-
Kohler CH18-26 - page 1
C OMMAND S ERIES CH18-26, CH730-745 O WNER ' S M ANUAL H ORIZONT AL C RANKSHAFT ...
-
Kohler CH18-26 - page 2
2 Explosive Fuel can cause fires and severe burns. S top engine before filling fuel tank. W ARNING Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated, unoccupied buildings, away from sparks or flames. Do not fill the fuel tank while the engine is hot ...
-
Kohler CH18-26 - page 3
3 Safety Precautions (Cont.) Accidental S t arts can cause severe injury or death. Disconnect and ground spark plug leads before servicing. W ARNING Carbon Monoxide can cause severe nausea, fainting or death. Do not operate engine in closed or confined area. W ARNING W ARNING Explosive Gas can cause fires and severe acid burns. Charge battery only ...
-
Kohler CH18-26 - page 4
4 Figure 1. T ypical Command Horizontal Shaf t Carbureted Engine. Figure 2. T ypical Command Horizontal Shaf t EFI Engine. Air Cleaner Oil Fill Rectifier-Regulator Throttle Body Intake Manifold Ignition Coil Fuel Injectors Ignition Coil Oil Filter Oil Cooler Oil Filter Rectifier-Regulator Fuel Pump Electric S tarter Oil Cooler Dip stick Side Oil Dr ...
-
Kohler CH18-26 - page 5
5 Refer to “Maintenance Instructions” beginning on p age 8 for detailed oil check, oil change, and oil filter change procedures. Fuel Recommendations W ARNING: Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated, unoccupied buildings, away from spa ...
-
Kohler CH18-26 - page 6
6 Engine Identification Numbers When ordering parts, or in any communication involving an engine, always give the Model, Specification, and Serial Numbers of the engine. The engine identification numbers appear on a decal affixed to the engine shrouding. Include letter suf fixes, if there are any . Record your engine identification numbers on the i ...
-
Kohler CH18-26 - page 7
7 flywheel is rotating, the starter pinion and flywheel ring gear may clash resulting in damage to the st arter . If the starter does not turn the engine over , shut off starter immediately . Do not make further attempts to start the engine until the condition is corrected. Do not jump start using another battery (refer to “Battery” on this pag ...
-
Kohler CH18-26 - page 8
8 Refer to the operating instructions of the equipment this engine powers. Because of equipment design or application, there may be more stringent restrictions regarding the angle of operation. NOTE: D o n o t operate this engine continuously at angles exceeding 25° in any direction. Engine damage could result from insufficient lubrication. Coolin ...
-
Kohler CH18-26 - page 9
9 Change Oil and Filter , Service Oil Cooler Change Oil Change oil after every 100 hours of operation (more frequently under severe conditions). Refill with service class SG , SH, SJ or higher oil as specified in the ‘‘V iscosity Grades’’ table (Figure 3) on p age 5. Change the oil while the engine is still warm. The oil will flow more free ...
-
Kohler CH18-26 - page 10
10 Service Oil Cooler Some engines are equipped with an oil cooler . One style of oil cooler mounts on the engine crankcase and has the oil filter on it (See Figure 8). The other style of oil cooler is mounted on the blower housing (See Figure 9), separate from the oil filter . Inspect and clean the oil cooler every 100 hours of operation (more fre ...
-
Kohler CH18-26 - page 11
11 4. Do not wash the paper element or use pressurized air , as this will damage the element. Replace a dirty , bent, or damaged element with a genuine Kohler element. Handle new elements carefully; do not use if the sealing surfaces are bent or damaged. 5. When servicing the air cleaner , check the air cleaner base. Make sure it is secured and not ...
-
Kohler CH18-26 - page 12
12 Clean Air Intake/Cooling Areas T o ensure proper cooling, make sure the grass screen, cooling fins, and other external surfaces of the engine are kept clean at all times . Every 100 hours of operation (more often under extremely dusty , dirty conditions), remove the blower housing* and other cooling shrouds. Clean the cooling fins and external s ...
-
Kohler CH18-26 - page 13
13 Fuel Filter Carbureted Engines: Most engines are equipped with an in-line fuel filter . Periodically inspect the filter and replace with a genuine Kohler filter every 200 operating hours . EFI Engines: A special, high volume, high pressure filter with greater filtration capabilities and internal surface area is used. See Figure 15. Figure 14. Se ...
-
Kohler CH18-26 - page 14
14 Figure 16. Carburetor (CH18-25,CH730,740). T roubleshooting If engine troubles are experienced that appear to be fuel system related, check the following areas before adjusting the carburetor . • Make sure the fuel tank is filled with clean, fresh gasoline. • Make sure the fuel tank cap vent is not blocked and that it is operating properly . ...
-
Kohler CH18-26 - page 15
15 T roubleshooting When troubles occur , be sure to check the simple causes which, at first, may seem too obvious to be considered. For example, a starting problem could be caused by an empty fuel t ank. Some common causes of engine troubles are listed in the following table. Do not attempt to service or replace major engine components, or any ite ...
-
Kohler CH18-26 - page 16
16 Storage If the engine will be out of service for two months or more, use the following storage procedure: 1. Clean the exterior surfaces of the engine. On EFI engines, avoid spraying water at the wiring harness or any of the electrical components. 2. Change the oil and filter while the engine is still warm from operation. See “Change Oil and O ...
-
Kohler CH18-26 - page 17
17 KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED W ARRANTY SMALL OFF-ROAD ENGINES The U.S. Environmental Protection Agency (EP A), the California Air Resources Board (CARB), and Kohler Co. are pleased to explai n the Federal and California Emission Control Systems W arranty on your small off-road equipment engine. For Californi ...
-
Kohler CH18-26 - page 18
18 (c) For warranty repairs, the engine must be presented to a Kohler Co. service center as soon as a problem exists. Call 1-800-54 4-2444 or access our website at: www .kohlerengines.com, for the names of the nearest service centers. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have any que ...
-
Kohler CH18-26 - page 19
ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 FOR SALES AND SERVICE INFORMA TION IN U.S. AND CANADA, CALL 1-800-544-2444 LITHO IN U.S.A. FORM NO.: 2 4 590 01 ISSUED: 1 1/04 REVISED: 1/05 MAILED: ...
Kohler CH18-26についてご質問がありますか？
次のフォームを使用してください
見つけた説明書を読んでもKohler CH18-26の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがKohler CH18-26で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。