English dropdown-ico

Manual Alto-Shaam Oven / Steamer CT Express

31 pages 3.45 mb
Download

Go to site of 31

Summary
  • Alto-Shaam Oven / Steamer CT Express - page 1

    MN-29805 (R e v . 1) • 09/13 p r i n t e d i n u . s . a . Combitherm ® Combination Oven / Steamer CT EXPRESS™ 4•10es i 4•10esiVH 4•10CCi   • InstallatIon W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONe: 262.251.3800 • 800.558.8744 u s a / c a N a d a F a X : 2 6 2 . 2 5 1 . 7 0 6 ...

  • Alto-Shaam Oven / Steamer CT Express - page 2

    i Delivery .................................. 1 Unpacking ................................ 1 Safety Procedures and Precautions ............ 2 Installation Site Installation .......................... 3 Ventilation Requirements .................. 3 Positioning on Site ....................... 4 Lifting Instructions ....................... 5 Leveling ...

  • Alto-Shaam Oven / Steamer CT Express - page 3

       INSTALLATION MANUAL • MN-29805 • 1. DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportati ...

  • Alto-Shaam Oven / Steamer CT Express - page 4

       INSTALLATION MANUAL • MN-29805 • 2. CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard ...

  • Alto-Shaam Oven / Steamer CT Express - page 5

       INSTALLATION MANUAL • MN-29805 • 3. SITE INSTALLATION INSTALLATION DANGER IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY B ...

  • Alto-Shaam Oven / Steamer CT Express - page 6

       INSTALLATION MANUAL • MN-29805 • 4. NOTE: Note dimensions required for doorways and aisles for access of the oven and pallet to the installation site. Transport the oven in an upright and level position only. Do not tilt the oven. ® SITE INSTALLATION INSTALLATION POSITIONING ON SIT ...

  • Alto-Shaam Oven / Steamer CT Express - page 7

       INSTALLATION MANUAL • MN-29805 • 5. LIFTING INSTRUCTIONS INSTALLATION Remove banding before lifting. Lift the unit from either side of the unit, n e v e r f r o m t h e f r o n t o r b a c k . Adjust the forks so that they do not damage any of the components under the unit. Air inta ...

  • Alto-Shaam Oven / Steamer CT Express - page 8

       INSTALLATION MANUAL • MN-29805 • 6. SITE INSTALLATION INSTALLATION EXHAUST VENT 18" (46cm) 4" (102mm) 4" (102mm) 20" (50cm) MINIMUM 20" (50cm) POSITIONING REQUIREMENTS q In order to ensure proper ventilation, a minimum distance of at least 4-inches (101mm) m ...

  • Alto-Shaam Oven / Steamer CT Express - page 9

       INSTALLATION MANUAL • MN-29805 • 7. ACCESSORIES CombiClean® Tablets — CE-28892 s P e c i a l l y F O R M u l a t e d FOR c O M b i t H e R M O v e N s ➥ twO (2) c O N t a i N e R s / b O X , 90 P a c k e t s e a c H c O N t a i N e R Combitherm Cleaning Liquid — CE-24750 s P ...

  • Alto-Shaam Oven / Steamer CT Express - page 10

       INSTALLATION MANUAL • MN-29805 • 8. WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS ONE (1) COLD W A TER INLETS - DRINKING QUALITY ONE (1) W A TER INLET: 3/4" G* LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" connection WitH a 2" MiniMUM air Gap i ...

  • Alto-Shaam Oven / Steamer CT Express - page 11

       INSTALLATION MANUAL • MN-29805 • 9. WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS ONE (1) COLD W A TER INLETS - DRINKING QUALITY ONE (1) W A TER INLET : 3/4" G* LI NE PRE SS UR E: 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" C ON N EC T I ON W I TH A 2 " M I ...

  • Alto-Shaam Oven / Steamer CT Express - page 12

       INSTALLATION MANUAL • MN-29805 •  WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS ONE (1) COLD W A TER INLETS - DRINKING QUALITY ONE (1) W A TER INLET: 3/4" G* LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" connection WitH a 2" MiniMUM ai ...

  • Alto-Shaam Oven / Steamer CT Express - page 13

       INSTALLATION MANUAL • MN-29805 • 11. ELECTRICAL CONNECTION INSTALLATION DANGER ENSURE POWER SOURCE MATCHES VOLTAGE IDENTIFIED ON APPLIANCE RATING TAG. DANGER To avoid electrical shock, this appliance MUST be adequately grounded in accordance with local electrical codes or, in the ab ...

  • Alto-Shaam Oven / Steamer CT Express - page 14

       INSTALLATION MANUAL • MN-29805 • 12. ELECTRICAL CONNECTION INSTALLATION DANGER ELECTRICAL CONNECTIONS MUST BE MADE BY A QUALIFIED SERVICE TECHNICIAN IN ACCORDANCE WITH APPLICABLE ELECTRICAL CODES. INTERNAL GROUND STUD CUSTOMER MUST SUPPLY CORD INCOMING ELECTRICAL TERMINALS APPLIES T ...

  • Alto-Shaam Oven / Steamer CT Express - page 15

       INSTALLATION MANUAL • MN-29805 • 13. MOBILE EQUIPMENT RESTRAINT INSTALLATION Any appliance that is not furnished with a power supply cord but includes a set of casters, stand with casters, or a stacked configuration must be installed with a tether. Adequate means must be provided to ...

  • Alto-Shaam Oven / Steamer CT Express - page 16

       INSTALLATION MANUAL • MN-29805 • 14. INSTALLATION WATER QUALITY REQUIREMENT WARNING TO PREVENT WATER PIPES FROM BURSTING, INCOMING WATER SUPPLY SHOULD BE TURNED OFF WHEN THE APPLIANCE IS NOT IN USE. WARNING WATER SUPPLY MUST BE OPEN WHEN CLEANING PROGRAM IS ACTIVATED. VERIFY WATER S ...

  • Alto-Shaam Oven / Steamer CT Express - page 17

       INSTALLATION MANUAL • MN-29805 • 15. INSTALLATION WATER CONNECTIONS WATER SUPPLY & INSTALLATION WATER REQUIREMENTS ONE (1) COLD WATER INLET - DRINKING QUALITY ONE (1) TREATED WATER INLET: 3/4" G LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar REFER TO PUBLISHED SPECIFIC W A TER ...

  • Alto-Shaam Oven / Steamer CT Express - page 18

       INSTALLATION MANUAL • MN-29805 • 16. INSTALLATION OPTIONAL HAND HELD SPRAY HOSE V alve bracket INSTALLATION 1. Two pre-drilled holes with screws in place are located at the lower rear side of the unit (same side as door opening). Remove screws, position valve bracket and attach usin ...

  • Alto-Shaam Oven / Steamer CT Express - page 19

       INSTALLATION MANUAL • MN-29805 • 17. INSTALLATION WATER VALVE WATER DRAINAGE NOTE: THE SHUT-OFF VALVE MUST BE IN THE OPEN POSITION WHEN THE OVEN IS BEING USED. The oven must discharge through an indirect waste pipe by means of an air gap. The drain fitting is supplied with a 1-1/2-i ...

  • Alto-Shaam Oven / Steamer CT Express - page 20

       INSTALLATION MANUAL • MN-29805 • 18. INSTALLATION INDICATOR LIGHT If the indicator light does not illuminate, the filters may be missing or not properly aligned. Check them for proper positioning. Ventless hood and oven will not operate unless the hood is closed properly. VENTLESS H ...

  • Alto-Shaam Oven / Steamer CT Express - page 21

       INSTALLATION MANUAL • MN-29805 • 19. INSTALLATION VENTLESS HOOD MODEL TOP EXHAUST VENT 1. Charcoal Filter: The charcoal filter should be inspected for contaminant's on a regular basis. Replacement must be made at a minimum of three month intervals — more often if heavy contam ...

  • Alto-Shaam Oven / Steamer CT Express - page 22

    ...

  • Alto-Shaam Oven / Steamer CT Express - page 23

       INSTALLATION MANUAL • MN-29805 • 21. INSTALLATION CT EXPRESS™ CHECKLIST Use this list as a nal check of oven installation conformance. Damage directly attributed to improper set up, installation, or cleaning can invalidate warranty claims. CLEARANCES: Left: 4" (152mm) — ...

  • Alto-Shaam Oven / Steamer CT Express - page 24

    ...

  • Alto-Shaam Oven / Steamer CT Express - page 25

       INSTALLATION MANUAL • MN-29805 • 23. continued on next page This section is provided for the assistance of qualified technicians only and is not intended for use by untrained or unauthorized service personnel. If your Alto-Shaam ® unit is not operating properly , check the followin ...

  • Alto-Shaam Oven / Steamer CT Express - page 26

       INSTALLATION MANUAL • MN-29805 • 24. continued on next page Error Code Error Call Out in Display Description of Error Possible Cause E13    ...

  • Alto-Shaam Oven / Steamer CT Express - page 27

       INSTALLATION MANUAL • MN-29805 • 25. ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E34   Water level in steam generator does not drop during cleanin ...

  • Alto-Shaam Oven / Steamer CT Express - page 28

       INSTALLATION MANUAL • MN-29805 • 26. ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E57  During rinse no water   solenoid valve ...

  • Alto-Shaam Oven / Steamer CT Express - page 29

       INSTALLATION MANUAL • MN-29805 • 27. ERROR CODES When the oven malfunctions, an error code will appear in the display . PRESS THE ST AR T ICON TO ACKNOWLEDGE THE ERROR. The icons that begin to flash repr esent operational modes that are still usable. When the oven fault is corrected ...

  • Alto-Shaam Oven / Steamer CT Express - page 30

       INSTALLATION MANUAL • MN-29805 • 28. ORIGINAL EQUIPMENT LIMITED WARRANTY Alto-Shaam, Inc. warrants to the original purchaser that any original part that is found to be defective in material or workmanship will, at Alto-Shaam’s option, subject to provisions hereinafter stated, be r ...

  • Alto-Shaam Oven / Steamer CT Express - page 31

    TRANSPORTATION DAMAGE AND CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...

Manufacturer Alto-Shaam Category Oven

Documents that we receive from a manufacturer of a Alto-Shaam Oven / Steamer CT Express can be divided into several groups. They are, among others:
- Alto-Shaam technical drawings
- Oven / Steamer CT Express manuals
- Alto-Shaam product data sheets
- information booklets
- or energy labels Alto-Shaam Oven / Steamer CT Express
All of them are important, but the most important information from the point of view of use of the device are in the user manual Alto-Shaam Oven / Steamer CT Express.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Alto-Shaam Oven / Steamer CT Express, service manual, brief instructions and user manuals Alto-Shaam Oven / Steamer CT Express. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Alto-Shaam Oven / Steamer CT Express.

Similar manuals

A complete manual for the device Alto-Shaam Oven / Steamer CT Express, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Alto-Shaam Oven / Steamer CT Express by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Alto-Shaam Oven / Steamer CT Express.

A complete Alto-Shaam manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Alto-Shaam Oven / Steamer CT Express - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Alto-Shaam Oven / Steamer CT Express, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Alto-Shaam Oven / Steamer CT Express, that we can find in the current document
3. Tips how to use the basic functions of the device Alto-Shaam Oven / Steamer CT Express - which should help us in our first steps of using Alto-Shaam Oven / Steamer CT Express
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Alto-Shaam Oven / Steamer CT Express
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Alto-Shaam Oven / Steamer CT Express in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Alto-Shaam Oven / Steamer CT Express?

Use the form below

If you did not solve your problem by using a manual Alto-Shaam Oven / Steamer CT Express, ask a question using the form below. If a user had a similar problem with Alto-Shaam Oven / Steamer CT Express it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)