ページに移動 of 84
P AR TS AND OPERA TION MANUAL OPERA TION AND P AR TS MANUAL Re vision #1 (01/06/09) THIS MANU AL MUST A CCOMP ANY THE EQUIPMENT A T ALL TIMES. UL TRA-SILENT TM SERIES MODEL DCA-70SSIU 60 Hz GENERA TOR P AR TS LIST NO . M2870300504 ...
P A GE 2 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 3 1 © COPYRIGHT 2009, MUL TIQUIP INC . MQ P ow er Inc, Super-Silent series, and the MQ P o wer logo are registered trademarks of Multiquip Inc. and ma y not be used, reproduced, or altered without written permission. All other trademarks are the property of thier res ...
P A GE 4 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) T ABLE OF CONTENTS Specification and part number are subject to change without notice . NO TE MQ POWER DCA-70SSIU (60HZ) MQ POWER DCA-70SSIU (60HZ) MQ POWER DCA-70SSIU (60HZ) MQ POWER DCA-70SSIU (60HZ) MQ POWER DCA-70SSIU (60HZ) SUPER-SILENT GENERA SUPER-SIL ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 5 1 MQPO WER A Division of Multiquip Inc. POST OFFICE BO X 6254 CARSON, CA 90749 310-537-3700 • 800-421-1244 F AX: 310-632-2656 E-MAIL: mqpower@multiquip.com INTERNET : www .mqpower .com When ordering parts, please supply the following information: ❒ ❒ ❒ ❒ ? ...
P A GE 6 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — SPECIFICA TIONS s n o i t a c i f i c e p S r o t a r e n e G . 1 e l b a T l e d o MU I S S 0 7 - A C D e p y T , d e t a l i t n e v f l e s , d l e i f g n i v l o v e R r o t a r e n e g s u o n o r h c n y s e p y t d e t c e t o ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 7 1 DCA-70SSIU (60 Hz) — DIMENSIONS (T OP , SIDE AND FRONT) Figure 1. Dimensions 70 A B E C D F H G TOP VIEW SIDE VIEW FRONT VIEW Denyo S N O I S N E M I D . 3 E L B A T e c n e r e f e R r e t t e L ) . m m ( . n i n o i s n e m i Dr e t t e L e c n e r e f e R) . ...
P A GE 8 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Bef ore using this g enerator , ensure that the operating individual has read and understands all instructions in this manual. Safety precautions should be followed at all times when operating this equipment. F ailure to read and understand the Safety Messag ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 9 1 DCA-70SSIU (60 Hz) — SAFETY MESSA GE ALER T SYMBOLS AL W A YS place the Engine ON/OFF switch in the OFF position and remove the ignition key when the pump is not in use. AL W A YS wear approv ed respiratory protection. AL W A YS wear approv ed eye and hearing pr ...
P A GE 10 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — R ULES FOR SAFE OPERA TION The following safety guidelines should always be used when operating the DCA-70SSIU (60 Hz) Ultra Silent™ Generator . General Safety: ■ DO NO T operate or ser vice this equipment before reading this enti ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 11 1 DCA-70SSIU (60 Hz) — R ULES FOR SAFE OPERA TION POWER CORD (POWER ON) WET HANDS Dur ing operation of this generator , there exists the possibility of electrocution, electrical shock or burn, which can cause severe bodil y harm or e v en DEA TH! T o av oid these ...
P A GE 12 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — R ULES FOR SAFE OPERA TION Battery Safety Use the following guidelines when handling the battery: ■ The battery contains acids that can cause injur y to the ey es and skin. T o avoid eye irritation, always wear safety glasses. ■ U ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 13 1 Emergencies ■ AL W A YS know the location of the nearest fire e xtinguisher . ■ AL W A YS know the location of the nearest and first aid kit . ■ AL W A YS know the location of the nearest phone or keep a phone on the job site, in case of emergencies. ■ AL ...
P A GE 14 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) The DCA-70SSIU (60 Hz) SuperSilent ™ Generator is equipped with a number of saf ety decals (Figures 2 & 3). These decals are pro vided f or operator saf ety and maintenance inf or mation. The illustration below and on the preceding page show the decal ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 15 1 DCA-70SSIU (60 Hz) — GENERA T OR DECALS Figure 3. Generator Decals (Cont inued) ...
P A GE 16 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Figure 4. T ypical Generator Grounding Application DCA-70SSIU (60 Hz) — INST ALLA TION ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 17 1 Outdoor Installation Install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around. Also install the generator in a manner so that the exhau ...
P A GE 18 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — GENERAL INFORMA TION DCA-70SSIU Ultra Silent™ (60 Hz) Series Familiarization Generator The MQ P o wer Model DCA-70SSIU (60 Hz) is a 56 kW generator (Figure 5) that is designed as a high quality por table (requires a trailer f or tra ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 19 1 DCA-70SSIU (60 Hz) — MAJOR COMPONENTS Figure 5. Major Components 4 e l b a T. s t n e n o p m o C r o j a M r o t a r e n e G . O N M E T IN O I T P I R C S E D 1y l b m e s s A r e l f f u M 2y l b m e s s A e n i g n E 3y l b m e s s A e r u s o l c n E 4y l ...
P A GE 20 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) NO TE P A GE ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 21 1 DCA-70SSIU (60 Hz) — GENERA T OR CONTR OL P ANEL The definitions below describe the controls and functions of the DCA-70SSIU (60 Hz) Generator Control Panel (Figure 6). 1. Main Cir cuit Breaker – This three-pole, 175A main breaker is pro vided to protect the ...
P A GE 22 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Figure 7. Engine Operating Panel DCA-70SSIU (60 Hz) — ENGINE OPERA TING P ANEL ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 23 1 DCA-70SSIU (60 Hz) — ENGINE OPERA TING P ANEL The definitions below describe the controls and functions of the DCA-70SSIU (60 Hz) Engine Operating Panel (Figure 7). 1. Panel Light – Normally used in dark areas or at night time. When activ ated, panel lights w ...
P A GE 24 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Output T erminal F amiliarization The “ Output T erminal P anel ” (Figure 8) is provided with the following: ■ ■ ■ ■ ■ Three (3) 120/240V output receptacles @ 50 amp ■ ■ ■ ■ ■ Three (3) Circuit Breakers @ 50 amps ■ ■ ■ ■ ■ ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 25 1 120 V A C GFCI Receptacles There are two 120 V A C, 20 amp GFCI (Duple x Nema 5-20R) recepacles pro vided on the output ter minal panel. These receptacles can be accessed in any voltage selector switch position. Each receptacle is protected by a 20 amp circuit br ...
P A GE 26 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Figure 13. Connecting Loads Connecting Loads Loads can be connected to the generator by the Ouput T erminal Lugs or the con vienience receptacles (Figure 13). Make sure to read the operation manual before attempting to connect a load to the generator . T o ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 27 1 DCA-70SSIU (60 Hz) — LO AD APPLICA TION Single Phase Load Always be sure to check the nameplate on the generator and equipment to insure the w attage, amperage , frequency , and voltage requirements are satisfactorily supplied by the generator for operating the ...
P A GE 28 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) V oltage Selector Switch The voltage selector switch (Figure 16) is located above the output ter minal panel’ s Har d Wire Hook-up P anel . I t has been provided for ease of voltage selection. V oltage Selector Switch Loc king Button The voltage selector ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 29 1 DCA-70SSIU (60 Hz) — GA UGE READING How to Read the Output T erminal Gauges. The gauges and selector switches on the control panel DO NO T eff ect the generator output. They are pro vided to help observe how much power is being supplied at the Output terminals ...
P A GE 30 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Figure 22. V oltage Selector Switch 240/139V Three-Phase P osition DCA-70SSIU (60 Hz) — OUTPUT TERMINAL P ANEL CONNECTIONS UVW O T erminal Output V oltages V arious output voltages can be obtained using the Output T erminal Lugs . The voltages at the term ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 31 1 Figure 27. V oltage Selector Switch 480/277V Three-Phase P osition 3Ø 480/277 Output T erminal Lug V oltages 1. Place the voltage selector switch in the 3Ø 480/277 position as shown in Figure 27. Figure 28. Output T erminal Lugs 3Ø-480/277V Connections 2. Conn ...
P A GE 32 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — PRE-SETUP Figure 31. Engine Oil Dipstick When checking the engine oil, be sure to check if the oil is clean. If the oil is not clean, drain the oil by removing the oil drain plug, and refill with the specified amount of oil as outline ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 33 1 DCA-70SSIU (60 Hz) — PRE-SETUP Refueling Procedure: 1. Le vel T anks – Make sure fuel cells are le v el with the ground. F ailure to do so will cause fuel to spill from the tank before reaching full capacity (Figure 33). Figure 33. Only Fill on Level Ground O ...
P A GE 34 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Coolant (ISUZU Antifreeze/Summer Coolant/W ater) ISUZU recommends ISUZU Antifreeze/Summer Coolant for use in thier engines, which can be purchased in concentrate (and mixed with 50% demineralized water) or pre-diluted. See the ISUZU Engine Owner's Manu ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 35 1 DCA-70SSIU (60 Hz) — PRE-SETUP When connecting battery do the following: 1. NEVER connect the battery cables to the battery terminals when the MPEC Control Switch is in either the MANU AL position. AL W A YS make sure that the MPEC Control Switch is in the OFF/ ...
P A GE 36 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) 8. Once the engine glow plugs have been warmed, place the MPEC Contr ol Switch in the MANU AL position to star t the engine (Figure 44). Starting (Manual) Figure 44. MPEC Control Switch (Manual P osition) DCA-70SSIU (60 Hz) — GENERA T OR ST ART -UP PR OCE ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 37 1 DCA-70SSIU (60 Hz) — GENERA T OR ST AR T -UP PR OCEDURE (MANU AL) Figure 48. V oltage Adjust Control Knob Figure 49. Ammeter (No Load) 1 3 . The ammeter (Figure 49) will indicate zero amps with no load applied. When a load is applied, the ammeter will indicate ...
P A GE 38 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Shutdown Procedure T o shutdown the generator use the f ollowing procedure: 1. Place both the MAIN , GFCI and LO AD circuit breakers as shown in Figure 39 to the OFF position. 3. Let the engine cool by running it for 3-5 minutes with no load applied. 4. Pla ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 39 1 DCA-70SSIU (60 Hz) — MAINTENANCE Service Daily If the engine is operating in very dusty or dry grass conditions , a clogged air cleaner will result. This can lead to a loss of power , e xcessiv e carbon b uildup in the combustion chamber and high fuel consumpti ...
P A GE 40 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — MAINTENANCE Generator Storage For longe term storage of the generator the following is recommended: Fill the fuel tank completely . T reat with a fuel stabilizer if necessar y . Completely drain the oil from the crankcase and ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 41 1 DCA-70SSIU (60 Hz) — MAINTENANCE Jac ket W ater Heater and Internal Battery Charger 120 V A C Input Receptacles (OPTIONAL) This generator can be optionally equipped with two 120 V A C , 20 amp input receptacles located on the output terminal panel. The purpose ...
P A GE 42 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — TRAILER MAINTENANCE 7. Coupler - T ype of hitch used on the trailer f or towing. 8. Tire Size - Indicates the diameter of the tire in inches (10,12,14, etc.), and the width in millimeters (175,185,205, etc.). The tire diameter must ma ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 43 1 DCA-70SSIU (60 Hz) — TRAILER MAINTENANCE Hydraulic Surge Brakes Hydraulic surge brakes (Figure 58) should not require any special attention with the exception of routine maintenance such as shoe and lining replacement. Brake lines should be periodically checked ...
P A GE 44 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Tires/Wheels/Lug Nuts Tires and wheels are a v er y impor tant and cr itical components of the trailer . When specifying or replacing the trailer wheels it is impor tant the wheels , tires, and axle are properly matched. Tire W ear/Inflation Tire inflation ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 45 1 NEVER use an pneumatic air gun to tighten wheel lug nuts. Figure 60. Wheel Lug Nuts Tightening Sequence DCA-70SSIU (60 Hz) — TRAILER MAINTENANCE NOTE Lug Nut T or que Requirements It is e xtremely impor tant to apply and maintain proper wheel mounting torque on ...
P A GE 46 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — TRAILER WIRING DIA GRAM Figure 61. T railer/T owing V ehicle Wiring Diagram ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 47 1 NO TE P A GE ...
P A GE 48 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — GENERA T OR WIRING DIA GRAM Figure 62. Generator Wiring Diagram ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 49 1 DCA-70SSIU (60 Hz) — ENGINE WIRING DIA GRAM Figure 63. Engine Wiring Diagram ...
P A GE 50 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, use T able 19 sho wn below f or diagnosis of the Generator . If the problem cannot be remedied, consult our company's business ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 51 1 DCA-70SSIU (60 Hz) — TROUBLESHOO TING (ENGINE CONTR OLLER) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdo wn, use T ab le 20 (Engine Controller T roubleshooting) as a basic guideline f o ...
P A GE 52 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) EXPLANA TION OF CODE IN REMARKS COLUMN How to read the marks and remarks used in this parts book. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serial number range (inclusiv e) where a par ticular par t is used. Mo ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 53 1 DCA-70SSIU (60 Hz) — SUGGESTED SP ARE P AR TS P ar t number on this Suggested Spare P ar ts list may supercede/replace the P/N shown in the text pages of this book. NOTE DCA-70SSIU (60 Hz) WHISPER W A TTGENRA T OR W/ISUZU FF4BG1T DIESEL ENGINE 1 T O 3 UNITS Qty ...
P A GE 54 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 HZ) — GENERA T OR ASSY . GENERA T OR ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 55 1 DCA-70SSIU (60 Hz) — GENERA T OR ASSY . GENERA T OR ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 B5110000102 RO T OR ASSY . ............................................ 1 ............. INCLUDES ITEMS W/ * 1-1 * FIELD ASSY . 1 1-2 * 8101070033 F A N 1 1-3 ...
P A GE 56 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — CONTR OL BO X ASSY . CONTR OL BO X ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 57 1 DCA-70SSIU (60 Hz) — CONTR OL BO X ASSY . CONTR OL BO X ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M2213001402 CONTR OL BO X 1 2- 1 0330000180 EDGING 2 2- 2 0330000240 EDGING 1 3 0601870432 CIRCUIT BREAKER 1 3- 1 0601870490 END CAP KLD 2 4 0021004040 M ...
P A GE 58 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — CONTR OL BO X ASSY . (CONT .) CONTR OL BO X ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 59 1 DCA-70SSIU (60 Hz) — CONTR OL BO X ASSY . (CONT .) CONTR OL BO X ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 33 0602202546 CONTR OLLER (EGS) D YN1 1 34 0027105016 MACHINE SCREW 4 35 0016906016 HEX HEAD BOL T 1 4 35 A 0040506000 TOO THED W ASHER 1 3 6 M222 ...
P A GE 60 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — ENGINE AND RADIA T OR ASSY . ENGINE AND RADIA T OR ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 61 1 DCA-70SSIU (60 Hz) — ENGINE AND RADIA T OR ASSY . ENGINE AND RADIA T OR ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 B5923200034 ENGINE 1 1- 1 1132402321 O I L F I L TER CARTRIDGE ..................................... 1 ........... REPLACES P/N 060204121 ...
P A GE 62 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — ENGINE AND RADIA T OR ASSY . (CONT .) ENGINE AND RADIA T OR ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 63 1 DCA-70SSIU (60 Hz) — ENGINE AND RADIA T OR ASSY . (CONT .) ENGINE AND RADIA T OR ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 39 0605511395 V A L V E 1 40 0603306395 HOSE JOINT 1 41 0602021070 C A P 1 42 0269200500 DRAIN HOSE 1 4 3 M9300000103 RESER VE T A ...
P A GE 64 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — OUTPUT TERMINAL ASSY . OUTPUT TERMINAL ASSY . THE SERIAL NUMBER MA Y BE REQUIRED . ADD THE FOLLOWING DIGITS AFTER THE P AR T NUMBER WHEN ORDERING ANY P AINTED P ANEL T O INDICA TE COLOR OF UNIT: 1-ORANGE 5-BLACK 2-WHITE 6-CA TERPILLAR ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 65 1 DCA-70SSIU (60 Hz) — OUTPUT TERMINAL ASSY . OUTPUT TERMINAL ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M3230700003 TERMINAL P ANEL 1 2 M3278500004 OUTPUT TERMINAL BOL T 5 3 0801830904 TIE BOL T 5 4 0040020000 SPRING W ASHER 5 5 0041420000 PLAIN W ASHER ...
P A GE 66 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) A CTU A T OR ASSY . DCA-70SSIU (60 Hz) — A CTU A T OR ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 67 1 A CTU A T OR ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 0602150095 ACTU A T O R 1 1- 1 0030006000 H E X N U T 1 2 M2354200104 BRACKET 1 3 0343502090 HEX SOCKET HEAD CAP SCREW 4 3 A 0036302000 H E X N U T 4 3 B 0043002000 SPRING W ASHER 4 4 M2354200304 BR ...
P A GE 68 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — B A TTER Y ASSY . BA TTER Y ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 69 1 DCA-70SSIU (60 Hz) — B A TTER Y ASSY . BA TTER Y ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 0602220187 B A TTER Y 1 2 M9310500014 BA TTER Y SHEET 1 3 M9103000304 BA TTER Y BAND 1 4 0602220920 B A TTER Y BOL T SET 2 5 0040006000 SPRING W ASHER 2 6 M2346 ...
P A GE 70 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — MUFFLER ASSY . MUFFLER ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 71 1 DCA-70SSIU (60 Hz) — MUFFLER ASSY . MUFFLER ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 B5330100303 MUFFLER 1 2 0016910025 HEX HEAD BOL T 4 3 M2333001203 EXHA UST PIPE 1 4 3943690210 GASKET ............................................................... ...
P A GE 72 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — FUEL T ANK ASSY . FUEL T ANK ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 73 1 DCA-70SSIU (60 Hz) — FUEL T ANK ASSY . FUEL T ANK ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M2363000102 FUEL T ANK 1 2 0605505070 FUEL T ANK CAP 1 3 0605501074 FUEL SENDER UNIT 1 4 0605516090 GASKET 1 5 0027104016 MACHINE SCREW 5 6 M2363200104 T ANK B ...
P A GE 74 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) THE SERIAL NUMBER MA Y BE REQUIRED . ADD THE FOLLO WING DIGITS AFTER THE P ART NUMBER WHEN ORDERING ANY P AINTED P ANEL T O INDICA TE COLOR OF UNIT: 1-ORANGE 5-BLACK 2-WHITE 6-CA TERPILLAR YELLO W 3-SPECTRUM GREY 7-CA T O GOLD 4-SUNBEL T GREEN 8-RED DCA-70S ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 75 1 DCA-70SSIU (60 Hz) — ENCLOSURE ASSY . ENCLOSURE ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M2413001902 BASE 1 2 M1413400004 UNDER CO VER 1 3 0016908020 HEX HEAD BOL T 2 4 M2423001602 FRONT FRAME 1 4A M2493107203 ACOUSTIC SHEET 1 5 0016908020 HEX HEAD B ...
P A GE 76 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — ENCLOSURE ASSY . (CONT .) THE SERIAL NUMBER MA Y BE REQUIRED . ADD THE FOLLO WING DIGITS AFTER THE P ART NUMBER WHEN ORDERING ANY P AINTED P ANEL T O INDICA TE COLOR OF UNIT: 1-ORANGE 5-BLACK 2-WHITE 6-CA TERPILLAR YELLO W 3-SPECTRUM ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 77 1 DCA-70SSIU (60 Hz) — ENCLOSURE ASSY . (CONT .) ENCLOSURE ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 3 4 M2453201602 SPLASHER P ANEL 1 34A M2493408704 ACOUSTIC SHEET 1 35 0019108055 HEX HEAD BOL T 4 35 A 0042308000 SPRING W ASHER 4 35 B 0042408000 PLAIN W ...
P A GE 78 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — R UBBER SEALS ASSY . R UBBER SEALS ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 79 1 DCA-70SSIU (60 Hz) — R UBBER SEALS ASSY . R UBBER SEALS ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 0228901660 R UBBER SEAL 3 2 0228900915 R UBBER SEAL 1 3 0228900745 R UBBER SEAL 1 4 0228901120 R UBBER SEAL 3 5 M1490300004 R UBBER SEAL 1 6 0228800680 R ...
P A GE 80 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) DCA-70SSIU (60 Hz) — NAME PLA TE AND DECALS ASSY . NAMEPLA TE AND DECALS ASSY . ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 81 1 DCA-70SSIU (60 Hz) — NAME PLA TE AND DECALS ASSY . NAMEPLA TE AND DECALS ASSY . NO . P AR T NO . P AR T NAME QTY . REMARKS 1 M1550000204 DECAL : NO TE 1 2 M1550002203 DECAL : A UXILLAR Y OUTPUT 1 3 M1550001304 DECAL : LIFTING CAP 1 4 M2550001803 DECAL : GENERA ...
P A GE 82 — DCA-70SSIU (60 Hz) — OPERA TION AND P A R TS MANU AL — REV . #1 (01/06/09) TERMS AND CONDITIONS OF SALE — P AR TS P A YMENT TERMS T er ms of pa yment f or par ts are net 10 da ys. FREIGHT POLICY All par ts orders will be shipped collect or prepaid with the charges added to the invoice. All shipments are F .O .B. point of or igin ...
DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 83 1 NO TE P A GE ...
P AR TS AND OPERA TION MANUAL OPERA TION AND P AR TS MANUAL Y our Local Dealer is: MQ PO WER A Division of Multiquip Inc. POST OFFICE BO X 6254 CARSON, CA 90749 310-537-3700 • 800-421-1244 F AX: 310-632-2656 E-mail: mqpower@multiquip.com Inter net: www .mqpower .com Manufactured for Multiquip Inc. by DENYO CO., L TD, JAPAN HERE'S HOW TO GET ...
Multiquip M2870300504のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- M2870300504の取扱説明書
- Multiquipの製品カード
- パンフレット
- またはMultiquip M2870300504の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Multiquip M2870300504の取扱説明書に含まれています。
取扱説明書と呼ばれる文書のグループは、Multiquip M2870300504の取り付け説明書、サービスマニュアル、簡易説明書、またはMultiquip M2870300504のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Multiquip M2870300504の製品を使用するにあたって最も人気のある説明書を閲覧できます。
Multiquip M2870300504デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがMultiquip M2870300504を使用するのを助ける技術的文書のことです。説明書は通常、全てのMultiquip M2870300504ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。
Multiquipの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。
1. Multiquip M2870300504の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははMultiquip M2870300504の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Multiquip M2870300504に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Multiquip M2870300504デバイスの基本機能を使うにあたってのヒント。 Multiquip M2870300504のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Multiquip M2870300504に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるMultiquip M2870300504のメーカー/サービスへの連絡先に関する情報。
Multiquip M2870300504についてご質問がありますか？
次のフォームを使用してください
見つけた説明書を読んでもMultiquip M2870300504の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがMultiquip M2870300504で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。