Wagner SprayTech 295000の取扱説明書

40ページ 5.41 mb
ダウンロード

ページに移動 of 40

Summary
  • Wagner SprayTech 295000 - page 1

    English Français Español 1299 © 1999 SprayTECH Corporation. All rights reserved. Form No. 0295627A Printed in the U. S. A. EP2005 P ist on P ump Owner’s Manual • Notic e d’utilisation • Manual del Propiet ario SprayTECH 1770 Fernbrook Lane Minneapolis, MN 55447 T echnical Assistance: 1-800-292-4637 Order Entry: 1-800-443-4500 Fax: 1-800- ...

  • Wagner SprayTech 295000 - page 2

    English T able of Contents General Description ................................................................2 Safety Precautions ..................................................................2 Grounding Instructions ..........................................................3 Extension Cord Selection .......................................... ...

  • Wagner SprayTech 295000 - page 3

    English HAZARD: EXPLOSION OR FIRE - Solvent and paint fumes can explode or ignite, causing property damage and/or severe injury . PREVENTION: • Exhaust and fresh air introduction must be provided to keep the air within the spray area free from accumulation of flammable vapors. • Avoid all ignition sources such as static electricity sparks, open ...

  • Wagner SprayTech 295000 - page 4

    English Extension Cord Selection If an extension cord is used, make sure that it is of the 3- conductor type with NEMA connectors so a continuous grounding circuit is provided from the tool to the power circuit receptacle. Also, be sure that the conductor size is large enough to prevent excessive voltage drop which will cause loss of power and poss ...

  • Wagner SprayTech 295000 - page 5

    English Purging and Priming for Solvent-Based Paint Thorough cleaning is not necessary when using solvent-based paint. All you need to do is purge the test fluid from the system. 1. Secure the return hose into a waste container . 2. Place a full container of paint under the suction tube. 3. Turn the pressure control knob fully counterclockwise to r ...

  • Wagner SprayTech 295000 - page 6

    English Spraying Spraying T echnique The key to a good paint job is an even coating over the entire surface. This is done by using even strokes. Keep your arm moving at a constant speed and keep the spray gun at a constant distance from the surface. The best spraying distance is 10 to 12 inches between the spray tip and the surface. Keep the spray ...

  • Wagner SprayTech 295000 - page 7

    English Always spray at minimum pressure with the gun nozzle tip removed when using mineral spirits or any other solvent to clean the pump, hose, or gun. Static electricity buildup may result in a fire or explosion in the presence of flammable vapors. Flushing the Unit Flush the unit with the solvent appropriate to the material being used after dai ...

  • Wagner SprayTech 295000 - page 8

    English Replacing the T -lip Packings 1. Apply a light coat of household oil to the new lower T -lip packing and insert it edge-first into the lower end of the fluid section. 2. Turn the T -lip packing inside the fluid section cylinder so that the springs of the T -lip packing face into the cylinder . T o do this, hold the lower edge of the T -lip ...

  • Wagner SprayTech 295000 - page 9

    English Cleaning the Spray Ti p 1. Flush the gun with solvent immediately after the work is completed. 2. Oil the sliding pins to prevent them from seizing up. Should the spray tip become clogged, reverse the spray tip with the lever and pull the trigger . Once the obstruction comes out of the spray tip, release the trigger , reverse the spray tip ...

  • Wagner SprayTech 295000 - page 10

    T roubleshooting English 10 © SprayTECH Corporation. All rights reserved. Problem The unit will not run. The unit will not prime. The unit will not build or maintain pressure. Fluid leakage at the upper end of the fluid section. Poor spray pattern. The unit lacks power . Blown fuses at the pump. Cause 1. Blown panel fuse or tripped breaker . 2. Th ...

  • Wagner SprayTech 295000 - page 11

    English © SprayTECH Corporation. All rights reserved. 11 Limited W arranty Commercial Airless Spray Equipment T wo Y ear W arranty Spray T ech, a division of W agner Spray T ech Corporation ("Spray T ech"), warrants this product against defects in material and workmanship for a period of two years following the date of purchase by the or ...

  • Wagner SprayTech 295000 - page 12

    Fran ç ais T able des mati è res Introduction ...........................................................................12 S é curit é ..................................................................................12 Instructions de mise à la terre .............................................13 Choix d'une rallonge .................. ...

  • Wagner SprayTech 295000 - page 13

    Fran ç ais DANGER: RISQUES D'EXPLOSION OU D'INCENDIE - Les vapeurs d é gag é es par le solvant ou la peinture sont explosives et inflammables et peuvent causer des dommages mat é riels ou corporels s é rieux. MESURES PR é VENTIVES: • V eiller à é viter toute accumulation de vapeurs inflammables en vous assurant que la zone o ù ...

  • Wagner SprayTech 295000 - page 14

    Fran ç ais Choix d'une rallonge S'il est n é cessaire d'utiliser une rallonge, v é rifiez qu'elle soit munie de 3 broches et de connecteurs NEMA afin qu'un circuit de mise à la terre continu soit é tabli entre l'appareil et la prise du circuit d'alimentation. Il faut é galement que le conducteur soit d' ...

  • Wagner SprayTech 295000 - page 15

    Fran ç ais Vidange et amor ç age pour peinture à base de solvant Un nettoyage complet n'est pas n é cessaire pour l'utilisation de peinture à base de solvant. Seule la purge du fluide d'essai de l'appareil est n é cessaire. 1. Placez l'extr é mit é du flexible de retour dans un r é cipient r é cup é ration. 2. Pl ...

  • Wagner SprayTech 295000 - page 16

    Fran ç ais Pulv é risation T echnique de pulv é risation Pour obtenir une peinture d'un fini impeccable il est essentiel que le produit soit é galement r é parti sur toute la surface. Il faut pour cela que vous appliquiez la peinture de fa ç on r é guli è re en d é pla ç ant votre bras à vitesse constante et en gardant le pistolet d ...

  • Wagner SprayTech 295000 - page 17

    Fran ç ais TOUJOURS pulv é riser à la pression minimale et en ayant eu soin de retirer la t ê te de pulv é risation lorsque vous utilisez de l'essence min é rale ou tout autre solvant pour nettoyer la pompe, le flexible ou le pistolet. Ceci afin d' é viter une accumulation d' é lectricit é statique qui risquerait de d é cle ...

  • Wagner SprayTech 295000 - page 18

    Fran ç ais Remplacement des joints à bord en T 1. Appliquez un mince film d'huile domestique sur le nouveau joint à bord en T inf é rieur et ins é rez-le verticalement dans l'extr é mit é inf é rieure du compartiment à liquide. 2. Faites pivoter le joint à bord en T dans le cylindre du compartiment à liquide de fa ç on à ce q ...

  • Wagner SprayTech 295000 - page 19

    Fran ç ais 12. Ins é rez la coude sur le dispositif de succion en le fond du logement de la soupape d'aspiration. 13. Poussez le bague de retenue en l'int é rieur de cannelure du logement de la soupape d'aspiration fixer le dispositif de succion dans la position. Nettoyage de la t ê te de pulv é risation 1. Purgez le pistolet av ...

  • Wagner SprayTech 295000 - page 20

    20 © SprayTECH Corporation. T ous droits r é serv é s. Fran ç ais En cas de probl è me Probl è me L'appareil ne d é marre pas. Impossible d'amorcer l'appareil. L'appareil ne se met pas, ou ne reste pas, sous pression. Du liquide s' é chappe de l'extr é mit é sup é rieure du compartiment à liquide. Mauvaise ...

  • Wagner SprayTech 295000 - page 21

    Fran ç ais © SprayTECH Corporation. T ous droits r é serv é s. 2 1 Garantie limit é e Equipement commercial de pulv é risation sans air Garantie de deux ans Spray T ech, une division de W agner Spray T ech Corporation ("Spray T ech") garantit ce produit contre les d é fauts de mati è re et de main-d'oeuvre pour une p é riode ...

  • Wagner SprayTech 295000 - page 22

    Espa ñ ol Í ndice Descripci ó n general ..............................................................22 Seguridad ...............................................................................22 Instrucciones para conectar a tierra ....................................23 Selecci ó n de la extensi ó n........................................... ...

  • Wagner SprayTech 295000 - page 23

    Espa ñ ol PELIGRO: EXPLOSI Ó N O INCENDIO - Los vapores de solventes y pintura pueden explotar o incendiarse, causando con esto da ñ os en la propiedad y/o lesiones severas. P ARA PREVENIR: • Debe proveerse un escape y aire fresco para hacer que el aire que est á dentro del á rea de atomizaci ó n se mantenga libre de acumulaciones de vapore ...

  • Wagner SprayTech 295000 - page 24

    Espa ñ ol Selecci ó n de la extensi ó n Si se usa una extensi ó n, aseg ú rese de que é sta sea del tipo de 3 conductores con conectadores autorizados por la Asociaci ó n de Fabricantes de Productos Electrot é cnicos (NEMA por sus siglas en ingl é s) de manera que se tenga un circuito de conexi ó n a tierra continuo, de la herramienta al ...

  • Wagner SprayTech 295000 - page 25

    Espa ñ ol Purgaci ó n y cebadura para usar pintura a base de solvente No ser á necesario limpiar perfectamente cuando se use pintura a base de solvente. T odo lo que necesita hacer es extraer el fluido de prueba del sistema. 1. Asegure la manguera de retorno dentro del recipiente de desperdicios. 2. Ponga un recipiente lleno de pintura debajo de ...

  • Wagner SprayTech 295000 - page 26

    Espa ñ ol Para atomizar T é cnica para atomizar La clave para lograr un buen trabajo de pintura consiste en aplicar un revestimiento uniforme a trav é s de toda la superfice. Esto se logra empleando descargas uniformes. Mantenga el brazo movi é ndose a una velocidad constante y la pistola de atomizaci ó n a una distancia de la superficie tambi ...

  • Wagner SprayTech 295000 - page 27

    Espa ñ ol Atomice SIEMPRE a la presi ó n m í nima y sin que la boquilla de la pistola est é puesta cuando utilice solventes derivados del petr ó leo o cualquier otro solvente para limpiar la bomba, manguera o pistola. La electricidad est á tica acumulada podr í a ocasionar un incendio o una explosi ó n al haber presentes vapores inflamables ...

  • Wagner SprayTech 295000 - page 28

    Espa ñ ol Para reemplazar las empaquetaduras con borde en forma de T 1. Aplique una ligera capa de aceite casero en la nueva empaquetadura con borde en forma de T e introd ú zcala verticalmente dentro del extremo inferior de la secci ó n de fluido. 2. Gire la empaquetadura con borde en forma de T que est á dentro del cilindro de la secci ó n d ...

  • Wagner SprayTech 295000 - page 29

    Espa ñ ol 4. Inserte el pasador a trav é s de la culata y el pist ó n. 5. Ajuste a presi ó n el broche de retenci ó n alrededor del pasador y la culata. 6. Atornille la secci ó n de fluido en la caja de la bomba tanto como sea posible, y despu é s desatorn í llela ligeramente para que el adaptador de la manguera de fluido se alinee con la m ...

  • Wagner SprayTech 295000 - page 30

    3 0 © SprayTECH Corporation. T odos los derechos reservados. Espa ñ ol Detecci ó n de problemas Problema La unidad no funciona. La unidad no ceba. La unidad no acumula presi ó n o no la mantiene. Una fuga de fluido en el extremo superior de la secci ó n de fluido. Patr ó n de atomizaci ó n deficiente. Le falta potencia a la unidad. Los fusib ...

  • Wagner SprayTech 295000 - page 31

    Espa ñ ol © SprayTECH Corporation. T odos los derechos reservados. 3 1 Garant í a Limitada Equipo Rociador Comercial Sin Aire Garant í a de Dos A ñ os Spray T ech, una division de W agner Spray T ech Corporation ("Spray T ech"), garantiza este producto contra defectos de materiales y de fabricaci ó n por un per í odo de dos a ñ os ...

  • Wagner SprayTech 295000 - page 32

    English 32 © SprayTECH Corporation. All rights reserved. Fran ç ais Espa ñ ol Parts List • Liste des pi è ces • Lista de piezas Main Assembly • Dispositif de principale • Conjunto del principal S P R A Y P R IM E 1 2 3 5 6 4 7 9 8 11 10 12 Item Part # Description Quantity 1 ----------- Drive assembly .................................... ...

  • Wagner SprayTech 295000 - page 33

    English Fran ç ais © SprayTECH Corporation. All rights reserved. 33 Espa ñ ol Espa ñ ol Art í culo Pieza # Descripci ó n Cantidad 1 ----------- Conjunto del impulsor ...........................1 2 0295628 Cubierta ................................................1 3 0295226 Conjunto del equipo de succi ó n ...........1 4 13549 Manguera de flu ...

  • Wagner SprayTech 295000 - page 34

    English 34 © SprayTECH Corporation. All rights reserved. Fran ç ais Espa ñ ol Drive Assembly • Dispositif de entra î nement • Conjunto del impulsor 1 10 9 11 12 13 14 15 16 17 18 19 21 20 19 18 22 23 24 25 26 27 28 2 3 4 5 6 7 8 ...

  • Wagner SprayTech 295000 - page 35

    English Fran ç ais © SprayTECH Corporation. All rights reserved. 35 Espa ñ ol Espa ñ ol Item Part # Description Quantity 1 0295123 Handle with grip ....................................1 2 9800339 Screw ....................................................4 3 9821515 Lock washer ..........................................4 4 0295301 Housing ...... ...

  • Wagner SprayTech 295000 - page 36

    English 36 © SprayTECH Corporation. All rights reserved. Fran ç ais Espa ñ ol Pressure Control Assembly • Dispositif de r é glage de la pression • Conjunto del control de la presi ó n (P/N 0295234) Item Part # Description Quantity 1 0295426 Pressure control knob ...........................1 2 9822522 Retaining ring......................... ...

  • Wagner SprayTech 295000 - page 37

    English Fran ç ais © SprayTECH Corporation. All rights reserved. 37 Espa ñ ol Fluid Section Assembly • Compartiment liquide • Conjunto de la secci ó n de fluido (P/N 0295229) Item Part # Description Quantity 1 00302 Locknut .................................................1 2 0294319 Packing nut (torque tp 25-30 ft./lbs.) ....1 3 0295308 Up ...

  • Wagner SprayTech 295000 - page 38

    English 38 © SprayTECH Corporation. All rights reserved. Fran ç ais Espa ñ ol Spray Gun • Pistolet • Pistola de atomizaci ó n (P/N 0295666) Item Part # Description Quantity 1 0295664 Tip assembly , 515 ...................................1 2 0149342 Diffuser ...................................................1 3 0149366 Trigger guard ....... ...

  • Wagner SprayTech 295000 - page 39

    English Fran ç ais © SprayTECH Corporation. All rights reserved. 39 Espa ñ ol PRIME/SPRA Y V alve Assembly • V alve amor ç age/pulv é risation • Conjunto de la v á lvula de Cebar/Atomizar (P/N 0295905) Item Part # Description Quantity 1 0281316 Seat assembly (torque to 10-12 ft./lbs.). ..1 2 0090523 O-ring ................................ ...

  • Wagner SprayTech 295000 - page 40

    English 40 © SprayTECH Corporation. All rights reserved. Fran ç ais Espa ñ ol T ransducer Assembly • T ransducteur • Conjunto del transductor (P/N 0295902) Item Part # Description Quantity 1 9871056 O-ring ....................................................1 2 ---------- T ransducer body ...................................1 3 0295902 Transd ...

メーカー Wagner SprayTech カテゴリー Paint Sprayer

Wagner SprayTech 295000のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 295000の取扱説明書
- Wagner SprayTechの製品カード
- パンフレット
- またはWagner SprayTech 295000の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Wagner SprayTech 295000の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Wagner SprayTech 295000の取り付け説明書、サービスマニュアル、簡易説明書、またはWagner SprayTech 295000のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Wagner SprayTech 295000の製品を使用するにあたって最も人気のある説明書を閲覧できます。

Wagner SprayTech 295000デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWagner SprayTech 295000を使用するのを助ける技術的文書のことです。説明書は通常、全てのWagner SprayTech 295000ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Wagner SprayTechの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Wagner SprayTech 295000の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWagner SprayTech 295000の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Wagner SprayTech 295000に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Wagner SprayTech 295000デバイスの基本機能を使うにあたってのヒント。 Wagner SprayTech 295000のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Wagner SprayTech 295000に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWagner SprayTech 295000のメーカー/サービスへの連絡先に関する情報。

Wagner SprayTech 295000についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWagner SprayTech 295000の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWagner SprayTech 295000で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)