-
Graco 204500 - page 1
Instructions–Parts List 306563K ENG Important Safety Instructions Read all warnings and instructions in this manual. Save these instructions. LOW PRESSURE Fluid Regulator For accurate, positive control of fluid pressure to one spray gun, dispensing valve, or atomizing head. For professional use only . 250 psi (18 bar , 1.8 MPa) Maximum Inbound Pr ...
-
Graco 204500 - page 2
2 306563 T able of Contents W arnings 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Installation 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Operation 6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . T roubleshooting 7 . . . . . . . . . . . . . . . . . . . . ...
-
Graco 204500 - page 3
3 306563 W ARNING SKIN INJECTION HAZARD Spray from the gun, leaks or ruptured components can inject fluid into your body and cause extremely serious injury , including the need for amputation. Fluid splashed in the eyes or on the skin can also cause serious injury . D Fluid injected into the skin is a serious injury . The injury may look like just ...
-
Graco 204500 - page 4
4 306563 W ARNING FIRE AND EXPLOSION HAZARD Improper grounding, poor ventilation, open flames or sparks can cause a hazardous condition and re- sult in a fire or explosion and serious injury . D If there is any static sparking or you feel an electric shock while using this equipment, stop spray- ing immediately. Do not use the equipment until you i ...
-
Graco 204500 - page 5
5 306563 Installation F E A C G D H B A B C D E F G H Regulator Dispensing Unit Gauge Regulator Inlet Regulator Outlet Air Regulator Supply Line Accessory Outlet KEY Fig. 1 03363 TYPICAL INST ALLA TION CAUTION Before installing the regulator , check the tightness of the screws (1). Refer to Fig. 3 for the tightening sequence and the torque value. I ...
-
Graco 204500 - page 6
6 306563 Operation W ARNING T o reduce the risk of component rupture, which can cause a fire or explosion and result in serious bodily injury , including splashing in the eyes, never exceed 250 psi (18 bar , 1.8 MPa) Maximum Inbound Fluid Pressure to this regula- tor . CAUTION Do not pressure test the regulator with air; use solvent. Air may cause ...
-
Graco 204500 - page 7
7 306563 T roubleshooting Problem Cause Solution No pressure regulation Damaged diaphragm Replace diaphragm (31). Fluid leaks under cap Loose cap, worn gasket T ighten screws (1), replace gasket (32). Damaged diaphragm Replace diaphragm (31). Pressure creeps above setting Loose cap T ighten screws (1). Worn gasket Replace gasket (32). Damaged diaph ...
-
Graco 204500 - page 8
8 306563 Service Regulator Disassembly Shut off pump, close shutof f valve and relieve pressure in regulator by triggering the spray gun. Remove the regulator from the system. 1. Using the hex end of key (25), adjust screw (20) all the way counterclockwise to relieve regulator spring tension. 2. Remove outlet bushing (15) and counter-balance spring ...
-
Graco 204500 - page 9
9 306563 Notes ...
-
Graco 204500 - page 10
10 306563 Parts 03374 Fig. 4 1 3 4 2 25 1 1 17 34 4 3 20 2 2 12 13 30 10 21 9 31 3 32* 33* 28* 27* 16 14 2 *7 4 5 5 26 29 22* 15 19 See torque sequence in Fig. 3. Lubricate with grease. side down. Lubricate with oil. Apply sealant to threads. *5 4 11 T orque to 70–80 in-lb (8–9 N S m). 4 6 6 7 7 4 T orque to 30–35 ft-lb (41–47 N S m) PTFE ...
-
Graco 204500 - page 11
11 306563 Parts Ref No. Part N o. Description Qty . Ref No. Part No. Description Qty . 1 101682 SCREW , soc hd cap; 1/4–20 x 5/8 6 2 101754 PLUG, pipe; hex soc; 3/8 npt 1 3 101971 RACE, thrust; adjusting nut 1 4 101972 BEARING, needle thrust 1 5* 187875 GAUGE, fluid pressure; 0–30 psi (0–2 bar) (Model 204500 only) 1 101 180 GAUGE, fluid press ...
-
Graco 204500 - page 12
12 306563 The Graco W arranty and Disclaimers W ARRANTY Graco warrants all equipment listed in this manual which is manufactured by Graco and bearing its name to be free from defects in material and workmanship on the date of sale by an authorized Graco distributor to the original purchaser for use. Graco will, for a period of twelve months from th ...
Graco 204500についてご質問がありますか?
次のフォームを使用してください
見つけた説明書を読んでもGraco 204500の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがGraco 204500で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。