English dropdown-ico

Manual Lincoln 1132-000-A

32 pages 0.9 mb
Download

Go to site of 32

Summary
  • Lincoln 1132-000-A - page 1

    1100AdvDigSvc REV: 3/20/08 SERVICE MANUAL (DOMESTIC) IMPINGER ADVANTAGE DIGITAL SERIES MODEL 1116-000-A, 1117-000-A, 1130-000-A, 1131-000-A, 1132-000-A, 1133-000-A WITH PUSH BUTTON CONTROLS Lincoln Foodservice Products, LLC 1111 North Hadley Road Fort Wayne, Indiana 46804 United States of America Phone : (800) 374-3004 U.S. Fax: (888) 790-8193 • ...

  • Lincoln 1132-000-A - page 2

    Impinger II – Advantage Digital Service Manual - Domestic 2 SEQUENCE OF OPERATION IMPINGER II ADVANTAGE SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) MODEL 1116-000-A NAT. GAS 120VAC 60 HZ. 1 PHASE MODEL 1117-000-A LP GAS 120VAC 60 HZ. 1 PHASE POWER SUPPLY Electrical power is supplied to the oven by a three-co nductor cordset. ...

  • Lincoln 1132-000-A - page 3

    Impinger II – Advantage Digital Service Manual - Domestic 3 SEQUENCE OF OPERATION IMPINGER II ADVANTAGE SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) 1130-000-A 208VAC 60 HZ. 1 PHASE 1131-000-A 240VAC 60 HZ. 1 PHASE 1132-000-A 208VAC 60 HZ. 3 PHASE 1133-000-A 240VAC 60 HZ. 3 PHASE POWER SUPPLY Electrical power to be supplied t ...

  • Lincoln 1132-000-A - page 4

    Impinger II – Advantage Digital Service Manual - Domestic 4 SCHEMATIC DIAGRAM MODEL 1116-000-A, 1117-000-A SERIAL NUMBER 2038616 AND ABOVE ...

  • Lincoln 1132-000-A - page 5

    Impinger II – Advantage Digital Service Manual - Domestic 5 SCHEMATIC DIAGRAM MODEL 1130-000-A, 1131-000-A SERIAL NUMBER 2038616 AND ABOVE ...

  • Lincoln 1132-000-A - page 6

    Impinger II – Advantage Digital Service Manual - Domestic 6 SCHEMATIC DIAGRAM MODEL 1132-000-A, 1133-000-A SERIAL NUMBER 2038616 AND ABOVE ...

  • Lincoln 1132-000-A - page 7

    Impinger II – Advantage Digital Service Manual - Domestic 7 TROUBLESHOOTING GUIDE GAS OVENS SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) MODEL 1116-000-A NAT. GAS 120VAC 60 HZ. MODEL 1117-000-A LP GAS 120VAC 60 HZ. SYMPTOM POSSIBLE CAUSE EVALUATION Oven fan will not run Incoming power sup ply Check circuit breakers, reset if ...

  • Lincoln 1132-000-A - page 8

    Impinger II – Advantage Digital Service Manual - Domestic 8 Main fan If not operating, refer to “Oven fan will not run”. Centrifugal switch of main fan motor Check for 120VAC at wire #5 (inp ut to centrifugal switch, located at 6-pin connecto r in ra ceway near the main fan motor) to neutral. If no voltage is present, trace wiring back to the ...

  • Lincoln 1132-000-A - page 9

    Impinger II – Advantage Digital Service Manual - Domestic 9 valves, the valve should open. Check for gas pressure at the manifold tap located just before the burner. If there is no pressure, check the incoming gas supply to be sure all manu al valves are open and flexible gas hose i s properly connected. If gas is present, and the gas control val ...

  • Lincoln 1132-000-A - page 10

    Impinger II – Advantage Digital Service Manual - Domestic 10 voltage output at the oven control, check the read- out on the control. If the control reads “P ROBE FAIL”, this indicates that the thermocouple has failed or become disconnected from the oven control. Thermocouple Check to be sure that the thermocouple is securely connected to the ...

  • Lincoln 1132-000-A - page 11

    Impinger II – Advantage Digital Service Manual - Domestic 11 wiring back to the oven power relay. If voltage is present, check for 24 VAC at the transformer secondary. If there is primary voltage but no secondary voltage, replace control tran sformer. Conveyor motor Check for 120 VAC supply to the convey or motor at wire #14 to neutral. If no vol ...

  • Lincoln 1132-000-A - page 12

    Impinger II – Advantage Digital Service Manual - Domestic 12 TROUBLESHOOTING GUIDE ELECTRIC OVENS 1130-000-A 208VAC 60 HZ. 1 PHASE 1131-000-A 240VAC 60 HZ. 1 PHASE 1132-000-A 208VAC 60 HZ. 3 PHASE 1133-000-A 240VAC 60 HZ. 3 PHASE SYMPTOM POSSIBLE CAUSE EVALUATION Oven fan will not run Incoming power supply Check circuit breakers. Reset if requi r ...

  • Lincoln 1132-000-A - page 13

    Impinger II – Advantage Digital Service Manual - Domestic 13 oven cavity thermostat and rete st. If thermostat will not hold for maximum oven temperature, and oven is not exceeding temperature setting, check for prope r location of capillary bulb in its spring holder. If the capillary checks okay, replace the hi -limit thermostat. Control transfo ...

  • Lincoln 1132-000-A - page 14

    Impinger II – Advantage Digital Service Manual - Domestic 14 activate, replace the mercury contactor. Also check each contactor for hi gh voltage in put and output. Heating element(s) Check the Amp draw on each p ower le g for proper load. Check the sp ecification pla te for rating information. If the amp draw is high or low, check the individual ...

  • Lincoln 1132-000-A - page 15

    Impinger II – Advantage Digital Service Manual - Domestic 15 discharge before testing. Switch, conveyor reversing Check co ntinuity between swit ch terminals. Replace switch as needed. Oven control If there is supply voltage to the motor, and the motor, capacitor, and reversing switch check good, replace the oven control. Conveyor motor runs, but ...

  • Lincoln 1132-000-A - page 16

    Impinger II – Advantage Digital Service Manual - Domestic 16 REMOVAL, INSTALLATION AND ADJUSTM ENTS IMPINGER II ADVANTAGE SERIES CAUTION BEFORE REMOVING OR INSTALLING ANY COMPONENT IN THE IMPINGER OVEN BE SURE TO DISCONNECT EL ECTRICAL POWER AND GAS SUPPLY. MAIN FAN – REPLACEMENT A. Shut off power at main breaker. B. Remove motor cover from bac ...

  • Lincoln 1132-000-A - page 17

    Impinger II – Advantage Digital Service Manual - Domestic 17 FUSE HOLDER – REPLACEMENT A. Shut off power at main breaker. B. Remove control box cover and front pa nel. C. Remove wires from fuse h o lder and ma rk for reassembly. D. Remove mounting screws or mounting n ut on fuse hol der and remove fuse holde r. E. Reassemble in reverse order an ...

  • Lincoln 1132-000-A - page 18

    Impinger II – Advantage Digital Service Manual - Domestic 18 TRANSFORMER, BURNER – REPLACEMENT A. Shut off power at main breaker. B. Remove control panel top and front cover. C. Remove all wires from transformer and mark for re assembly. D. Remove two mounting screws from tr ansformer base and re move transformer. E. Reassemble in reverse order ...

  • Lincoln 1132-000-A - page 19

    Impinger II – Advantage Digital Service Manual - Domestic 19 BURNER CONTROL – REPLACEMENT A. Shut off power at main breaker. B. Remove control panel top and front cover. C. Remove wires from control and mark for reassembly. D. Remove mounting screws from control and rem ove burner control. E. Reassemble in reverse order and check system operati ...

  • Lincoln 1132-000-A - page 20

    Impinger II – Advantage Digital Service Manual - Domestic 20 BYPASS ORIFICE – REPLACEMENT A. Shut off power at main breaker. B. Shut off gas supply to the oven and di sconnect the flexible gas line to oven. C. Remove control panel top and front cover. D. Disconnect bypass tube from gas valve. E. Remove bypass orifice from gas valve. F. Reassemb ...

  • Lincoln 1132-000-A - page 21

    Impinger II – Advantage Digital Service Manual - Domestic 21 AIR PRESSURE SWITCH – REPLACEMENT A. Shut off power at main breaker. B. Remove control panel top and front cover. C. Disconnect wiring from air pre ssure switch and mark for reassembly. D. Disconnect air tube from air pre ssure switch. E. Remove two mounting screws and remove air pres ...

  • Lincoln 1132-000-A - page 22

    Impinger II – Advantage Digital Service Manual - Domestic 22 IMPINGER II ADVANTAGE GENERAL VIEW LETTER PART NUMBER DESCRIPTION A 369390 Caster 4” w/ mounting pl ate B 369502 Bottom finger cover C Columnating plate, see Installation & Operations manual D 370010 Bottom finger housing E 369504 Top finger housin g F Columnating plate, see Insta ...

  • Lincoln 1132-000-A - page 23

    Impinger II – Advantage Digital Service Manual - Domestic 23 ...

  • Lincoln 1132-000-A - page 24

    Impinger II – Advantage Digital Service Manual - Domestic 24 CONTROL BOX MODEL 1116-000-A, 1117-000-A SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) LETTER PART NUMBER DESCRIPTION A 369124 Cooling fan B 369537 Power cord C 370362 Thermocouple type “K” D 370378 Conveyor Motor (S/N 2052 462 & Below) 370675 Conveyor Motor ...

  • Lincoln 1132-000-A - page 25

    Impinger II – Advantage Digital Service Manual - Domestic 25 ...

  • Lincoln 1132-000-A - page 26

    Impinger II – Advantage Digital Service Manual - Domestic 26 CONTROL BOX MODEL 1130-000-A, 1131-000-A, 1132-000-A, 1132-000-A SERIAL NUMBER 2038616 AND ABOVE (OVENS WITH PUSH BUTTON CONTROLS) LETTER PART NUMBER DESCRIPTION A 370108 Control box top B 370355 Control, oven C 369432 On/off switch D 370354 Facia, Label E 370107 Side panel F 370067 369 ...

  • Lincoln 1132-000-A - page 27

    Impinger II – Advantage Digital Service Manual - Domestic 27 ...

  • Lincoln 1132-000-A - page 28

    Impinger II – Advantage Digital Service Manual - Domestic 28 OVEN BACK ASSEMBLY LETTER PART NUMBER DESCRIPTION A 369182 Fan B 369899 Fan shroud C 369655 Stand off D Heating element 369183 208 Volt 369184 240 Volt E Rear wall 369976 Gas ovens 369549 Electric ovens F 369581 Motor mount G Motor 369539 Gas ovens (120VAC) 369181 Electri c ovens (208/2 ...

  • Lincoln 1132-000-A - page 29

    Impinger II – Advantage Digital Service Manual - Domestic 29 ...

  • Lincoln 1132-000-A - page 30

    Impinger II – Advantage Digital Service Manual - Domestic 30 CONVEYOR / DOOR LETTER PART NUMBER DESCRIPTION A 369611 Cou pler (S/N 2052462 & Below) B 369664 Cou pling center (S/N 2052 462 & Below) C 369269 Ball plunge r (S/N 2052462 & Below) D 370116 Set screw (S/N 2052462 & Below) Not Shown 370671 Drive Coupli ng (S/N 2052463 &am ...

  • Lincoln 1132-000-A - page 31

    Impinger II – Advantage Digital Service Manual - Domestic 31 ...

  • Lincoln 1132-000-A - page 32

    Impinger II – Advantage Digital Service Manual - Domestic 32 ...

Manufacturer Lincoln Category Oven

Documents that we receive from a manufacturer of a Lincoln 1132-000-A can be divided into several groups. They are, among others:
- Lincoln technical drawings
- 1132-000-A manuals
- Lincoln product data sheets
- information booklets
- or energy labels Lincoln 1132-000-A
All of them are important, but the most important information from the point of view of use of the device are in the user manual Lincoln 1132-000-A.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Lincoln 1132-000-A, service manual, brief instructions and user manuals Lincoln 1132-000-A. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Lincoln 1132-000-A.

Similar manuals

A complete manual for the device Lincoln 1132-000-A, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Lincoln 1132-000-A by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Lincoln 1132-000-A.

A complete Lincoln manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Lincoln 1132-000-A - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Lincoln 1132-000-A, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Lincoln 1132-000-A, that we can find in the current document
3. Tips how to use the basic functions of the device Lincoln 1132-000-A - which should help us in our first steps of using Lincoln 1132-000-A
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Lincoln 1132-000-A
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Lincoln 1132-000-A in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Lincoln 1132-000-A?

Use the form below

If you did not solve your problem by using a manual Lincoln 1132-000-A, ask a question using the form below. If a user had a similar problem with Lincoln 1132-000-A it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)