Keating Of Chicago 24763の取扱説明書

26ページ 1.79 mb
ダウンロード

ページに移動 of 26

Summary
  • Keating Of Chicago 24763 - page 1

    KEEP THIS MANU AL FOR TRAINING NEW PERSONNEL 1-800-KEA TING www .keatingofchicago.com Part # 024763 Electric Pasta 0709 7/09 CUST OM P AST A ™ SYSTEM ELECTRIC SER VICE MANU AL ...

  • Keating Of Chicago 24763 - page 2

    i T his operating, inst allation, and service manual should be given to the user . T he operator of the Custom Past a ™ System should be familiar with the functions and operation of the cooker . T his manual must be kept in a prominent, easily reac hable location near the Past a System. P OST T H I S L AB E L I N A P R O M I N E NT LO C A T I O N ...

  • Keating Of Chicago 24763 - page 3

    T ABLE OF CONTENTS 1 SECTION I SPECIFICA TIONS . . . . . . . . . . . . . . 2 SECTION II INST ALLA TION Shipment and T ransit . . . . . . . . . . . . . . . . . . . . . . . .4 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 A. Positioning, Leveling, & Restraining Devices . .5 B. Electrical Connection . . . . . . . . ...

  • Keating Of Chicago 24763 - page 4

    2 I INTRODUCTION Instructions in this manual should be read thoroughly before attempting to operate this Keating Electric Pasta Cooker . All installation and service on Keating Equipment must be performed by qualified, certified, licensed and/or authorized installation or service personnel. Operating information for Keating equipment has been prepa ...

  • Keating Of Chicago 24763 - page 5

    SAFETY PRECAUTIONS THIS SYMBOL W ARNS YOU THA T SERIOUS BURNS OR OTHER INJURIES MA Y RESUL T IF SAFETY INSTRUCTIONS ARE NOT FOLLOWED. • This service manual should be retained in a safe place for future reference. The inst allation of your new Pasta System must conform to local codes and with the current National Electrical Codes and regulations a ...

  • Keating Of Chicago 24763 - page 6

    4 II INST ALLA TION This Custom Pasta ™ System MUST be installed, inspected, calibrated and serviced by qualified and/or certified and/or licensed service personnel – you may void your Keating warranty if installation is not completed per current local, national and Keating specifications. Contact your dealer for assistance. DAMAGE DURING SHIPM ...

  • Keating Of Chicago 24763 - page 7

    5 Push the fryer forward as far as it will go holding the fryer on approximately a 15° angle, and then drop the rear of the past a cooker into its proper position lowering it down gently so you do not deform the table or equipment stand. POSITIONING The past a cooker must be no closer than 6" from any combustible material. When placed under a ...

  • Keating Of Chicago 24763 - page 8

    6 In most cases the health department will not allow a direct connection between the cooker drain and the floor receptical. Contact your local health dep artment for specific information in your area. III OPERA TION FILLING   NOTE: Before filling the Past a System make certain the vessel is sanitized, dry and the drain valve is completely clo ...

  • Keating Of Chicago 24763 - page 9

    7 thermostat calls for additional heat at st art up or occasionally when water is added. Follow cooking procedures below for your model.   NOTE : Use of sodium chloride during the cooking process will have a detrimental ef fect on the cooker tank and will void the warranty .   OPERA TION OF THIS P AST A SYSTEM SHOULD BE LIMITED TO PERSO ...

  • Keating Of Chicago 24763 - page 10

    8 4. Fill Past a System vessel with water . See page 6 – Filling. UNDER NO CIRCUMST ANCES SHOULD THE P AST A SYSTEM BE LEFT UNA TTENDED DURING BOIL-OUT . TRAINED PERSONNEL MUST BE PRESENT DURING THE PROCEDURE TO PREVENT BOIL OVER OR T O TURN OFF THE POWER IF W A TER DROPS BELOW HEA T TRANSFER TUBES. 5. T urn Pasta System on and bring water to a g ...

  • Keating Of Chicago 24763 - page 11

    9 When the countdown has reached "00:00" the relay output contact s will open, the display will flash, and the audible alarm will sound. T o cancel the audible alarm, press any button. C. P AUSE FEA TURE T o pause a cycle in progress, press any button. The relay output contact s will open, the display will flash, and the countdown will p ...

  • Keating Of Chicago 24763 - page 12

    10 every calibration. Position near primary thermostat (center) bulb is recommended. 4. Pre-2000 model: If calibration of thermost at is found to be less than 15°F(9.44°C) off, simply loosen three dial plate retaining screws, rot ate dial plate to match thermometer reading and tighten screws. 2000-model: If calibration is found to be less than 15 ...

  • Keating Of Chicago 24763 - page 13

    V SER VICE DIAGNOSIS THE COOKER MUST BE DISCONNECTED FROM ITS POWER SOURCE OR SHUT DOWN A T THE BREAKER PRIOR TO SER VICE. AUTO-FILL SYSTEM The auto-fill system allows the automatic addition of water to the past a cooker during cooking or idle function. The system is controlled by the on/of f switch explained in CLEANING . If the system should fail ...

  • Keating Of Chicago 24763 - page 14

    12 COMMON PROBLEMS SOLUTIONS (FOLLOW IN SEQUENCE) W ater always filling 1. Clean sensors thoroughly with brush and vinegar . 2. Adjust the sensitivity of the B Board (for the top sensor) fully clockwise. 3. If filling persists, ground out the top sensor (if filling stops, replace sensor – Part #010212). 4. If filling persists after grounding the ...

  • Keating Of Chicago 24763 - page 15

    PROBLEM PROBABLE CAUSE SOLUTION Pasta Cooker has poor recovery or runs cold. a. Over-filling baskets. b.Thermostat out of calibration. c. Element is faulty . d. Thermostat is faulty . e. Contactor is faulty . a. Don’t overfill baskets. b. Calibrate thermostat. See pages 9-10 - Calibration. c. Replace element. d. Replace thermostat. e. Replace con ...

  • Keating Of Chicago 24763 - page 16

    VI P ARTS LIST 14 ITEM # DESCRIPTION QTY P ART # 1 INDICA TING LIGHT , AMBER, POWER ON 1 031624 2 TOGGLE SWITCH– MAIN ON-OFF 2 004499 3 INDICA TING LIGHT , GREEN, THERMOST A T HEA TING 2 010682 4 INDICA TING LIGHT , W A TER FILLING 1 009256 5 MANUAL W A TER FILL BUTT ON 1 004304 NUT WITH BOOT 1 009389 6 DIGIT AL TIMERS 2 056921 14" BASKET LI ...

  • Keating Of Chicago 24763 - page 17

    15 P ARTS LIST FOR CUSTOM P AST A SYSTEM ™ ITEM DESCRIPTION MODELS P ART # 14 18 20 24 1 HEA TING ELEMENT 220V 6500W 14" ONL Y 018668 2 1 HEA TING ELEMENT 220V 6000W 18" & 20" ONL Y 004353 3 3 1 HEA TING ELEMENT 220V 6000W 24” ONL Y 004355 4 (SEE DET AIL - QUANTITIES ARE PER ELEMENT ) B. W ASHER FLA T #10 059502 2222 C. W ASH ...

  • Keating Of Chicago 24763 - page 18

    16 VII WIRING DIAGRAMS 14" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS) (2) ...

  • Keating Of Chicago 24763 - page 19

    14" ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM 17 ...

  • Keating Of Chicago 24763 - page 20

    18 14" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL) ...

  • Keating Of Chicago 24763 - page 21

    19 14” ELECTRIC P AST A WITH BASKET -LIFT AND DIGIT AL TIMERS WIRING DIAGRAM ...

  • Keating Of Chicago 24763 - page 22

    20 18" & 20" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL) ...

  • Keating Of Chicago 24763 - page 23

    21 18" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS) ...

  • Keating Of Chicago 24763 - page 24

    22 24” ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM ...

  • Keating Of Chicago 24763 - page 25

    L IMITED W ARRANTY Keating Of Chicago, Inc. ("Keating”) warrants to the original purchaser . ("Customer"), all new Keating Fryers, Filter Systems, Griddles, Keep Krisp®, Custom Pasta Systems, T op-Side™ Cookers, Computer T imers, Fryer & Pasta V essels, and Keating replacement parts ("products") installed after Jun ...

  • Keating Of Chicago 24763 - page 26

    K EA TI N G LI M ITE D W AR RANTY C AR D PLEASE C OM PLETE AN D MAI L A T O NC E–W AR RANTY IS NOT IN E F FE C T U NTI L C AR D I S RETU R N E D. W AR RANTY CARD I S AL S O A V AI LAB LE T O C OM P LETE ON LI N E A T Y OU R C ONVE NIENC E . CO M P ANY: _______________________________________________________________________________________________ ...

メーカー Keating Of Chicago カテゴリー Pasta Maker

Keating Of Chicago 24763のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 24763の取扱説明書
- Keating Of Chicagoの製品カード
- パンフレット
- またはKeating Of Chicago 24763の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Keating Of Chicago 24763の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Keating Of Chicago 24763の取り付け説明書、サービスマニュアル、簡易説明書、またはKeating Of Chicago 24763のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Keating Of Chicago 24763の製品を使用するにあたって最も人気のある説明書を閲覧できます。

Keating Of Chicago 24763デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがKeating Of Chicago 24763を使用するのを助ける技術的文書のことです。説明書は通常、全てのKeating Of Chicago 24763ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Keating Of Chicagoの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Keating Of Chicago 24763の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははKeating Of Chicago 24763の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Keating Of Chicago 24763に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Keating Of Chicago 24763デバイスの基本機能を使うにあたってのヒント。 Keating Of Chicago 24763のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Keating Of Chicago 24763に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるKeating Of Chicago 24763のメーカー/サービスへの連絡先に関する情報。

Keating Of Chicago 24763についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもKeating Of Chicago 24763の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがKeating Of Chicago 24763で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)