English dropdown-ico

Manual Weber 43720

50 pages 3.07 mb
Download

Go to site of 50

Summary
  • Weber 43720 - page 1

    SUMMIT ®  W ARNING: Follow all leak-c heck procedures carefull y in this manual prior to barbecue operation. Do this e ven if the barbecue was dealer -assembled. NO TICE T O INST ALLER: These instructions must be left with the o wner and the owner should keep them f or future use . THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONL Y .  W AR ...

  • Weber 43720 - page 2

    A-2  Dangers &  W arnings  D ANGER Failure to f ollow the Danger s, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to pr oper ty .  W ARNINGS  Do not store a spare or disconnected liquid pr opane cylinder under or near this barbe ...

  • Weber 43720 - page 3

    A-3 Contents Danger & W arnings .................................................................................. A-2 W arranty .................................................................................................. A-4 General Instructions ................................................................................. A-5 Grillin ...

  • Weber 43720 - page 4

    A-4 W eber-Stephen Products Co . (W eber) hereby warr ants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of def ects in material and workmanship from the date of purchase as f ollows: when assembled and oper ated in accordance with the printed instr uctions accompanying it. W eber may require reasonab le proof of your da ...

  • Weber 43720 - page 5

    A-5 Gener al Instructions Y our W eber ® gas barbecue is a por table outdoor cooking appliance. With the Weber ® gas barbecue y ou can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer ® Bars produce that “outdoor” flav or in the f ood. The W eber ® g ...

  • Weber 43720 - page 6

    A-6 Gener al Instructions Grilling Methods NO TE: If grill looses heat while cooking refer to the tr oubleshooting section of this manual.  W ARNING: Do not move the W eber ® gas barbecue when operating or while barbecue is hot. Y ou can adjust the Left and Right b ur ners in each b ur ner set as desired. The control settings are High (H), Medi ...

  • Weber 43720 - page 7

    A-7 Summit ® Silv er B Exploded V iew 5 43 1 2 Summit ® Silv er B LP 012903 7 12 13 14 16 22 23 25 26 27 28 29 30 31 33 38 39 40 41 48 52 53 54 56 63 64 65 67 42 21 4 8 10 15 17 18 19 24 32 34 51 11 9 57 69 46 47 50 3 35 36 6 58 20 70 66 71 59 60 61 62 55 72 45 44 37 68 49 ...

  • Weber 43720 - page 8

    A-8 Summit ® Silv er B Exploded V ie w List 1. Hinge Pin 2. Ther mometer Hardware 3. Ther mometer Bez el 4. W ar m-Up ™ Bask et 5. 12 inch Cooking Grate 6. Left Fla vorizer ® Bar Assemb ly 7. Cookbo x Assembly Hardw are 8. 1/4 - 20 He x Nut 9. Electrode Assembly 10. Crossov er ® T ube 11. Left Bur ner T ube 12. 1/4 - 20 x 1/2 inch Scre w 13. M ...

  • Weber 43720 - page 9

    A-9 Summit ® Gold B Exploded V iew 5 44 1 2 Summit ® Gold B LP 012903 7 13 14 15 17 23 24 26 27 28 29 30 31 32 34 39 40 41 42 45 50 53 54 55 56 57 59 64 65 66 67 68 69 70 72 43 22 4 8 10 16 19 20 21 25 33 35 49 52 58 11 9 60 63 71 63 47 46 48 51 3 36 37 6 73 12 18 61 38 ...

  • Weber 43720 - page 10

    A-10 Summit ® Gold B Exploded V ie w List 1. Hinge Pin 2. Ther mometer Hardware 3. Ther mometer Bez el 4. W ar m-Up ™ Bask et 5. 12 inch Cooking Grate 6. Left Fla vorizer ® Bar Assemb ly 7. Cookbo x Assembly Hardw are 8. 1/4 - 20 inch He x Nut 9. Electrode Assembly 10. Crossov er ® T ube 11. Left Bur ner T ube 12. Right Burner T ube 13. 1/4 - ...

  • Weber 43720 - page 11

    A-11 Summit ® Silv er B P arts List Lid - 1 Cookbo x - 1 Left F rame Assemb ly - 1 Right F rame Assembly - 1 Side T ab le - 1 Bottom Shelf - 1 Rear P anel - 1 Left Door - 1 Right Door - 1 W ar ming Rac k - 1 W ar m-Up ™ Rac k - 1 Rear F rame Rail - 1 F ront F rame Rail - 1 Side Bur ner - 1 ...

  • Weber 43720 - page 12

    A-12 LP T ank - 1 Catch-P an Holder - 1 Catch-P an - 1 Disposable Drip P ans - 2 7/16 inch Wrench - 1 Flav or izor ® Bars - 2 Sets Stainless Steel Cooking Grates - 2 Bottom T r ay - 1 Summit ® Silv er B P arts List 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Plastic Washer - 1 Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 i ...

  • Weber 43720 - page 13

    A-13 Summit ® Gold B P arts List Lid - 1 Cookbo x - 1 Left F rame Assemb ly - 1 Right F rame Assembly - 1 Side T ab le - 1 Bottom Shelf - 1 Rear P anel - 1 Left Door - 1 Right Door - 1 W ar ming Rac k - 1 W ar m-Up ™ Rac k - 1 Rear F rame Rail - 1 F ront F rame Rail - 1 Side Bur ner - 1 ...

  • Weber 43720 - page 14

    A-14 LP T ank - 1 Catch-P an Holder - 1 Catch-P an - 1 Disposable Drip P ans - 2 7/16 inch Wrench - 1 Flav or izor ® Bars - 2 Sets Stainless Steel Cooking Grates - 3 Bottom T r ay - 1 Summit ® Gold B P arts List 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Plastic Washer - 1 Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch ...

  • Weber 43720 - page 15

    B-a 1 Ba401.c a b c (1) (2) (3) (3)  CA UTION: Bef ore proceeding to the ne xt step check that fr ame rail (2) is on the side with the s wing tables (3). The tab on frame rail (2) m ust be f acing tow ard the wheels. Place corregated from each side of the Cookbo x under the Caster and Wheel F rame Assembly to le vel the frames f or F rame Rail A ...

  • Weber 43720 - page 16

    B-b 2 b a  A TTENTION! Only start these bolts. Do not tighten yet. ...

  • Weber 43720 - page 17

    B-c 3 ...

  • Weber 43720 - page 18

    B-d b c a 1 2 4  A TTENTION! Completely remove both par tially started bolts from top rear frame rail  A TTENTION! Reinstall both bolts thr ough rear panel and into rear frame rail. ...

  • Weber 43720 - page 19

    B-e 5 a (1) (2) (2) (1) (2) (2)  A TTENTION! Remo ve packing tape holding the gas line and brac ket(1). When installing cookbo x route the gas line and brac ket(1) inside the frame rails(2). ...

  • Weber 43720 - page 20

    B-f (1) (2) (3) b 6 ...

  • Weber 43720 - page 21

    B-g 7 (1) (2) (1) (2) c ...

  • Weber 43720 - page 22

    B-h 8 b a Matchlight Holder ...

  • Weber 43720 - page 23

    B-i 9 (1) (2) (3) a b ...

  • Weber 43720 - page 24

    B-j a b a b 10 ...

  • Weber 43720 - page 25

    B - 1 (1) (2) a b (1) B404_LP .b NO TE: Igniter Wire (1) is located up under right side of control panel. 11 ...

  • Weber 43720 - page 26

    B - 2 c d (1) (2)  CA UTION: Hold burner cap (1) down while pushing side burner ignition wire (2) on. ...

  • Weber 43720 - page 27

    B - 3 a b 12 13 14 ...

  • Weber 43720 - page 28

    B - 4 16 15 ...

  • Weber 43720 - page 29

    B - 5 B ...

  • Weber 43720 - page 30

    B - 6 B ...

  • Weber 43720 - page 31

    C-1 Gas Instructions Impor tant LP Cylinder Inf ormation F ailure to follow these D ANGER statements exactly ma y result in a fire causing death or serious injur y .  D ANGER  NEVER store a spare LP Cylinder under or near this barbecue.  NEVER fill the tank bey ond 80% full. Y our W eber ® gas grill is equipped with a cylinder supply syst ...

  • Weber 43720 - page 32

    C-2 Gas Instructions W e utilize v ar ious LP tank manuf acturers. Some of the tanks hav e diff er ing top collar assembles . (The top collar is the metal protective ring around the v alve .) One ser ies of tanks mount with the valv e facing front. The other tanks mount with the valv e facing a wa y from the fuel scale. These types of tanks are ill ...

  • Weber 43720 - page 33

    C-3 Gas Instructions  W ARNING : The gas connections of your Summit ® gas grill have been factory tested. We do ho wever recommend that y ou leak check all gas connections before operating y our Summit ® gas grill. Remove contr ol panel P ar t required: Phillips Screwdriver . Remov e the burner control knobs (1). The screws (2) need to be remo ...

  • Weber 43720 - page 34

    C-4 Gas Instructions Remov e the F ront P anel by sliding the panel up and out of the slots. Chec k for gas leaks  D ANGER Do not use an open flame to chec k for gas leaks. Be sure there are no sparks or open flames in the area while y ou chec k for leaks. Sparks or open flames will result in a fire or explosion, which can cause serious bodil y ...

  • Weber 43720 - page 35

    C-5 Gas Instructions Check: 1) Hose connection. 2) Gas line to manif old connections.  W ARNING: If there is a leak at connection (1, or 2), retighten the fitting with a wrench and rechec k for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn OFF the gas. DO NO T OPERA TE THE GRILL. Contact the Custome ...

  • Weber 43720 - page 36

    C-6 Gas Instructions Reinstall control panel P ar ts required: control panel, screws , and burner control knobs. Place the control panel back onto the control panel brack ets on either side of the front of the cooking bo x. Line up screws with scre w holes on both the control panel and control panel brac kets. Tighten screws . Reinstall burner cont ...

  • Weber 43720 - page 37

    C-7 Gas Instructions Liquid Propane Cylinder The liquid propane cylinder manuf acturer is responsible f or the materials, workmanship and performance of the tank. If the tank has a defect malfunctions , or you ha ve a question regarding the tank, call the tank manuf acturer ’ s customer ser vice center . The phone number is on the warning decal, ...

  • Weber 43720 - page 38

    C-8 Gas Instructions Safe handling tips f or Liquid Propane Gas Cylinders ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas . LP gas is a gas at regular temperatures and pressures . Under moderate pressure, inside a cylinder , LP gas is a liquid. As the pressure is released, the liquid readily v apor izes and become ...

  • Weber 43720 - page 39

    D-1 Oper ating Instructions D404_LP .d Grilling Methods NO TE: If grill looses heat while cooking refer to the tr oubleshooting section of this manual. Y ou can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burner s go out during cooking, turn off all burner s ...

  • Weber 43720 - page 40

    D-2 Oper ating Instructions Indirect cooking The Indirect Method is similar to roasting, b ut with the added benefits of that grilled texture , flav or , and appearance you can ’ t get from an o ven. T o set up f or Indirect cooking, gas burners are lit on either side of the f ood but not directly beneath it. Heat rises, reflects off the lid and ...

  • Weber 43720 - page 41

    D-3 Oper ating Instructions Lighting Summar y lighting instructions are on the control panel.  D ANGER Failure to open the lid while igniting the barbecue’ s burner s, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, ma y result in an explosive flame-up whic h can cause serious bodily injury or death. Crosso ...

  • Weber 43720 - page 42

    D-4 Oper ating Instructions Manual Lighting  D ANGER Failure to open the lid while igniting the barbecue’ s burners, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, may result in an e xplosive flame-up which can cause serious bodil y injury or death. 1) Open the lid. 2) Make sure all burner control knobs are ...

  • Weber 43720 - page 43

    D-5 Oper ating Instructions Side Burner Lighting Instructions  D ANGER F ailure to open the lid while igniting the side b urner , or not waiting 5 minutes to allow the gas to c lear if the side burner does not light, ma y result in an explosive flame-up which can cause serious bodily injury or death. Lighting only the side b urner . 1) Open the ...

  • Weber 43720 - page 44

    D-6 Pr oblem Chec k Cure Burner s burn with a yellow or orange flame, in conjunction with the smell of gas. Inspect W eber ® Insect / Spider screens f or possible instructions. (Blockage of holes .) Clean W eber ® Insect / Spider screens. (See Section “ Annual Maintenance ” ) Burner s do not light. -or - Burners ha ve a small flickering flame ...

  • Weber 43720 - page 45

    D-7 Pr oblem Chec k Cure Side Burner does not light. Flame is low in HIGH position. Push button ignition does not work. Is gas supply off? T ur n supply on. Is the fuel hose bent or kink ed? Straighten hose . Does burner light with a match? If match lights b ur ner , checkigniter (see below). Side Burner maintenance  W ARNING: All gas controls a ...

  • Weber 43720 - page 46

    E-1 Maintenance (1) (1) Main Burner Flame P attern The W eber ® gas barbecue burners hav e been factory set f or the correct air and gas mixture. The correct flame pattern is shown. 1) Bur ner tube 2) Tips occasionally flick er yellow 3) Light blue 4) Dar k b lue If the flames do not appear to be unif or m throughout the burner tube, f ollow the b ...

  • Weber 43720 - page 47

    E-2 Maintenance Replacing Main Burners 1. Y our Summit ® gas grill must be OFF and cool. 2. T ur n gas OFF at source. 3. Disconnect regulator . 4. Remov e cooking grates . 5. Remov e Smoker bo x. 6. Remov e Flav orizer ® bars. 7. T o remov e control panel refer to “Remove the control panel” under “Chec k for Gas Leaks . ” 8. Disconnect al ...

  • Weber 43720 - page 48

    E-3 Maintenance 9. Remov e screws from the manif old assembly: (a) Locate the screws on both sides of the manif old frame. (b) Remov e the screws from manif old frame. 10. Pull manif old assembly out from the manif old frame. (a) (a) (b) (b) (a) (a) (b) (b) ...

  • Weber 43720 - page 49

    E-4 Maintenance (a) (b) (b) 11. Lift and twist the burner assembly slightly , to separate the Crossov er ® tube (a) from the burners (b). 12. Remov e the Crossov er ® tube. 13. Pull the selected burner(s) tube(s) from manif old frame and replace with a ne w burner tube. 14. T o reinstall the manifold assemb ly , re verse steps 7 through 13.  C ...

  • Weber 43720 - page 50

    E-5 Maintenance Cr ossover ® Ignition System Operations If the Crossov er ® ignition system f ails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossov er ® ignition system. • Check that both ignition wires (1,2) are attached properly . • Check that the ...

Manufacturer Weber Category Gas Grill

Documents that we receive from a manufacturer of a Weber 43720 can be divided into several groups. They are, among others:
- Weber technical drawings
- 43720 manuals
- Weber product data sheets
- information booklets
- or energy labels Weber 43720
All of them are important, but the most important information from the point of view of use of the device are in the user manual Weber 43720.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Weber 43720, service manual, brief instructions and user manuals Weber 43720. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Weber 43720.

Similar manuals

A complete manual for the device Weber 43720, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Weber 43720 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Weber 43720.

A complete Weber manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Weber 43720 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Weber 43720, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Weber 43720, that we can find in the current document
3. Tips how to use the basic functions of the device Weber 43720 - which should help us in our first steps of using Weber 43720
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Weber 43720
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Weber 43720 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Weber 43720?

Use the form below

If you did not solve your problem by using a manual Weber 43720, ask a question using the form below. If a user had a similar problem with Weber 43720 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)