Raypak RHP100の取扱説明書

19ページ 1.47 mb
ダウンロード

ページに移動 of 19

Summary
  • Raypak RHP100 - page 1

    Raypak ® RHP Series Swimming Pool and Spa Heat Pump OWNER and INST ALLA TION MANUAL This manual should be maint ained in legible condition and kept adjacent to the heat pump or in a safe place for future use. For additional information call: ( 800) 260-2758 Manual Effective Date: 3/1/20 03 Replaces: All Previous V ersions De ve lo pe d a nd pr in ...

  • Raypak RHP100 - page 2

    i PRODUCT SAFETY SIGNS AND LABE LS This manual, as well as the pool/spa heat pum p itself, contains ANSI-approved product safety signs and labels. Please read these signs and labe ls, as they convey important safety information about hazards that may be potentially present in and around the heat pump. They are classified according to relative serio ...

  • Raypak RHP100 - page 3

    ii RHP Series Swimming Pool and Spa Heat Pump OWNER and INST ALLA TION MANUAL CONTENTS Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 I. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Raypak RHP100 - page 4

    1 Intr oduction This pool/sp a heat pump is an electromechanical m achine that incorporates a pressurized refrigerant gas in a sealed system. ONL Y trained and qualified service personnel should attem pt to install or servic e this equipment. Without proper training a nd knowledge of such equipment, any attempt to inst all or service the unit could ...

  • Raypak RHP100 - page 5

    2 • Each side of the unit must be lo cated at least 1 ft fr om walls, pipes, or other obstructions for unrestricted air intake and service access. Do not inst all the unit within 3 f t of fossil fuel burning heaters. Air int ake along the sides of this heat pump co uld disturb the combustion process of the unit, and could cause damage or personal ...

  • Raypak RHP100 - page 6

    3 III. W ater Connections The heat pump inlet and outlet connection s are NOT interchangeable. They must be connected as inst ructed below . 1. Connect the heat pump in the return water li ne between the pool filt er and the pool. See page 10, Plumbing Diagrams. 2. Connect the filter outlet to the fitting marked WA T E R I N at the bottom front of ...

  • Raypak RHP100 - page 7

    4 Indicator Lamps : There are 6 indicator lamps located on the unit control panel: • Power (amber lamp): When lit, indicates power is applied to the unit. NOTE: The heat pump will not run whe n the Remote position is selected and there is no remote control system attached. • W ater Flow (green lamp): When lit, indicates normal water flow . • ...

  • Raypak RHP100 - page 8

    5 NOTE: The heat pump wi ll be OFF when the Remote position is selected on th e Pool/Sp a selector switch and there is no remote con trol system att ached. 4.Allow the heat pump to op erate for a few minutes to stabilize operating pressure s and to allow various component temperatures to normalize. 5. V erify that the discharge air temperature is a ...

  • Raypak RHP100 - page 9

    6 VIII. Summer Shutdown If you do not plan to use the pool heat pump duri ng the summer months, secure and protect it as follows: 1. From the control panel, tu rn the contr ol switch to Remote (OFF). 2. T urn the heat pump circuit break er or disconnect switch to OFF . 3. Leave the valves set the way they are unless additional circulation is requir ...

  • Raypak RHP100 - page 10

    7 2. B. Cabinet Care (optional) - The cabinet is designed for outdoor use and require s little care. However , you can clean it if you wish. 1. 2. W ash the cabinet with soap and water . C. Condensate Drainage - The heat pump extracts humidity from the air as it passes through the coil, similar to the way a cold drink outside “swe ats” on a hot ...

  • Raypak RHP100 - page 11

    8 operation. After the desired temper ature is reached, return the system to normal operation of 8-10 hours per day . • Is airflow through the unit being obstructed? Restri ctions such as shrubbe ry , tall grass, dirty coils, or any other obstruction to airflow will reduce performance. • Is the pool blanket/cover bei ng used? Unblanketed pools ...

  • Raypak RHP100 - page 12

    9 POWER SUPPL Y • V erify that all circ uit breakers are reset and working properly . •I f t h e Power lamp on the control pane l still does not light, cont act the installing dealer , since it may be a power probl em requiring an electrician. WAT E R F L O W • V erify that the filter is clean to provide good flow . • V erify that the valve ...

  • Raypak RHP100 - page 13

    10 Plumbing Diagrams For systems with p umps of less than 2 HP (under 80 gpm) , no external bypass is required. Connections are 2 -inch pipe slip. Plumb the heat pump after the filter and before any chlorinators. Wa t er I n (from pool or S pa) Wa t er O u t (to pool or S pa) Filter For systems with pum p s of 2 HP or greate r (over 80 gpm), an ext ...

  • Raypak RHP100 - page 14

    11 Heat Pump Schematic 12 34 A B C D 4 3 2 1 D C B A Title Number Revision Size A Date: 27-Jan-2003 Sheet of File: C:Pool FactPoofactPoofact.ddb Drawn By: 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 TB1 Control Panel Interface D4 Delay Active D5 Active D6 Pressure D1 Power D2 Wat er Fl ow D3 Heat Demand R1 Spa R2 Pool K1 Conta ...

  • Raypak RHP100 - page 15

    12 Contr ol Panel Assembly Replacement Parts List 12 4 7 13 11 10 16 11 9 15 2 5 8 14 3 6 1 ITEM QTY DESCRIPTION PART No. 1 1 Control Panel 83-10002 2 1 Contactor Compressor 54-10002 3 1 Fan Relay 50-10010 4 1 Control Board 24Volt 50-10007 5 1 Thermostat 50-10003 6 1 Transformer 50-10014 7 1 Timer IMC 203 55-10011 8 1 Capacitor 55-10003 9 1 Pressur ...

  • Raypak RHP100 - page 16

    13 Contr ol Panel Cover Assemb ly Replacement Parts List 1 4 4 4 7 6 7 6 8 8 5 Front ITEM QTY DESCRIPTION PART No. 1 1 Control Panel Cover 81-30152 2 2 POT 50-10004 3 1 Switch Type A403 50-10005 4 3 Knob 56-10001 5 1 Label Control Panel 84-10017 6 2 Lamp Green 53-10001 7 2 Lamp Red 53-10003 8 2 Lamp Amber 53-10002 2 3 2 RHP Control Panel Cover 1 Ba ...

  • Raypak RHP100 - page 17

    14 Heat Pump Assembly Re placement Parts List - RHP 100 11 15 13 12 5 9 18 2 7 7 7 6 8 1 4 10 3 17 14 9 19 RHP 100 16 0207 *See assembly drawing in this manual ITE M QT Y DESCRIPTION PART No. 1 1 Assembly Base 8 1- 20140 2 1 E vaporator Coil 40-10002 3 1 Access Panel 81 - 50141 4 1 Power Input Panel 81-40151 5 1 Co ver, Top 81-10140 6 1 Compressor, ...

  • Raypak RHP100 - page 18

    15 Heat Pump Assembly Re placement Parts List - RHP 1 15 11 15 13 12 5 9 2 9 16 7 7 18 14 6 7 3 17 19 4 10 1 8 RHP 115 *See assembly drawing in this manual ITEM QTY DESCRIPTION PART No. 1 1 Assembly Base 8 1- 20 14 0 2 1 E v aporator Coil 40-10002 3 1 Ac ce ss P an el 81-50141 4 1 Power Input Panel 81-40151 5 1 Cover, Top 81 -10 140 6 1 Compressor, ...

  • Raypak RHP100 - page 19

    16 11 12 15 13 18 9 2 16 9 7 7 7 6 8 1 4 3 17 14 10 19 5 *See assembly drawing in this manual RHP 160 ITE M QTY DESCRIPTION PART No. 1 1 Assembly Base 8 1- 20 14 0 2 1 E vaporator Coil 40-10003 3 1 Access Panel 81- 50 14 2 4 1 Power Input Panel 81-4015 2 5 1 Cover, Top 81-1 0140 6 1 Compressor, Scroll 30- 1000 3 7 3 Corner Support 81-60152 8 1 Heat ...

メーカー Raypak カテゴリー Swimming Pool Pump

Raypak RHP100のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- RHP100の取扱説明書
- Raypakの製品カード
- パンフレット
- またはRaypak RHP100の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Raypak RHP100の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Raypak RHP100の取り付け説明書、サービスマニュアル、簡易説明書、またはRaypak RHP100のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Raypak RHP100の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Raypak RHP100デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがRaypak RHP100を使用するのを助ける技術的文書のことです。説明書は通常、全てのRaypak RHP100ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Raypakの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Raypak RHP100の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははRaypak RHP100の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Raypak RHP100に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Raypak RHP100デバイスの基本機能を使うにあたってのヒント。 Raypak RHP100のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Raypak RHP100に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるRaypak RHP100のメーカー/サービスへの連絡先に関する情報。

Raypak RHP100についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもRaypak RHP100の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがRaypak RHP100で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)