TURES Off/Pilot/On Knob Hi/Lo Knob Door Figure 1 - Cast Iron Sto ve (Single Door) Optional Remote Receiv er F an Switch Piezo Handle On/Off Switch Figure 2 - Cast Iron Sto ve (Double Door) Break-A wa y Handle Store Break-A wa y Handle Here Optional F an Switch Off/Pilot/On Knob Hi/Lo Knob Piezo Optional Remote R ...

  • Monessen Hearth VFCS20DNV - page 6

    6 58D6002 A C B DIMENSIONS Figure 3 - Dimensions CSVF20S/VFCS20D CSVF30S/VFCS30D A 21 1 / 4 " 26 3 / 4 " B 23" 28 1 / 2 " C 16 1 / 2 " 19 3 / 4 " ...

  • Monessen Hearth VFCS20DNV - page 7

    58D6002 7 MAKE SURE Y OU HA VE RECEIVED ALL P ARTS: Carefully inspect the contents for shipping damage. If any parts are missing or damaged, immediately inform the dealer from whom you purchased the appliance. Do not attempt to install any part of the appliance unless you have all parts in good ...

  • Monessen Hearth VFCS20DNV - page 8

    8 58D6002 PR ODUCT SPECIFICA TIONS NA TURAL GAS NO TE: An external regulator is required to reduce supply pressure to a maximum of 10 1 / 2 " w .c. on Natural Gas systems operating at higher pressure . MILLIV OL T PRESSURE RegulatorPressureSetting: 3.5"w .c. PilotRegulator: 3.5"w .c. GasInletPressure: ...

  • Monessen Hearth VFCS20DNV - page 9

    58D6002 9 CODES Adhere to all local codes or , in their absence, the latest edition of THE NA TIONAL  FUEL GAS CODEANSI Z223.1 or NFP A54whichcanbeobtainedfrom… American National Standards Institute, Inc. 1430Broadway New Y ork,NY 10018 or National Fire Pr o ...

  • Monessen Hearth VFCS20DNV - page 10

    10 58D6002 ON OFF L 2 L 1 W H GENERAL INST ALLA TION INFORMA TION Thefollowingformulacanbeusedtodeterminethemaximumheaterratingperthedenitionofunconnedspace: BTU/Hr = (L 1 + L 2 ) Ft x (W) Ft x (H) Ft 50 Considertwoconnectingroomswithanopenareabetween,withthef ...

  • Monessen Hearth VFCS20DNV - page 11

    58D6002 11 D Minimum to Either Side W all E Minimum A G G D Minimum to Either Side W all F Minimum F Minimum 36" in Front C B Mantel Clearance from T op of Unit Side, Measured from T op Rear Measured from Bac k Corner Measured From T op Corners Product Min. Ceiling from Floor Max. Protrusion Min. Height Right Left A B C D E F G VF20 72" 1 ...

  • Monessen Hearth VFCS20DNV - page 12

    12 58D6002 ON OFF A C B CLEARANCES / HEIGHT REQUIRMENTS Figure 6 - Placing Stove in Alco ve Note: Maintain minimum side and bac k clearances when placing sto ve in alcove. Height From Hearth A Width B Depth C VF20 38½" 23" 36" VF30 52" 34" 36" T ested Minim um Alcove Dimensions ...

  • Monessen Hearth VFCS20DNV - page 13

    58D6002 13 PILOT OFF REMOTE CONTROL LOGS ON OFF LOGS PILOT OFF REMOTE CONTROL LOGS REMO VING UNIT FR OM CRA TE 1.  Removetwo(2)straps. See Figur e 7. 2.  Open plastic bag and slide to bottom of unit . See Figur e 8. 3.  Liftup on ashlip andpivot downto opencontrol d ...

  • Monessen Hearth VFCS20DNV - page 14

    14 58D6002 Pipe Coupling T o Heater V alve Gas Supply Inlet CONNECTING THE GAS NO TICE: A qualified gas appliance installer must connect the heater to the gas supply . Consult all local codes. IMPORT ANT : Holdheatervalvermlywithawrenchtopreventmovementwhenconnectingtoinletpipe. Manual Shutoff V alve ...

  • Monessen Hearth VFCS20DNV - page 15

    58D6002 15 ON OFF CHECKING GAS PRESSURE and CONNECTING REMO TE RECEIVER MILLIV OL T CONTR OL (FIGURE 11) The valve regulatorcontrols the burner pressure whichshould becheckedatthepressuretestpoint. If outlet pressure is low , check inlet pressure against data plates or ma ...

  • Monessen Hearth VFCS20DNV - page 16

    16 58D6002 Label all wires prior to disconnection when servicing controls. Wiring error s can cause improper and danger ous operation. V erify pr oper operation after servicing. ELECTRICAL WIRING (MILLI-V OL T) Themilli-voltvalveisaself-poweredcombinationgascontrol THA T DOES NO T REQUIRE 110 V A C T O OPERA TE. On/Off Sw ...

  • Monessen Hearth VFCS20DNV - page 17

    58D6002 17 PILOT OFF REMOTE CONTROL Left Bottom Log #2 Back Log #1 T op Left Log #4 LOG PLA CEMENT VF30 INST ALLING LOGS ON GRA TE (See Figure 14) 1. Installbacklog(#1)onrearlogsupportbracket. 2. Inst all left bottom  log  (# 2) o n le ft l og support brac ket in front ofbac ...

  • Monessen Hearth VFCS20DNV - page 18

    18 58D6002 PILOT OFF REMOTE CONTROL VF20 INST ALLING LOGS ON GRA TE (See Figure 15) 1. Installbacklog(#1)onbackofburnerassembly . 2. Installfrontlog(#2)on2pegsonburnerassembly . R OCK WOOL INST ALLA TION (VF30 UNITS ONL Y) Figure 16 - Rock W ool Installation 1.  Breakrock ...

  • Monessen Hearth VFCS20DNV - page 19

    58D6002 19 Flames fr om the pilot, front and rear b urner should be visually checked as soon as the heater is installed. Inaddition,periodicallychecktheamesvisuallyduringoperation. CHECKING PILO T FLAME The pilot flame m ust alwa ys be present when the heater is in operation. It should just touch the top of the ther - mo ...

  • Monessen Hearth VFCS20DNV - page 20

    20 58D6002 PILOT OFF REMOTE CONTROL FLAME APPEARANCE CHECKING BURNER FLAME In normal operation at full rate after 15 minutes, the f ollowing flame appearances should be observed: Theleftandrightrearamesshould beyellowandextend1"-2"abovemiddlelogs. Theyellowamesshould not cont ...

  • Monessen Hearth VFCS20DNV - page 21

    58D6002 21 PILO T OFF REMOTE CO NTROL Figure 20 - Location of Piezo Ignitor , Contr ol Knobs and Switch on Milli-v olt Unit A. Thisappliance isequippedwithanignitiondevicewhichautomaticallylightsthepilot.Ifthe piezoisnot workingproperly ,see Match Lighting Instructions, page 24. B. BEFO ...

  • Monessen Hearth VFCS20DNV - page 22

    22 58D6002 O F F O N OPERA TING INSTRUCTIONS Figure 21 - Pilot T O TURN OFF GAS T O HEA TER 1. T urnON/OFFswitchtoOFFposition.  2. T urncontrolknobclockwise toOFFpositiontocompletelyshutofftheheater .  3. Ifapplicable:T urnof fallelectricpowertothehea ...

  • Monessen Hearth VFCS20DNV - page 23

    58D6002 23  1. Openstovedoor .Removeanyitemsnecessaryforeasyaccesstothepilot(forexample:logs,screens, etc.).  2. Follow appropriate lightinginstructions found previously . Light a matchand hold the ame tothe end of thepilota ...

  • Monessen Hearth VFCS20DNV - page 24

    24 58D6002 REPLA CEMENT P AR TS 3 4 5 6 7 8 9 10 2 12 1 1 1 BURNER ASSEMBL Y VF20 W ARNING Failure to position the par ts in accordance with these diagrams or failure to use only par ts specifically appro ved with this appliance may res ult in pr ope r ty dama g e or per sonal injury . ...

  • Monessen Hearth VFCS20DNV - page 25

    58D6002 25 REPLA CEMENT P AR TS LIST REPLA CEMENT P AR TS ARE A V AILABLE THROUGH Y OUR RET AILER. BURNER ASSEMBL Y VF20 Item Description Qty Natural Propane 1 Piezo Igniter 1 14D0503 14D0503 2 VF V alve T ube 1 58D0519 58D0519 3 Piezo Wire 1 00K0632 00K0632 4 Burner 1 33D0070 33D0071 5 Control V alve 1 14D0467 14D0468 6 Burner Injector 1 33D0280 3 ...

  • Monessen Hearth VFCS20DNV - page 26

    26 58D6002 3 4 5 6 7 8 9 10 1 1 12 1 13 14 15 2 REPLA CEMENT P AR TS BURNER ASSEMBL Y VF30 W ARNING Failure to position the par ts in accordance with these diagrams or failure to use only par ts specifically appro ved with this appliance may res ult in pr ope r ty dama g e or per sonal injury . ...

  • Monessen Hearth VFCS20DNV - page 27

    58D6002 27 REPLA CEMENT P AR TS LIST REPLA CEMENT P AR TS ARE A V AILABLE THROUGH Y OUR RET AILER. BURNER ASSEMBL Y Accessories Fle x Connector Flexcon 18 W all Switch Kit MVWS W all Ther mostat Kit WT Hand Held Remote RCM/RCB/WMTD Hand Held Thermostat Remote RCT/RCST/WWTD Item Description Qty VF30 Natural Pr opane 1 Piezo Ignitor 1 14D0503 14D0503 ...

  • Monessen Hearth VFCS20DNV - page 28

    28 58D6002 1 2 3 4 5 REPLA CEMENT P AR TS ARE A V AILABLE THROUGH Y OUR RET AILER. Item Description Qty VF30 1 Back Log 1 58D1901 2 Bottom Left Log 1 58D1902 3 Bottom Right Log 1 58D1903 4 Left T op Log 1 58D1904 5 Right T op Log 1 58D1905 REPLA CEMENT P AR TS LIST LOGS W ARNING Failure to position the par ts in accordance with these diagrams or fa ...

  • Monessen Hearth VFCS20DNV - page 29

    58D6002 29 Note: All troub leshooting items are listed in order of operation. TR OUBLESHOO TING W ARNING W ARNING T urn appliance OFF and allo w to cool before servicing. Only a qualified service person should ser vice and repair the heater . SYMPT OM POSSIBLE CA USE A CTION When ignitor button is pressed, ther e is no spark at ODS/pilot. 1 . ? ...

  • Monessen Hearth VFCS20DNV - page 30

    30 58D6002 TR OUBLESHOO TING W ARNING If the gas quality is bad, your pilot ma y not sta y lit, the b urners may produce soot and the heater ma y backfire when lit. If the gas quality or pressure is low , contact your local gas supplier immediately . SYMPT OM POSSIBLE CA USE A CTION ODS/pilot lights, but ame goes out when con- trol knob is rele ...

  • Monessen Hearth VFCS20DNV - page 31

    58D6002 31 NOTE REGARDING VENTED PRODUCTS This product must be installed by a licensed plumber or gas tter when installed within the Commonwealth of Massachusetts. Anyresidencewitha directventproductmusthavea COdetector installed in the residence. Installation of the? ...

  • Monessen Hearth VFCS20DNV - page 32

    Marc h 2007 P/N 58D6002 • Rev . 5 LIMITED LIFETIME W ARRANTY MHS warrants its products to be free of defects in material and workmanship and backs each product with a Limited Lifetime W arranty . ThiswarrantyistotheoriginalpurchaserofaMHSproductand? ...

メーカー Monessen Hearth カテゴリー Oven

Monessen Hearth VFCS20DNVのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- VFCS20DNVの取扱説明書
- Monessen Hearthの製品カード
- パンフレット
- またはMonessen Hearth VFCS20DNVの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Monessen Hearth VFCS20DNVの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Monessen Hearth VFCS20DNVの取り付け説明書、サービスマニュアル、簡易説明書、またはMonessen Hearth VFCS20DNVのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Monessen Hearth VFCS20DNVの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Monessen Hearth VFCS20DNVデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがMonessen Hearth VFCS20DNVを使用するのを助ける技術的文書のことです。説明書は通常、全てのMonessen Hearth VFCS20DNVユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Monessen Hearthの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Monessen Hearth VFCS20DNVの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははMonessen Hearth VFCS20DNVの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Monessen Hearth VFCS20DNVに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Monessen Hearth VFCS20DNVデバイスの基本機能を使うにあたってのヒント。 Monessen Hearth VFCS20DNVのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Monessen Hearth VFCS20DNVに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるMonessen Hearth VFCS20DNVのメーカー/サービスへの連絡先に関する情報。

Monessen Hearth VFCS20DNVについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもMonessen Hearth VFCS20DNVの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがMonessen Hearth VFCS20DNVで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)